BBQ 41242 Manuale utente

WARNING

Improper installation, adjustment,

alteration, service or maintenance can

cause injury or property damage.

Read the installation, operation and

maintenance instructions thoroughly

before installing or servicing this

equipment.

Failure to follow these instructions

could result in fire or explosion which

could cause property damage,

personal injury or death.

PROP 65 WARNING

Chemicals known to the state of

California to cause cancer, birth

defects, or other reproductive harm

are created by the combustion of

propane.

DANGER!

DO NOT use gas grill for indoor

cooking or heating. TOXIC fumes can

accumulate and cause asphyxiation.

NOT to be used in or on boats or

recreational vehicles.

SAVE THESE INSTRUCTIONS FOR

FUTURE REFERENCE. IF YOU ARE

ASSEMBLING THIS UNIT FOR SOMEONE

ELSE, GIVE THIS MANUAL TO HIM OR HER

TO SAVE FOR FUTURE REFERENCE.

WARNING

FOR YOUR SAFETY

For Outdoor Use Only

(outside any enclosure)

Tabletop Gas Grill

ITEM # 41242

in China

GAT1913-1 owner' s manual

Grill Operation Quick Reference

Before Grilling,

Step 1 Keep your grill a safe distance away from your property.*

Step 2 Always Perform a Leak Test on all connections and hoses.*

Step 3 Keep children away from the grill.

During Grilling,

(To avoid tripping safety valves, please follow these instructions carefully!)

Step 1 First open lid and turn gas valve on slowly.

Step 2 Turn only one knob on at a time when lighting up the grill.

Step 3 Use protective gloves when grill gets hot.

After Grilling,

Step 1 Burn grill for 10-15 minutes to burn off food residues.

Step 2 Wait until the grill is completely cooled before closing lid.

Step 3 Clean up grease build-up and cover your grill.

* Please refer to the owner’s manual for details.

SPECIAL WARNINGS

1. DO NOT store or use gasoline or other flammable vapors and liquids within 25 feet

of this or any other appliance.

2. When cooking with oil/grease, do not allow the oil/grease to exceed 350°F

(177°C).

3. Do not store or use extra cooking oil in the vicinity of this or any other appliance.

4. Only use 1-pound (16.4 oz) cylinders equipped with a cylinder connection device

compatible with the connection for outdoor cooking appliances.

5. If you smell gas:

•Shut off gas to the appliance.

•Extinguish any open flames.

•Open lid.

•If odor continues, immediately call your gas supplier or fire

department.

Always read and understand the WARNINGS and INSTRUCTIONS that are

contained in this manual before attempting to use this gas barbecue grill, to

prevent possible bodily injury or property damage.

GAT1913-1 owner' s manual

Table of Contents

For Your Safety ....................................................................................................2

Illustrated Part List ................................................................................................4

Assembly Instructions .........................................................................................6

Operating Your Grill Propane Tank Connection ...................................12

Checking for Leaks .............................................13

Lighting Your Grill ...............................................13

Excess Flow Safety Valve Reset Procedure ……14

Care and Maintenance ........................................14

Award-Winning Barbecue Recipes ...................................................................15

Troubleshooting ..................................................................................................16

Warranty Program ..............................................................................................17

For Your Safety

Dear Valued Customer,

Congratulations on your new barbecue grill purchase! You’ve made the right choice. In this manual, you will find assembly

instructions, suggestions for grilling and helpful hints, as well as guidelines for the safe operation, proper care and use of

your grill. Our expert staff strives to provide you with an easy to assemble product. Should you have any questions or

problems with this product, please call our customer service department at 1-877-885-8227 6:00 am - 5:00 pm (PST),

Monday through Friday.

NOTE: The use and installation of this product must conform to local codes. In absence of local codes, use the National Fuel Gas

Code, ANSI Z223.1/NFPA 54, Storage and Handling of Liquefied Petroleum Gases, ANSI/NFPA 58 or CSA B149.1,

Natural Gas and Propane Installation Code.

Safety First!

