Alliance Laundry Systems 802702R4 Guida

Installation/Operation

www.comlaundry.com

Stacked

Washer and Dryer

Metered

Electric and Gas Models

SWD447C

Part No. 802702R4

October 2009

Keep These Instructions for Future Reference.

(If this machine changes ownership, this manual must accompany machine.)

Para bajar una copia de estas instrucciones

en español, visite www.comlaundry.com.

802702 1

IMPORTANT: Purchaser must consult the local gas supplier for suggested instructions to be followed if the

dryer user smells gas. The gas utility instructions plus the SAFETY and WARNING note directly above

must be posted in a prominent location near the dryer for customer use.

The following information applies to the state of Massachusetts, USA.

This appliance can only be installed by a Massachusetts licensed plumber or gas fitter.

This appliance must be installed with a 36 inch (91 cm) long flexible gas connector.

A “T-Handle” type gas shut-off valve must be installed in the gas supply line to this appliance.

This appliance must not be installed in a bedroom or bathroom.

• Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or

any other appliance.

• WHAT TO DO IF YOU SMELL GAS:

– Do not try to light any appliance.

– Do not touch any electrical switch; do not use any phone in your building.

– Clear the room, building or area of all occupants.

– Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s

instructions.

– If you cannot reach your gas supplier, call the fire department.

• Installation and service must be performed by a qualified installer, service agency or the gas

supplier. W052

FOR YOUR SAFETY, the information in this manual must be followed to minimize the risk

of fire or explosion or to prevent property damage, personal injury or death. W033

WARNING

Installation of unit must be performed by a qualified installer.

Install clothes dryer according to manufacturer’s instructions and local codes.

DO NOT install a clothes dryer with flexible plastic venting materials. If flexible metal (foil

type) duct is installed, it must be of a specific type identified by the appliance manufacturer

as suitable for use with clothes dryers. Refer to section on connecting exhaust system.

Flexible venting materials are known to collapse, be easily crushed, and trap lint. These

conditions will obstruct clothes dryer airflow and increase the risk of fire. W729R1

WARNING

FOR YOUR SAFETY

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or

any other appliance. W053

means without the expressed written consent of the publisher.

802702

Table of

Contents

Safety Information.............................................................................. 4

Explanation of Safety Messages........................................................... 4

Important Safety Instructions ............................................................... 4

Installation........................................................................................... 7

Before You Start................................................................................... 9

Supplies............................................................................................ 9

Installing the Unit................................................................................. 10

Step 1: Position Unit Near Installation Area.................................... 10

Step 2: Connect Fill Hoses............................................................... 10

Step 3: (Non-Gravity Drain Models Only) Connect

Drain Hose to Drain Receptacle..................................................... 12

Step 4: (Gravity Drain Models Only) Connect

Drain Outlet to Drain System......................................................... 12

Step 5: (Gas Dryer Only) Connect Gas Supply Pipe....................... 13

Step 6: (Electric Dryer Only) Connect Electrical Plug.................... 14

Step 7: Connect Dryer Exhaust System........................................... 20

Step 8: Position and Level the Unit ................................................. 25

Step 9: (Washer Only) Remove the Shock Sleeves and

Shipping Brace ............................................................................... 27

Step 10: Wipe Out Inside of Washer Drum and Dryer Drum.......... 27

Step 11: Plug In the Washer and Dryer ........................................... 28

Step 12: Recheck steps 1-11............................................................ 30

Step 13: Check Heat Source ............................................................ 30

Operation............................................................................................. 32

Operation Instructions for MDC Washers............................................ 32

Step 1: Load Laundry....................................................................... 32

Step 2: Close Loading Door............................................................. 32

Step 3: Add Laundry Supplies......................................................... 33

Step 4: Determine Proper Controls for Washer............................... 33

Step 5: Set Fabric Selector and Wash Temperature

(Cycles Vary by Model)................................................................. 33

Step 6: Insert Coin(s) or Card.......................................................... 34

Step 7: Start Washer......................................................................... 34

Indicator Lights................................................................................ 34

Operation Instructions for NetMaster Washers.................................... 35

Step 1: Load Laundry....................................................................... 35

Step 2: Close Loading Door............................................................. 35

Step 3: Add Laundry Supplies......................................................... 35

Step 4: Determine Proper Controls for Washer............................... 36

Step 5: Set Fabric Selector............................................................... 36

Step 6: Set Wash Temperature......................................................... 36

Step 7: Insert Coin(s) or Card.......................................................... 36

Step 8: Start Washer......................................................................... 37

Indicator Lights................................................................................ 37

Operation Instructions for MDC Dryers............................................... 38

Step 1: Clean Lint Filter................................................................... 38

