Battery Doctor’s®5 watt Trickle Charger/Maintainer (Model #23143)
Specifications and Included Items:
Power Rating: Up to 5 Watts
Current: Up to 420mAmps @ 12 Volts
Includes: Solar Panel, 12 Volt DC Plug, Alligator Battery Clamps, 8’ 8” Wire, (4) Steel Mounting Brackets, Tilting Rods, Voltage
Indicator
Installation
Securely place the solar panel in the sun. Included mounting brackets and screws can be used if necessary for permanent
installation. Tilting rods are also supplied positioning the solar panel at an angle.
Installation Through 12 Volt DC Plug:
Plug the included 12VDC Plug into the 12 Volt DC socket (example: portable power pack). For optimal power, ensure the panel
(solar cell facing up) is directly facing the sun.
Installation to Battery with Alligator Clamps:
Connect the included alligator clamps correctly by matching the red clamp which is Positive (+) to the Positive (+) terminal on
your battery. Connect the black Clamp which is Negative (-) to the Negative (-) Terminal on your battery.
WARNING Follow this carefully to not cause any bodily harm. Wrong connections may cause sparking or explosion.
For optimal power, ensure the panel (with the solar cell facing up) is directly facing the sun.
NOTE:
This solar panel has a built in blocking diode to prevent reverse discharge. Please do not use this panel while vehicle is in use.
When operating your vehicle it is best to secure the solar panel in the glove box or in another secure location.
BRACKET INSTALLATION
To install the mounting brackets, please follow the below instructions.
Step 1
Remove the screws from the silver bracket on the back side of the solar panel as shown in the picture. This will require a
small Phillips head screwdriver. The screws that are removed will not be needed to fasten the bracket.
Step 2
Line up the bracket’s two holes over the solar panel bracket’s holes and use the supplied Flush Head screws to secure the
bracket to the panel.
Step 3
Repeat these steps for the other three remaining brackets if required.
Battery Doctor’s®1.8 watt Maintainer (Model #23140)
Specifications and included items:
Power Rating: Up to 1.8 Watts
Current: Up to 150 mAmps @ 12 Volts.
Includes: Alligator Clamps, 12 Volt DC Plug, 8’ 8” Wire, Tilting Rods, Voltage Indicator
Installation
Installation through 12 Volt DC Plug:
Plug the included 12VDC Plug into the 12 Volt DC socket (example: portable power pack). Make sure both ends are secure and
aligned correctly. For optimal power, ensure the panel (solar cell up) is directly facing the sun.
Installation to Battery with Alligator Clamps:
Connect the included alligator clamps correctly by matching the red clamp which is Positive (+) to the Positive (+) terminal on
your battery. Connect the black Clamp which is Negative (-) to the Negative (-) Terminal on your battery.
WARNING: Follow this carefully to not cause any bodily harm. Wrong connections may cause sparking or explosion.
For optimal power, ensure the panel (with the solar cell facing up) is directly facing the sun.
FREQUENTLY ASKED QUESTIONS
Q: Will the Battery Doctor’s®1.8 watt Model #23140 keep my vehicle battery maintained?
A: The Battery Doctor’s®1.8 watt Model #23140 compensates for natural voltage losses and key-off small instrumentation
drain by replenishing and maintaining your battery up to a maximum rate of 150 milla-Amps in full sunlight.
Q: What types of batteries can I maintain?
A: You can maintain all types of rechargeable 12V batteries including automotive batteries, deep cycle (traction) batteries,
gel-cell batteries, and heavy-duty (stationary) batteries.
Q: Can the Battery Doctor’s®1.8 watt Model #23140 drain my battery at night?
A: No. Battery Doctor’s®1.8 watt Model #23140 solar panels are equipped with a built-in diode, which prevents reverse
current.
Q: Can I overcharge my battery with the Battery Doctor’s®1.8 watt Model #23140?
A: The Battery Doctor’s®1.8 watt Model #23140 will not overcharge a battery.
Q: Can the Battery Doctor’s®1.8 watt Model #23140 be left outdoors?
A: No. This solar panel is not weatherproof. If this solar panel is weathered the warranty will become void.
Q: Will the Battery Doctor’s®1.8 watt Model #23140 maintain the battery through the cigarette lighter socket (12 volt
lighter adapter)?
A: In some vehicle models, the cigarette lighter socket (12 volt lighter adapter) is inactive while the vehicle is off. Please
consult your car owner’s manual. In the event that your car presents this limitation, use the battery clamps provided
with the unit in order to connect it directly to your battery.
Q: How do I know if the panel is working?
A: Use a voltmeter to measure the voltage of the panel. The voltage reading should be between 16 and 25 Volts in full sun.
Q: The blue LED does not light up when the voltage indicator is plugged in to check the panel?
A: If the blue LED is not lit, it may mean that you are not exposing the unit to enough daylight. Please position the solar
panel to maximize its exposure to the sun.
Q: Do I need a charge controller?
A: No, a solar battery charge controller is only needed for our solar panels of 9 Watts or greater.