Read and understand all warnings, precautions and instructions prior to assembling and operating your grill.

WARNING

1. This grill is for outside use only. It should not be used in a building, garage or any other enclosed area.

2. The use of alcohol, prescription or non-prescription drugs may impair an individual’s ability to properly assemble or safely

operate this appliance.

3. Do not leave a lit grill unattended. This will prevent uncontrolled grease fires from erupting.

4. Keep children and pets away from the grill at all times.

5. Do not use the grill in high winds.

6. This grill must be use with propane gas only.

7. Do not attempt to attach this grill to the self-contained propane system of a camper

trailer, motor home or house.

8. Do not use charcoal or lighter fluid.

9. Do not use gasoline, kerosene or alcohol for lighting. The LP-gas supply cylinder must be constructed and marked in

accordance with the specifications for propane gas cylinders of the U.S. Department of Transportation (DOT) CFR 49.

10. Do not attempt to move the grill while it is lit.

11. Do not use the grill unless it is

COMPLETELY

assembled and all parts are securely fastened and tightened. If there are any

missing or damaged parts, contact customer service for a replacement.

12. Do not alter the grill in any manner.

GAT1913-1 owner' s manual

CAUTION-Prevention of Burns

1. To avoid burns, do not touch metal parts of the grill until they have completely cooled for at least 45 minutes or unless you

are wearing protective gear such as pot holders, gloves, BBQ mittens, etc.

2. Always open the grill lid carefully and slowly as heat and steam trapped within the grill could cause severe burns.

3. Clean and inspect the grill each use.

DANGER – Gas Safety

Liquid propane (LP) gas is flammable and hazardous if handled improperly. Become aware of its characteristics before using any

propane product.

•

Propane Characteristics: Flammable, explosive under pressure, heavier than air and settles in pools in low areas.

•

In its natural state, propane has no odor. For your safety, an odorant has been added.

•

Contact with propane could cause freeze burns to the skin.

•

This grill is shipped from the factory for propane gas use only.

•

Never use a propane cylinder with a damaged body, valve, collar or footing.

•

Dented or rusted propane cylinders may be hazardous and should be checked by your propane gas supplier.

•

Never keep a filled container in a hot car or car trunk. Heat will cause the gas pressure to increase, which may open the

releasevalveandallowgasflowtoescape.

Safe Locations for Use of This Outdoor Grill

DANGER

•

Never use this outdoor grill inside any building, garage, shed or breezeway, or

inside any boat, trailer or recreational vehicle, to prevent a possible fire and to

prevent the possibility of carbon monoxide poisoning or asphyxiation.

•

Always place your grill on a hard and level surface far away from combustible

materials and structures. An asphalt or blacktop surface may not be acceptable

for this purpose

•

This outdoor gas appliance is not intended to be installed in or on recreation

vehicles and

or boats.

•

Do not use this appliance under overhead combustible surface or covered area (e.g., awnings, umbrellas, porches or

gazeboes). Keep all combustible surfaces at least 12” (30CM) away

•

Always confirm that this grill is not positioned under the overhang of a house, a garage or other structure before lighting it. An

overhang will serve to deflect flare-ups and radiated heat into the structure itself, which could result in a fire.

•

Always confirm that this grill is positioned more than 24 inches (61 cm) away from any combustible materials or surface

before lighting it, and that no gasoline or other volatile substances are stored in the vicinity of this grill. The temperature of a

grease fire or of the radiated heat might otherwise be sufficient to ignite nearby combustible or volatile substances.

(As the fig. shown on right).

•

Always locate this grill where there will be ample combustion and ventilation air, but never position it in the direct path of a

strong wind.

•

Never store or use gasoline or other flammable or volatile substances in the vicinity of this grill or in the vicinity of any other

heat-generating appliance, because of the danger of starting a fire.

CAUTION

•

It is essential to keep the grill’s valve compartment, burners and circulating air passages clean.

•

Inspect the grill before each use:

Step 1

. Inspect all connections and make certain they are secure.