Step 2: Load Laundry....................................................................... 38

Step 3: Close Loading Door............................................................. 38

802702 3

Step 4: Determine Proper Controls for Dryer.................................. 39

Step 5: Set Fabric Selector............................................................... 39

Step 6: Insert Coin(s) or Card.......................................................... 39

Step 7: Start Dryer ........................................................................... 40

Indicator Lights................................................................................ 40

Operation Instructions for NetMaster Dryers....................................... 41

Step 1: Clean Lint Filter................................................................... 41

Step 2: Load Laundry....................................................................... 41

Step 3: Close Loading Door............................................................. 41

Step 4: Determine Proper Controls for Dryer.................................. 42

Step 5: Set Fabric Selector............................................................... 42

Step 6: Insert Coin(s) or Card.......................................................... 42

Step 7: Start Dryer ........................................................................... 43

Indicator Lights................................................................................ 43

Maintenance........................................................................................ 44

User-Maintenance Instructions............................................................. 44

Lubrication....................................................................................... 44

Cold Weather Care........................................................................... 44

Vacations and Extended Non-Use................................................... 44

Care of Your Washer....................................................................... 44

Care of Your Dryer.......................................................................... 45

Reinstallation of Shipping Materials ............................................... 46

Motor Overload Protector..................................................................... 46

For Energy Conservation...................................................................... 46

Troubleshooting.................................................................................. 47

Contact Information........................................................................... 49

Installer Checklist............................................................... Back Cover

4802702

Safety Information

Explanation of Safety Messages

Throughout this manual and on machine decals, you

will find precautionary statements (“DANGER,”

“WARNING,” and “CAUTION”) followed by specific

instructions. These precautions are intended for the

personal safety of the operator, user, servicer, and

those maintaining the machine.

Additional precautionary statements (“IMPORTANT”

and “NOTE”) are followed by specific instructions.

IMPORTANT: The word “IMPORTANT” is used

to inform the reader of specific procedures where

minor machine damage will occur if the procedure

is not followed.

NOTE: The word “NOTE” is used to communicate

installation, operation, maintenance or servicing

information that is important but not hazard

related.

Important Safety Instructions

Save These Instructions

1. Read all instructions before using the unit.

2. Refer to the GROUNDING INSTRUCTIONS in

the INSTALLATION manual for the proper

grounding of the unit.

3. Do not wash or dry articles that have been

previously cleaned in, washed in, soaked in, or

spotted with gasoline, dry-cleaning solvents, or

other flammable or explosive substances as they

give off vapors that could ignite or explode.

4. Under certain conditions, hydrogen gas may be

produced in a hot water system that has not been

used for two weeks or more. HYDROGEN GAS

IS EXPLOSIVE. If the hot water system has not

been used for such a period, before using a

washing machine or combination washer-dryer,

turn on all hot water faucets and let the water

flow from each for several minutes. This will

release any accumulated hydrogen gas. The gas

is flammable, do not smoke or use an open flame

during this time.

5. Do not allow children to play on or in the unit.

Close supervision of children is necessary when

the unit is used near children. This is a safety rule

for all appliances.

6. Before the unit is removed from service or

discarded, remove the doors to the washing and

drying compartments.

Indicates an imminently hazardous

situation that, if not avoided, will cause

severe personal injury or death.

DANGER

Indicates a hazardous situation that, if not

avoided, could cause severe personal

injury or death.

WARNING

Indicates a hazardous situation that, if not

avoided, may cause minor or moderate

personal injury or property damage.

CAUTION

To reduce the risk of fire, electric shock,

or injury to persons when using your

stacked washer and dryer, follow these

basic precautions. W287

WARNING

Safety Information

802702

7. Do not reach into the washer or dryer if the

cylinders are revolving.

8. Do not install or store the unit where it will be

exposed to water and/or weather.

9. Do not tamper with the controls.

10. Do not repair or replace any part of the unit, or

attempt any servicing unless specifically

recommended in the User-Maintenance

instructions or in published user-repair

instructions that you understand and have the

skills to carry out.

11. Do not add gasoline, dry-cleaning solvents, or

other flammable or explosive substances to the

wash water. These substances give off vapors that

could ignite or explode.

12. Do not use fabric softeners or products to

eliminate static unless recommended by the

manufacturer of the fabric softener or product.

13. To reduce the risk of an electric shock or fire, DO

NOT use an adapter to connect the unit to the

electrical power source.

14. To reduce the risk of fire, DO NOT DRY plastics

or articles containing foam rubber or similarly

textured rubberlike materials.

15. ALWAYS clean the lint filter after every load. A

layer of lint in the filter reduces drying efficiency

and prolongs drying time.

