Alpha Alpha CB Boiler Manuale utente

Installation Instructions

Alpha CB/C/SY Boiler

Vertical FlueTerminal Assembly

Concentric (60/100) Flue System

(Kit Part No. 6.1000350)

KIT CONTENTS

1. GENERAL

a. ThefluesystemmustbeinstalledinaccordancewithBS5440:1;1990.

b. The boiler must be installed in accordance with the Installation

instructions supplied with the boiler.

c. The vertical flue terminal assembly is equivalent to a 1 m length of

flue.

d. Each 45° bend is equivalent to a 0.5 m length of flue.

Note: A 90° bend must not be used with the vertical flue.

e. Refer to the vertical flue options (Fig. 4) and ensure the flue length

does not exceed the equivalent of 4 m (including the terminal

assembly).

f. Additional flue lengths of 0.75 m and 1.0 m are available for extending

the flue up to a maximum equivalent flue length of 4 m (including the

terminal assembly).

g. The vertical flue terminal assembly may be connected directly to the

boiler adaptor.

h. To determine the actual length of flue required (L), measure the

distance from the top of the side panel to the weathering slate position

and subtract 640 mm for the terminal assembly, i.e. L = A - 640 mm

(see Fig. 4).

i. When the flue length is more than 2.5 m, the flue restrictor (Fig. 1) must

be removed. - remove the screw securing it in the boiler adaptor and lift

out.

2. INSTALLATION

a. When the template is on the wall in the boiler position, continue the

vertical line from the centre of the flue hole to the roof/ceiling position.

Mark the centre position of the flue hole 215 mm from this line as shown in Fig. 2.

Fig. 1

Fig. 2

Compiled and designed by Publications 2000, Tel (01670) 356211 08/04/D131

Fig. 4

b. Cut a hole and/or remove tiles so that there is at least a 150

mm diameter hole in the roof. Ensure there is at least a 25

mm gap between the outer duct and any combustible

material.

c. Fit a 125 mm diameter weathering slate over the hole in the

roof. A suitable weathering slate (Part No. 6.1000380) is

available from Alpha Therm Ltd.

d. Position the vertical terminal assembly into the weathering

slate ensuring that the slate is located under the lip of the

terminal as shown in Fig. 3.

Note: Ensure that the minimum distances are maintained

(see Fig. 4). Do not secure the terminal into position at this

stage.

e. Assemble the flue ducts together and cut the outer air duct

and inner flue duct assemblies to the correct lengths, i.e. up

to the terminal.

f. Place the inner duct into the outer duct and fit the ducts to

the boiler, as shown in Fig. 3, using the clamps supplied.

g. Connect the terminal ducts to the flue assembly, as shown

in Fig. 3. Secure the inner ducts with the clamps supplied

before locating the outer duct clamp.

h. After assembling all of the ducts, check that the terminal is

correctly located above the roof.

Note: Ensure that the flue assembly is supported at roof

level using suitable brackets, and that the weathering slate

is fitted correctly. Fig. 3

These instructions have been carefully prepared but we reserve the right to

alter the specification at any time in the interest of product improvement.

Alpha Therm Limited.

Nepicar House,LondonRoad, Wrotham Heath,

Sevenoaks, Kent TN15 7RS

Technical Helpline: 0870 3001 964

email: info@alphatherm.co.uk

website: www.alpha-innovation.co.uk

Questo manuale è adatto per i seguenti modelli

Indice

Altri manuali Alpha Caldaia

Alpha

Alpha Ocean Style FF Manuale utente

Alpha

Alpha ARES 440 Tec Guida utente

Alpha

Alpha Alpha CB24 Manuale utente

Alpha

Alpha InTec 12S (NG) Guida utente

Alpha

Alpha Alpha CB50 Boiler Manuale utente

Alpha

Alpha Alpha CD32 Manuale utente

Alpha

Alpha InTec 50CS Guida utente

Alpha

Alpha 240P Manuale utente

Alpha

Alpha Alpha CD24C Guida utente

Alpha

Alpha Alpha CD18S Manuale utente

Alpha

Alpha Alpha 500E Manuale utente

Alpha

Alpha Alpha CombiMax 350 Manuale utente

Alpha

Alpha Alpha CombiMax 350 Foglio di istruzioni

Alpha

Alpha Alpha 240 Boiler Range Manuale di istruzioni e di sicurezza

Alpha

Alpha Alpha CD25C Manuale utente

Alpha

Alpha Alpha 240XP Manuale utente

Alpha

Alpha Alpha CD25X Guida utente

Alpha

Alpha Alpha CD50 Guida utente

Alpha

Alpha Alpha Plus DH Units Guida

Alpha

Alpha CD90S Guida utente

Alpha

Alpha Alpha C23 Guida utente

Alpha

Alpha InTec12S Manuale utente

Alpha

Alpha Alpha HE25 Manuale utente

Alpha

Alpha Alpha CD24 Guida utente

Manuali Caldaia popolari di altre marche

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Manuale utente

Radijator

Radijator BIO max 23.1 Manuale utente

Brunner

Brunner BSV 20 Manuale utente

Buderus

Buderus Logamax GB062-24 KDE H V2 Manuale utente

Potterton

Potterton 50e Scheda tecnica

UTICA BOILERS

UTICA BOILERS TriFire Manuale utente

Joannes

Joannes LADY Series Manuale

ECR International

ECR International UB90-125 Manuale di istruzioni

Froling

Froling FHG Turbo 3000 Manuale utente

Froling

Froling P4 Pellet 8 - 105 Manuale utente

U.S. Boiler Company

U.S. Boiler Company K2 Manuale utente

Henrad

Henrad C95 FF Manuale utente

NeOvo

NeOvo EcoNox EF 36 Manuale utente

Potterton

Potterton PROMAX SL 12 Manuale utente

Eco Hometec

Eco Hometec EC 25 COMPACT Manuale utente

Viessmann

Viessmann VITODENS 200 Guida

Baxi

Baxi Prime 1.24 Manuale utente

REXNOVA

REXNOVA ISA 20 BITHERMAL Manuale utente