Step 2

Check and clean the burner venturi tube for insects and insect nest by removing the burner and inserting a bottle brush

cleaner into the tube to make sure the passage is clear.

*** A clogged tube can lead to a fire at the regulator valve.

Step 3

Ensure that the regulator valve nozzle is pointing straight and completely inserted into the venturi tube.

GENERAL INFORMATION

1. A propane gas cylinder

required for operation.

2. This gas grill is NOT intended for commercial use.

GAT1913-1 owner’s manual

Illustrated parts list

1. Lid…………..…....................1pc

2. Lid handle.................…1pc 3. Body…........……….............1pc

4. Cooking grid……….......…...1pc 5. Warming rack..……..…1pc 6. Side handle…................…2pcs

7. Side handle support..........2pcs 8. Heat insulation board......2pcs 9. Burner......….……........……1pc

10. Heating plate..................1 pc 11. Reflection plate.............1pc

12. Front support.....................1pc

13. Back support..................1pc 14. Regulator valve…...........1pc 15.Fastener.........................2pcs

16. Grease cup....................1pc

GAT1913-1 owner’s manual

Hardware List (A screwdriver is also included for your convenience.)



8pcs G

  

2pcs





1pc H

2pcs



4pcs I

2pcs

D15pcs J4pcs

E15pcs K1pc

2pcs 



Bolt

M5 x 45MM

Clevis Pin

Ø6.5 X 45MM

Gasket

Hair Pin

Ø1.3MM

Nut M6

Bolt

M6 x10MM

Bolt

M5 x10MM

Nut M5

Screwdriver

Lock Washer

Ø6.0MM

Flat Washer

Ø6MM

GAT1913-1 owner’s manual 6

Assembly Instructions

For Best Results

Remove all contents from packaging, and make sure all parts are present before attempting to assemble!

Tighten all bolt connections by hand first, then when the grill is fully assembled, go back and tighten.

It will take 510 minutes to assemble the grill.

Step 2

Fix the front support (12) and back

support (13) onto the grill body as

shown. Pull them outwards and

make sure both supports/legs locked

in place.

Step 1

Install the burner (9) and reflection

plate (11) into the grill body (3) as

shown.

GAT1913-1 owner’s manual 7

Step 3

Fix side handles (6), heat insulation

board (8), side handle supports (7)

and fastener (15) to the grill body as

shown.

Step 4

Install the lid handle (2) on

lid (1) as shown.

GAT1913-1 owner’s manual 8

Step 5

Connect the top lid and body

by insert the clevis pins (G) as

shown.

Step 6

Inserting the hair pin (H)

through the hole in the end of

each clevis pin as shown.

GAT1913-1 owner’s manual 9

Step 8

Put the warming rack (5) onto the

heating plate as shown.

Step 7

Put the heating plate (10) into the

grill upon the burner as shown.

Indice

Manuali Griglia popolari di altre marche

Orbegozo

Orbegozo GR 2300 Manuale utente

bora

bora PT11 Manuale utente

Klarstein

Klarstein 10031664 Manuale utente

Garland

Garland MWE3W Manuale utente

Char-Broil

Char-Broil 463722714 Manuale utente

Nexgrill

Nexgrill 720-0830HK Manuale utente

Kenmore

Kenmore 415.16123800 Manuale utente

Camp Chef

Camp Chef PG24CLAU Manuale utente

Tucker Barbecues

Tucker Barbecues GTR Series Istruzioni per il montaggio

Monogram

Monogram ZGG540NCP1SS Manuale utente

Equipex

Equipex Sodir Savoy Manuale utente

Gaggenau

Gaggenau VR 414 610 Manuale utente

Miele

Miele KM 408-1 Manuale utente

George Foreman

George Foreman GGR50B Manuale utente

AOG

AOG T series Manuale utente

Gorenje

Gorenje TG2000CB Manuale di istruzioni

Weber

Weber Genesis Silver-B Permamount NG 051701 Manuale utente

Glen

Glen SA 3037 Manuale utente