16. Keep area around the exhaust opening and

adjacent surrounding area free from the

accumulation of lint, dust and dirt.

17. The interior of the dryer and the exhaust duct

should be cleaned periodically by qualified

service personnel.

18. If not installed, operated and maintained in

accordance with the manufacturer’s instructions

or if there is damage to or mishandling of this

product’s components, use of this product could

expose you to substances in the fuel or from fuel

combustion which can cause death or serious

illness and which are known to the State of

California to cause cancer, birth defects or other

reproductive harm.

19. Washer and dryer will not operate with the

loading door open. DO NOT bypass the door

safety switches by permitting the washer or dryer

to operate with the doors open. The washer and

dryer will stop tumbling when the doors are

opened. Do not use the washer or dryer if they do

not stop tumbling when the doors are opened or

start tumbling without pressing the START

mechanisms. Remove the unit from use and call

the service person.

20. Do not put articles soiled with vegetable or

cooking oil in the washer or dryer. Due to the oil,

the fabric may catch on fire by itself.

21. To reduce the risk of fire, DO NOT put clothes

which have traces of any flammable substances

such as machine oil, flammable chemicals,

thinner, etc., or anything containing wax or

chemicals such as in mops and cleaning cloths, or

anything dry-cleaned at home with a dry-

cleaning solvent in the dryer.

22. Use your washer only for its intended purpose,

washing clothes.

23. Use the dryer only for its intended purpose,

drying clothes.

24. Always disconnect the electrical power to the

washer and dryer before attempting service to

either unit. Disconnect the power cords by

grasping the plug, not the cord.

25. If the supply cord is damaged, it must be replaced

by a special cord or assembly available from the

manufacturer or its service agent.

26. Install this unit according to the

INSTALLATION INSTRUCTIONS. All

connections for electrical power, grounding and

gas supply must comply with local codes and be

made by licensed personnel when required. Do

not do it yourself unless you know how!

27. Keep your unit in good condition. Bumping or

dropping the unit can damage safety features. If

this occurs, have your unit checked by a qualified

service person.

Safety Information

802702

28. Remove laundry immediately after the dryer

stops.

29. Always read and follow manufacturer’s

instructions on packages of laundry and cleaning

aids. Heed all warnings or precautions. To reduce

the risk of poisoning or chemical burns, keep

them out of reach of children at all times

(preferably in a locked cabinet).

30. Do not tumble fiberglass curtains and draperies

unless the label says it can be done. If they are

dried, wipe out the cylinder with a damp cloth to

remove particles of fiberglass.

31. Be sure water connections have a shut-off valve

and that fill hose connections are tight. CLOSE

the shut-off valves at the end of each wash day.

32. ALWAYS follow the fabric care instructions

supplied by the garment manufacturer.

33. Never operate the unit with any guards and/or

panels removed.

34. DO NOT operate the unit with missing or broken

parts.

35. DO NOT bypass any safety devices.

36. Failure to install, maintain, and/or operate this

machine according to the manufacturer’s

instructions may result in conditions which can

produce bodily injury and/or property damage.

37. Do not operate washer and dryer if the units have

been separated.

IMPORTANT: Solvent vapors from dry-cleaning

machines create acids when drawn through the

heater of the drying unit. These acids are corrosive

to the dryer as well as to the laundry load being

dried. Be sure make-up air is free of solvent vapors.

IMPORTANT: Have your unit installed properly.

Don’t do it yourself unless you know how!

NOTE: The WARNING and IMPORTANT

SAFETY INSTRUCTIONS appearing in this

manual are not meant to cover all possible

conditions and situations that may occur. Common

sense, caution and care must be exercised when

installing, maintaining, or operating the dryer.

Always contact your dealer, distributor, service agent

or the manufacturer about any problems or conditions

you do not understand.

802702 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Installation

SWD907N

*With leveling legs turned into base.

SWD908N

*With leveling legs turned into base.

13/8 in. NPT Gas Connection

SWD907N

23.5 in.

2.0 in.

(5.1 cm)

7.0 in.

(17.8

*13.1 in.

(33.3 cm)

28 in.

(71.1 cm)

*29.6 in. (75.1

*31.1 in. (79

*76.5 in. (194.3

*45.8 in. (116.3

15.4 in.

(39.1 cm

26.9 in.

(68.3

2.0 in.

(5.1

ELECTRIC DRYERS

8.0 in.

(20.3 cm

*36.9 in. (93.8

*14.5 in

24.0 in.

MODELS EQUIPPED WITH DRAIN HOSE

*64.75 in. (164.47

*55.75 in. (141.6 cm)

1.5 in.

(3.81

SWD908N

23.5 in.

2.0 in.

