Atlantic TidalWave A-05 Manuale utente

Operating Manual

Manuel d’utilisation

Manual de operación

Includes Pumps:

Couvrant les pompes:

Comprende las siguientes bombas:

A-05

A-05L

A-21

A-31

A-32

1-877-80-PONDS

www.atlanticwatergardens.com

A-SERIES PUMPS

A-05, A-05L,

A-21, A-31

A-32

Prior to Operation and Installation

• Whenthepumpisdelivered,performthefollowingchecks:

 • Checkforanydamagetopumpandpowercablethatmayhave

  occurredduringtheshipment.

 • Checkthemodelnumbertomakesureitistheproductthatwas

  orderedandverifythevoltageandfrequencyarecorrect.

Caution

• DONOToperatethisproductunderanyconditionotherthanthose

 forwhichitisspecied.Failuretoobservethisprecautioncanleadto

 electricalshockorleakage,re,waterleakageorotherproblems.

Introduction

ThankyouforselectingtheTidalWaveA-05/A-05L/A-21/A-31/A-32

seriespumps.Beforeusingthispumppleasetakeamomenttoreview

thismanual.

Toavoidanaccidentdonotusethepumpinanywayotherthanas

describedinthismanual.Pleasenotethemanufacturercannotbe

responsibleforaccidentsarisingbecausetheproductwasnotused

asprescribed.Afterreadingthismanualkeepitasareferenceincase

questionsariseduringuse.Usingthepumpinamannerthatisnot

prescribedwillvoidthewarranty.

RecommendedOperatingRange

BestEfciencyPoint

* Operatingpumpsoutsideoftherecommendedrangemaycausebearingdamageand

 prematurefailure.

DoNotOperateRange

3165 2840 2500 2155 1875 1455 935 320

53 47 42 36 31 24 16 5

5040 4320 3600 2820 1920 840

84 72 60 47 32 14

5810 5325 4824 4335 3770 3140 2400 1530 540

97 89 80 72 63 52 40 26 9

9300 8150 6830 5535 4120 2535 625

155 136 114 92 68 42 13

12000 11040 10440 9780 9000 8280 7560 6780 5580 4920 3890

200 184 174 163 150 138 126 113 98 82 38

Max 5’ 10’ 15’ 20’ 25’ 30’ 35’ 40’ 45’ 50’ 55’ 60’

Model #

A-05 (gph)

(gpm)

A-05L (gph)

(gpm)

A-21 (gph)

(gpm)

A-31 (gph)

(gpm)

A-32 (gph)

(gpm)

• A-05/A-05L/A-21/A-31pumpsrequireasinglephase115volt/60hz

 powersupply.A-32pumprequiresasinglephase230volt/60hz

 powersupply.Alwaysverifythatthesuppliedpowermeetsthe

 requirementslistedontheupperpumpcover.

• DONOTapplyanypaintoverthestainlesssteelmotorbody.Reduced

 coolingabilitywillresultinoverheating,overloading,undesirable

 performancereductions,periodicautoshut-offandpumpmalfunction.

• Neverplaceyourhandoranyobjectinorneartheinletopeningwhile

 thisequipmentisoperating.Ifpumpinletisclogged,alwaysturnoff

 thepowersupply,fuseboxorcircuitbreakerandwaituntilthemotoris

 completelystoppedbeforeattemptingtoremoveanycloggedmaterial.

• PleasemakesurethatthepowerplugandtheACoutletreceptacleis

 protectedandawayfromwaterorpumpdischargehosetoprevent

 accidentalelectricshockorshortcircuit.

• Alwaysoperatethepumpcompletelysubmergedinwater.

• Avoiddryoperation,whichwillnotonlylowerperformancebutcan

 causethepumptooverheat/malfunction,leadingtoelectricalleakage,

 shockorprematurefailure.

• CAUTION:

THIS PUMP IS TO BE USED IN A CIRCUIT PROTECTED BY A GROUND CIRCUIT INTERRUPTER.

• CAUTION:

THIS PUMP HAS BEEN EVALUATED FOR USE IN WATER ONLY.

Before You Start

• Checkthemodelnameplatetomakesureonceagainthattheproduct

 isofthecorrectvoltageandfrequencyrating.

• Thesettingonthecircuitbreakerorotheroverloadprotectorshould

 bemadeinaccordancewiththeratedcurrencyofthepump.

• Turnoffthepowersupplyorcircuitbreakerbeforeinsertingthepower

 supplyplugtoavoidelectricalshock,shorting,orunexpectedstarting

 ofthepump,whichcouldleadtoinjury.

