Ariston ecoGENUS 24 MFFI Guida utente
Servicing
Instructions
Type C Boilers
G.C.N: 41-116-03
47-116-17
LEAVE THESE INSTRUCTIONS
WITH THE END-USER
Condensing
Country of destination: GB
2
1. SERVICING INSTRUCTIONS
1.1 REPLACEMENT OF PARTS
1.2 TOGAIN GENERAL ACCESS
- Lowering the control panel and removing the front panel
- Removing the side panels
1.3 ACCESS TO THE COMBUSTION CHAMBER
- Removing the sealed chamber front cover
- Removing the fan
- Removing the burner
- Removing the electrodes
- Removing the heat exchanger inspection panel
- Removing the condensate collector
- Removing the condensate trap
- Removing the injector
1.4 ACCESS TO THE GAS VALVE
- Removing the gas valve
1.5 ACCESS TO THE WATER CIRCUIT
- Removing the D.H.W. (secondary) exchanger
- Removing the safety valve
- Removing the automatic air vent
- Removing the main circuit flow switch
- Removing the diverter valve actuator
- Removing the D.H.W. flow switch
- Removing the pump
- Removing the pressure gauge
- Removing the expansion vessel
- Removing the D.H.W. temperature sensor (N.T.C.)
- Removing the C.H. flow temperature sensor (N.T.C.)
- Removing the C.H. return temperature sensor (N.T.C.)
1.6 ACCESS TO THE CONTROL SYSTEM
- Checking the fuses
- Removing the time clock
- Removing the P.C.B.s
2. FAULT FINDING
2.1 FAULT FINDING GUIDE (FLOW-CHART)
3. ELECTRICAL DIAGRAMS
4. SHORT SPARE PARTS LIST
TABLE OF CONTENTS
3
FIG. 1.2
FIG. 1.1
1. SERVICING
INSTRUCTIONS
The life of individual components vary and they will need servicing or
replacing as and when faults develop.
The fault finding sequence chart in chapter 2 will help to locate which
component is the cause of any malfunction, and instructions for removal,
inspection and replacement of the individual parts are given in the following
pages.
1.1 REPLACEMENT
OF PARTS
1.2 TOGAIN GENERAL
ACCESS
All testing and maintenance operations on the boiler require the control panel
to be lowered.This will also require the removal of the casing.
To lower the control panel and dismantle the front part of the casing,
proceed as follows:
1. Unscrew screws “A” (1/4 turn only) (FIG. 1.1 + FIG. 1.2) and rotate the
control panel forward;
2. Unscrew the screws “B” (FIG. 1.3) and unhook the front panel by lifting it.
To ensure efficient safe operation, it is recommended that the boiler is
serviced annually by a competent person.
Before starting any servicing work, ensure both the gas and electrical
supplies to the boiler are isolated and the boiler is cool.
Before and after servicing, a combustion analysis should be made via the flue
sampling point (please refer to the Installation Manual for further details).
After servicing, preliminary electrical system checks must be carried out to
ensure electrical safety (i.e. polarity, earth continuity, resistance to earth and
short circuit).
B
A
A
A
B
FIG. 1.3
4
Removing the side panels
1. Remove the screws “C” (FIG. 1.4);
2. Pull each panel away from the boiler, then lift the panel
up and away from the boiler.
1.3 ACCESS TO THE
COMBUSTION CHAMBER
D
FIG. 1.5
D
FIG. 1.4
C
CC
C
D D
Removing the sealed chamber front cover
1. Remove the screws “D” (FIG. 1.5);
2. Pull the cover away from the boiler (FIG. 1.6).
FIG. 1.6
5
Removing the fan
1. Loosen nut “E” (FIG. 1.7);
2. Pull off the hose “F” and disconnect the electrical
connector “G” (FIG. 1.8);