(5.1 cm)

7.0 in.

*13.1 in.

(33.3 cm)

28 in.

(71.1

*29.6 in. (75.1

*31.1 in. (79

*76.5 in. (194.3

*45.8 in. (116.3

15.4 in.

(39.1

26.9 in.

(68.3 cm)

2.0 in.

(5.1

2.3 in.

GAS DRYERS

8.0 in.

(20.3

*44.1 in. (112

*36.9 in. (93.8

*14.5

in.

24.0 in.

MODELS EQUIPPED WITH DRAIN HOSE

*64.75 in. (164.47

*55.75 in. (141.6 cm)

1.5 in.

(3.81

Installation

802702

NOTE: Side and rear exhaust openings are 4 inch

(10.2 cm) ducting. Gas models cannot be vented out

left side of cabinet because of burner housing.

IMPORTANT: The dryer should have sufficient

clearance around it for needed ventilation and for

the ease of installation and servicing. For

maximum drying performance, we recommend

that more clearance be allowed around the dryer

than the clearances that are listed throughout this

manual.

SWD909N

*With leveling legs turned into base.

13/8 in. NPT Gas Connection

21.5 in. (3.81 cm) Inside Diameter

1.86 in. (4.72 cm) Outside Diameter

SWD909N

23.5 in.

2.0 in.

(5.1 cm)

7.0 in.

*13.1 in.

(33.3 cm)

28 in.

(71.1

*29.6 in. (75.1

*31.1 in. (79

*76.5 in. (194.3

*45.8 in. (116.3

15.4 in.

(39.1

26.9 in.

(68.3

2.3 in.

GAS DRYERS

8.0 in.

(20.3

*44.1 in. (112

*36.9 in. (93.8

*14.5 in.

(36.8

24.0 in.

MODELS WITH GRAVITY DRAIN

*4.1 in.

(10.41

4.2 in.

(10.67 2

*64.75 in. (164.47

*55.75 in. (141.6 cm)

1.5 in.

(3.81

Questo manuale è adatto per i seguenti modelli

Indice

Altri manuali Alliance Laundry Systems Lavatrice e asciugatrice

Alliance Laundry Systems

Alliance Laundry Systems SWD455C SVG Guida

Alliance Laundry Systems

Alliance Laundry Systems SWD447C Guida

Alliance Laundry Systems

Alliance Laundry Systems LTS97A*N Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems CI 1650/325 Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems 802714R4 Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems LTS84B*H Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems SWD543C Guida

Alliance Laundry Systems

Alliance Laundry Systems BFNBCASG113TN01 Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems IAE180J Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems Cissell CTS97AWN Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems 801504R1 Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems SWD441C Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems SV6000WG Guida

Alliance Laundry Systems

Alliance Laundry Systems SWD444C Guida

Alliance Laundry Systems

Alliance Laundry Systems H242I Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems ATE50FGP171TW01 Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems 802957R3 Guida

Alliance Laundry Systems

Alliance Laundry Systems STEA17*H Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems CP040PMN1 Manuale del proprietario

Alliance Laundry Systems

Alliance Laundry Systems BT3LLFSG401UN01 Istruzioni operative

Alliance Laundry Systems

Alliance Laundry Systems DCG Series Manuale del proprietario

Alliance Laundry Systems

Alliance Laundry Systems Speed Queen SF7 Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems ATGE9AWP303AW01 Manuale di programmazione

Alliance Laundry Systems

Alliance Laundry Systems HTEB17-N2802 Manuale utente

Manuali Lavatrice e asciugatrice popolari di altre marche

Whirlpool

Whirlpool WFC8090GX Manuale utente

Whirlpool

Whirlpool LTE5243DQ6 Manuale utente

Bosch

Bosch XQG100-WDU285H00W Manuale utente

montpellier

montpellier MWD7512S Manuale utente

LG FHD0905 T Series Manuale utente

Midea

Midea MF200D85B Manuale utente

Maytag

Maytag MGT3800XW Manuale utente

Siemens

Siemens WD15G440TR Scheda tecnica

Equator

Equator Clothes Processor EZ1500 Manuale utente

Splendide

Splendide WDC7100XCP Manuale utente

John Lewis

John Lewis JLWD 1408 Manuale utente

Ariston

Ariston A1200WD Manuale utente

Whirlpool

Whirlpool YLTE5243DQ5 Manuale utente

Whirlpool

Whirlpool WFCR 75230 Guida all'installazione

ATT

ATT Hammer Jet v1 Manuale utente

AEG

AEG LAVAMAT 63742 VI Manuale utente

Electrolux

Electrolux EWW8024P5WB Manuale utente

GE GTD42EASJWH Manuale utente