• Neveroperatethepumpwhileitissuspendedinair.Therecoilmay

 resultininjuryorothermajoraccident.

Electrical Safety

• Electricalwiringshouldbeinstalledbyaqualiedelectricianinaccor-

 dancewithallapplicablesafetyregulations.Incorrectwiringcanlead

 toapumpmalfunction,electricalshockorre.

• Pumpsshouldoperateonadesignated,circuitratedat15Amps

 (minimum).

• Pumpmustbeprotectedbyagroundfaultcircuitinterrupter(GFCI).

• Pumpmustbepluggedintoastandard,properlygrounded,three

 prongedoutlet.

• Donotcuttheelectricalcable.Ifacablewithcutinsulationorother

 damageissubmergedinwater,thereisdangerofwaterseepinginto

 thepumpmotorandcausingashort.Thismayresultindamagetothe

 pump,electricalshockorre.Altering the electrical cable in any way

will void the warranty.

• Nevermoveorhandlethepumpbypullingontheelectricalcable.

 Makesuretheelectricalcabledoesnotbecomeexcessivelybentor

 twisted,doesnotrubagainstastructureinawaythatmightdamageit,

 anddoesnotcomeincontactwithheatedsurfaces.

Operation

• Incaseofapoweroutage,turnoffthepowertothepumptoavoid

 havingitstartunexpectedlywhenthepowerisrestored.

• Paycarefulattentiontothewaterlevelwhilethepumpisoperating.

 Dryoperationmaycausethepumptomalfunction.Pump must always

operate while fully submersed.

• Incaseofveryexcessivevibration,unusualnoiseorodor,turnoffthe

 powerimmediatelyandconsultwithyournearestdealer.Continuingto

 operatethepumpunderabnormalconditionsmayresultinelectrical

 leakage,electricalshockorre.

Motor Protection System

• Thepumphasabuilt-inmotorprotectionsystem.Thefollowingreasons

 maycausethepumptostopautomaticallyregardlessofwaterlevel.

  Motoroverheating

  Excessivecurrent

  Changeinvoltagepolarity

  Open-phaseoperationoroperationunderconstraint

• Repeatingcyclesofstoppingandrestartingwilldamagethewater

 pump.Donotcontinueoperationatlowlift,lowwaterlevel,or

 whiletheinletiscloggedwithdebris.Notonlywillperformance

 suffer,butalsosuchconditionsmaycausenoise,heavyvibration,

 andpumpfailure.

Maintenance and Inspection

• Regularmaintenanceandinspectionsareanecessityfor

 continuedefcientfunctioning.Ifanyabnormalconditionsare

 noticed,refertothesectiononTroubleshootingandtakecorrective

 measuresimmediately.

• Duringorafterthewarrantyperiod,thecustomerisNOTto

 disassemblethepumpforanyreason.

Monthly Inspection

• Checkforanydropinperformance.Reducedperformanceisusually

 causedbydebrisblockingtheintakescreen.

• Detachthepowercablefromthereceptacleandturnoffthepower

 supply(circuitbreaker).

• Disconnectthepumpdischargeandremovethepumpfrom

 thewater.

• Removeanyaccumulateddebrisfromthesurfaceofthepump,inlet

 screenandimpeller.

• Makesureallnutsandboltsarefastenedsecurely.

• Donotdisassemblethepumpforanyreason.Disassemblywillvoid

 thepumpwarranty.Referoperatingandmaintenanceproblemstoa

 qualiedtechnician.

Winterizing

• Undernocircumstancesshouldthepumpbeleftinfrozenwater.

• Whenthepumpisoutofuseforanextendedperiod,washitanddry

 itthoroughly,thenstoreitindoors.

Note:Alwaysrunatestoperationbeforeputtingthepumpbackinto

operation.Whenthepumpisleftinstalledinwateritshouldberunat

regularintervals(aboutonceperweek).

Warranty

AllA-SeriesPumpscarryatwo-yearlimitedwarranty.Thislimited

warrantyisextendedsolelytotheoriginalpurchasercommencing

fromthedateoforiginalpurchasereceiptandisvoidifanyofthe

followingapply:

• Thepumphasbeenrunwhilenotfullysubmersedcausingthe

 thermalprotectiontotrip.Skimmersusinginadequatevertical

 ltrationmaycreate“rundry”conditions.

• Thepumpwasnotrunonadedicatedcircuit.

• Thecordhasbeencutoraltered.

• Thepumphasbeenmisusedorabused.

• Serialnumbertaghasbeenremoved.