3. Remove the nuts “H” (FIG. 1.9);
4. Pull the fan away from the exchanger (FIG. 1.10).
FIG. 1.10
E
FIG. 1.9
FIG. 1.7
FIG. 1.8
F
G
H
H
H
6
Removing the burner
With the fan removed (see previous section);
1. Slide the burner from its housing (FIG. 1.11).
FIG. 1.13
J
I
J
Removing the electrodes
1. Pull off the ignition cable “I” (FIG. 1.12);
2. Remove the two allen bolts “J” (FIG. 1.13);
3. Extract the electodes (FIG. 1.14).
FIG. 1.12
FIG. 1.11
FIG. 1.14
Removing the combustion chamber inspection panel
1. Remove the four nuts “K” (FIG. 1.15);
2. Remove the inspection panel (FIG. 1.16).
FIG. 1.15
KK
FIG. 1.16
K
K
7
Removing the condensate collector
1. Remove the nuts “L” from each side of front of the
collector (FIG. 1.17);
2. Remove the nuts “M” from each side of rear of the
collector (FIG. 1.18);
3. Release the condesate trap union “N” (FIG. 1.19);
4. Separate the collector from the combustion
chamber(FIG. 1.20);
5. Remove the condensate collector (FIG. 1.21).
FIG. 1.17
L
FIG. 1.18
M
FIG. 1.19
FIG. 1.20
FIG. 1.21
N
8
Removing the condensate trap
1. Loosen the union “O” (FIG. 1.22);
2. Remove the condensate trap (FIG. 1.23).
FIG. 1.22
O
Removing the injector
See the section on removing the fan before carring out this
procedure
1. Disconnect all connections from the fan and remove
(FIG. 124);
2. Remove the four screws “P” (FIG. 125);
3. Unscrew the injector “Q” using a suitable screwdriver
(FIG. 126);
4. Remove the injector (FIG. 127).
Fig. 1.23
Fig. 1.24
Fig. 1.25
P
9
FIG. 1.26
FIG. 1.27
Q
10
1.4 ACCESS TO THE GAS VALVE
FIG. 1.28
S
R
Removing the gas valve
1. Disconnect the electrical connection “R” from the gas
valve (FIG. 128);
2. Release the top nut “S” (FIG. 1.29);
3. Remove the screws “T” from the bottom of the gas valve
pipe (FIG. 1.30);
4. Remove the gas valve (FIG. 1.31).
FIG. 1.29
FIG. 1.30
FIG. 1.31
T T
Altri manuali per ecoGENUS 24 MFFI
1
Questo manuale è adatto per i seguenti modelli
1
Indice
Altri manuali Ariston Caldaia
Ariston
Ariston Type C Manuale utente
Ariston
Ariston microGENUS II 24 MFFI Manuale utente
Ariston
Ariston GENUS PREMIUM EVO SYSTEM 12 Guida utente
Ariston
Ariston CLAS HE Series Guida utente
Ariston
Ariston INTESA TP23 Manuale utente
Ariston
Ariston GENUS PREMIUM EVO 24 Guida utente
Ariston
Ariston EGIS PREMIUM Series Guida utente
Ariston
Ariston CLAS X Guida all'installazione
Ariston
Ariston MICROCOMBI 23 MFFI Guida utente
Ariston
Ariston Benchmark System A 24 RFF Guida utente
Ariston
Ariston GENUS Manuale utente
Ariston
Ariston GENUS HE 24 Manuale utente
Ariston
Ariston GENUS 27 RFFI SYSTEM Manuale utente
Ariston
Ariston CLAS HE R 24 Guida utente
Ariston
Ariston microGENUS HE 24 MFFI Manuale utente
Ariston
Ariston microGENUS 23 MI Manuale utente
Ariston
Ariston CLAS B 25 CF Manuale utente
Ariston
Ariston microSYSTEM 15 RFFI Manuale utente
Ariston
Ariston Genius he 24 Guida utente
Ariston
Ariston MICROCOMBI 23 MFFI Guida utente