• Thepumphasbeenfullyorpartiallydisassembled.

Warranty Claims

• Incaseofwarrantyclaims,pumpshouldbereturnedtoplaceof

 purchaseaccompaniedbyoriginalreceipt.

A-05 A-05L A-21 A-31 A-32

A9” 10” 10” 11” 15”

B7½” 8½” 8½” 9” 13”

C6¼” 7” 7” 7” 8½”

D15” 17” 17” 18” 23”

NO. Description

1Handle

2Cable

3EpoxyCableBase

4UpperCover

5Autocut

6BallBearing(upper)

7Shaft

8Stator

9Rotor

10 BallBearing(lower)

11 MotorCase

12 BearingBracket

13 Lubricant

14 MechanicalSeal

15 SealBracket

16 LipSeal

17 Impeller

18 Flange

19 Casing

20 Strainer

10 13

Problem Possible Cause Possible Solution

Pumpdoes

notstart

Powerisoff Turnpoweron

Powerfailure Checkpowersupplyor

contactlocalpowercompany

Voltagedrop/

Overload

Check/ReplacetheGFI(Ground

FaultInterrupter)

Powercordisnot

connected Connectpowercord

Pumpstopsafter

starting

Pumpis

overheating

Submergepump/Raisewaterlevel/

Allowpumptocool

Power/Current

overload

Checklength/sizeofpowercable.

CheckorreplaceGFI

Impellerisblocked Removedebrisfromthe

impellerchamber

Diminished

owrateor

nowaterow

Airlock Restart/Cleanairvalve

Obstructioninpump

orpiping Clearobstruction

Pipingistoolong Reducelengthofpipe

Troubleshooting Guide

Alwaysturnoffpowerbeforeinspectingthepump.Failuretoobservethis

precautioncanresultinaseriousaccident.

Beforeorderingrepairs,carefullyreadthroughthisinstructionbooklet.If

theproblempersists,contactyourdealer.

Avant l’installation et la mise en fonctionnement

• Quandlapompeestlivrée,effectuezd’abordlescontrôlessuivants:

 • Vériezqu’iln’yaeuaucundommageàlapompeetàsoncâble 

  d’alimentationdurantl’expédition.

 • Vériezlaréférencedemodèle,envousassurantquec’estbien 

  leproduitquevousavezcommandé,etvériezquelatensionetla 

  fréquencedusecteursontcorrects.

Attention

• NEfaitesPASfonctionnerceproduitdansn’importequellecondition 

autrequecellepourlaquelleilestspécié.Nepasobserverces

précautionspeutentraînerunecommotionélectrique,unefuiteouun

départd’incendie,oud’autresproblèmes.

Introduction

Mercid’avoirsélectionnélespompesTidalWavedessériesA-05/A-

05L/A-21/A-31/A-32.Avantd’utilisercettepompe,veuillezprendreun

momentpourparcourircemanuel.

Pouréviterunaccidentn’utilisezpaslapomped’unefaçonautreque

cequiestdécritdanscemanuel.Veuilleznoterqueleconstructeurne

peutpasêtretenupourresponsabled’accidentssurvenantparceque

leproduitn’apasétéutilisécommec’estprescrit.Aprèsavoirluce

manuelgardez-lecommeréférenceencasoùvousauriezdes 

interrogationsdurantl’utilisation.Lefaitd’utilisercettepomped’une

façonnonprescriteannulerasagarantie.

Plagedetravailrecommandée

Pointdemeilleureefcacité

* Fairefonctionnerdespompeshorsdelaplagerecommandéepeutcauserdesdommages

 auxpaliersetunedéfaillanceprématurée.

Plageoùnepasfonctionner

3165 2840 2500 2155 1875 1455 935 320

53 47 42 36 31 24 16 5

5040 4320 3600 2820 1920 840

84 72 60 47 32 14

5810 5325 4824 4335 3770 3140 2400 1530 540

97 89 80 72 63 52 40 26 9

9300 8150 6830 5535 4120 2535 625

155 136 114 92 68 42 13

12000 11040 10440 9780 9000 8280 7560 6780 5580 4920 3890

200 184 174 163 150 138 126 113 98 82 38

Max 5’ 10’ 15’ 20’ 25’ 30’ 35’ 40’ 45’ 50’ 55’ 60’

Modèle

A-05 (gph)

(gpm)

A-05L (gph)

(gpm)

A-21 (gph)

(gpm)

A-31 (gph)

(gpm)

A-32 (gph)

(gpm)

• LespompesA-05/A-05L/A-21/A-31nécessitentunealimentationen 

 secteurmonophasé115volts/60Hz.LapompeA-32nécessiteune 

 alimentationensecteurmonophasé230volts/60Hz.Vérieztoujours

 quelesecteurfournirépondbienauxexigenceslistéessurlecouvercle

 duhautdepompe.

•N’appliquezPASunequelconquepeinturesurlecorpsdemoteur 

 enacierinox.Unecapacitéderefroidissementréduiteentraîneraune 

 surchauffeetunesurcharge,causeradesréductionsdeperformance, 

 descoupurespériodiquesautomatiques,etundysfonctionnementde 

 lapompe.

• Neplacezjamaisvosmainssurn’importequelobjetprèsdel’ouverture

 d’aspirationpendantquel’équipementestenmarche.Sil’entréedela 

 pompeestbouchée,coupeztoujoursl’alimentationsecteurenamont 

 auniveaudesfusiblesoududisjoncteur,etattendezl’arrêtcompletdu 

 moteuravantd’essayerd’éliminerlesmatièrescausantl’obstruction.

• Veuillezvousassurerquelached’alimentationetquelaprisesecteur 

sontprotégéesetàl’écartdel’eauetdutuyaud’évacuationdela 

pompe,pouréviterunecommotionélectriqueouuncourt-circuit

accidentels.

• Faitestoujoursfonctionnerlapompecomplètementimmergéedans 

 l’eau.

• Éviteztouteutilisationàsec,quinonseulementréduitlaperformance 

 maispeutprovoquerunéchauffementetundysfonctionnementde 

 lapompe,entraînantunefuiteouunecommotionélectriques,ouune 

 panneprématurée.

• ATTENTION:

CETTE POMPE DOIT ETRE BRANCHEE A UNE DERIVATION PROTEGEE PAR UN

DISJONCTEUR DIFFERENTIEL.

•ATTENTION: 

CETTE POMPE A ÉTÉ ÉVALUÉE POUR UTILISATION DANS DE L’EAU UNIQUEMENT.

Avant de commencer

• Contrôlezlaplaquesignalétiquepourvousassurerdenouveauque 

 leproduitportelesindicationscorrectesdetensionetdefréquence 

 secteur.

• Leniveaudedéclenchementdudisjoncteuroududispositifde 

 protectiondoitêtredénienfonctionducourantnominaltiréparla 

 pompe.

Altri manuali per TidalWave A-05

Questo manuale è adatto per i seguenti modelli

Indice

Lingue:

Altri manuali Atlantic Pompa dell'acqua

Atlantic

Atlantic TidalWave FP100 Series Manuale utente

Atlantic

Atlantic FP100-73816 Manuale utente

Atlantic

Atlantic MD550 Manuale utente

Atlantic

Atlantic PAF-20SV Manuale utente

Atlantic

Atlantic TidalWave L-305 Manuale utente

Atlantic

Atlantic TA1800 Manuale utente

Atlantic

Atlantic TidalWave A-05 Manuale utente

Atlantic

Atlantic TIDAlWAVE SH Series Manuale utente

Atlantic

Atlantic TidalWave TT1500 Manuale utente

Atlantic

Atlantic Typhoon TA-2200 Manuale utente

Atlantic

Atlantic A Series Manuale utente

Atlantic

Atlantic MD250 Manuale utente

Manuali Pompa dell'acqua popolari di altre marche

Neptun

Neptun NPHW 5500 Manuale utente

Sensidyne

Sensidyne Gilian BDX-II Istruzioni per l'installazione e il funzionamento

Draper

Draper 47808 Manuale utente

Trolla

Trolla 12820 Manuale utente

Sunfab

Sunfab SVH Series Manuale utente

WilTec

WilTec 50740 Manuale utente

Fieldmann

Fieldmann FVC 5015 EK Manuale utente

Everbilt

Everbilt EFSUB5-122HD Manuale utente

Graco

Graco Husky 3300e Manuale utente

esotec

esotec 101018 Manuale utente

moyno

moyno 2000 CC Manuale utente

Becker

Becker BASIC VASF 2.80/1-0.AC230 Manuale utente

Sykes AmeriPumps

Sykes AmeriPumps GP100M Guida alla risoluzione dei problemi

DUROMAX

DUROMAX XP WX Series Manuale utente

BRINKMANN PUMPS

BRINKMANN PUMPS SBF550 Manuale utente

Franklin Electric

Franklin Electric IPS Manuale utente

Xylem

Xylem e-1532 Series Manuale utente

Milton Roy

Milton Roy PRIMEROYAL Manuale utente