Beta RR 300 2T Manuale utente

1GB

RR 250 - 300 2T

Thanks for you preference, and have a good time! This hand-

book contains the information you need to properly operate and

maintain your motorcycle.

The data and speciﬁcations provided in this manual does not constitute an

engagement on the part of BETAMOTOR S.p.A. BETAMOTOR reserves the

right to make any changes and improvements to its models at any moment

and without notice.

IMPORTANT

We recommend you to check all the tightenings after the ﬁrst one

or two hours’ ride over rough ground. Special attention should

be paid to the following parts:

•rear sprocket

•ensure that the footrests are properly ﬁxed

•front/rear brake levers/calipers/discs

•check that the plastics are properly fastened

•engine bolts

•shock absorber bolts/swingarm

•wheel hubs/spokes

•rear frame

•pipe connections

•tensioning the chain

IMPORTANT

For any servicing requirements, please get in contact with Beta-

motor’s authorized service network.

CONTENTS

3GB

TABLE OF CONTENTS

Operating instructions.............................................................................5

Ecologic guide.......................................................................................5

Riding safety .........................................................................................6

CHAPTER 1 GENERAL INFORMATION ..............................................7

Vehicle identiﬁcation data .......................................................................8

Tools kit ................................................................................................8

Steering lock .......................................................................................10

Familiarizing with the vehicle.................................................................11

Digital rpm indicator operating instructions..............................................14

Speciﬁcations ......................................................................................20

Electrical system...................................................................................24

Recommended lubricants and liquid .......................................................28

CHAPTER 2 OPERATION..................................................................29

Checks to be performed before each ride ...............................................30

Running-in...........................................................................................31

Engine start .........................................................................................32

Refuelling............................................................................................33

Fuel tank cap.......................................................................................33

Fuel tap ..............................................................................................33

CHAPTER 3 CHECKS AND MAINTENANCE .....................................35

Changing the gear and clutch oil...........................................................36

Brakes ................................................................................................37

Tyres...................................................................................................40

Hydraulic clutch...................................................................................41

Fork oil ...............................................................................................42

Air Filter..............................................................................................45

Spark plug ..........................................................................................46

Carburettor .........................................................................................47

Coolant ..............................................................................................48

Chain.................................................................................................49

Battery................................................................................................50

Cleaning the vehicle.............................................................................51

Scheduled maintenance vehicle ............................................................52

Prolonged inactivity..............................................................................54

CONTENTS

CHAPTER 4 ADJUSTMENTS..............................................................56

Adjusting the home position of the front brake lever..................................57

Adjusting the home position of the brake pedal .......................................57

Adjusting the home position of the clutch lever.........................................57

Adjusting the handlebars ......................................................................57

Gas control adjustment .........................................................................58

Checking and adjusting the steering play................................................58

Adjusting fork......................................................................................59

Shock absorber....................................................................................60

Tensioning the chain.............................................................................61

Adjusting the idle speed........................................................................62

Exhaust valve control adjustment............................................................63

CHAPTER 5 REPLACEMENTS ............................................................64

Replacing the brake pads .....................................................................65

Replacing the headlight bulbs................................................................67

Tail light..............................................................................................67

Troubleshooting ...................................................................................69

5GB

OPERATING INSTRUCTIONS

•The vehicle must be accompanied by: number-plate, registration document, tax

disc and insurance.

•Do not carry animals, pets or loose objects that can stick out from the vehicle.

•Riding without a crash helmet is forbidden.

•Always ride with the low beam on.

•Any modiﬁcations of the engine or other parts resulting in a power and/or speed

increase are punishable by severe sanctions including the conﬁscation of the vehicle.

•To protect your safety and that of others, always drive carefully and with your helmet

on.

WARNING

Any modiﬁcations and tampering with the vehicle during the warranty period exempt

the manufacturer from all responsibility and invalidate warranty.

ECOLOGIC GUIDE

•Every vehicle powered by an internal combustion engine produces an amount of

noise (noise pollution) and gases (air pollution) which varies with the riding style.

•The abatement of noise and air pollution levels is the duty of everybody. Avoid

full-throttle starts, sudden acceleration and abrupt braking. This will reduce noise

emission as well as the wear and tear of the tyres and mechanical parts, and will

also allow a considerable reduction in fuel consumption.

RIDING SAFETY

•Observe the Highway Code.

•Always put on and fasten a homologated helmet.

•Always ride with the low beam on.

•Always keep the crash helmet visor clean.

•Avoid wearing garments with hanging ends.

•Do not keep sharp or brittle objects in your pockets while riding.

•Properly adjust the rearview mirrors.

•Always ride in a seated position, with both hands on the handlebars and both feet

on the footrests.

•Always pay attention and do not allow anything to distract you while riding.

•Do not eat, drink, smoke, use a mobile phone, etc. while riding.

•Do not wear headphones to listen to music while riding.

•Never ride abreast with other vehicles.

•Do not tow and avoid being towed by other vehicles.

•Always keep a safe distance from other vehicles.

•Do not sit on the vehicle when it is on its stand.

•Do not start off while the vehicle is on its stand.

•Do not pull out the stand when the vehicle is facing downhill.

•Avoid swaying and wheelies as they are extremely dangerous for your own and

other people’s safety as well as for your vehicle.

•Always apply both brakes on dry roads with no gravel and sand. Using one brake

may be dangerous and cause uncontrolled skidding.

•To reduce the braking distance, always apply both brakes.

•On wet roads and in off-road riding, drive with care and at moderate speed. Take

special care in applying the brakes.

•Do not start the engine in closed places.

GENERAL INFORMATION

7GB

CHAPTER 1 GENERAL INFORMATION

CONTENTS

Vehicle identiﬁcation data .......................................................................8

Frame identiﬁcation ...........................................................................8

Engine identiﬁcation ..........................................................................8

Tools kit ................................................................................................8

Steering lock .......................................................................................10

Familiarizing with the vehicle.................................................................11

Main parts:.....................................................................................11

Clutch lever ....................................................................................12

Front brake lever .............................................................................12

Gearchange lever............................................................................12

Brake pedal....................................................................................12

Starter button ..................................................................................13

LH switch........................................................................................13

Indicator switch...............................................................................13

Kickstart .........................................................................................13

Side stand ......................................................................................13

Digital rpm indicator operating instructions..............................................14

Speciﬁcations ......................................................................................20

Weight...........................................................................................20

Dimensions.....................................................................................20

Tyres..............................................................................................20

Capacities......................................................................................20

Front suspension..............................................................................20

Rear suspension ..............................................................................21

Front brake.....................................................................................21

Rear brake .....................................................................................21

Engine ...........................................................................................22

Electrical system...................................................................................24

Electrical diagram ...........................................................................24

Legend electrical diagram ................................................................25

Battery ...........................................................................................26

Fuse...............................................................................................27

Recommended lubricants and liquid .......................................................28

GENERAL INFORMATION

VEHICLE IDENTIFICATION

DATA

FRAME IDENTIFICATION

Frame identiﬁcation data Aare stamped

on the right side of the steering head tube.

ENGINE IDENTIFICATION

Engine identiﬁcation data Bare stamped

in the area shown in the ﬁgure.

TOOLS KIT

The following items are supplied as stand-

ard: operation and maintenance manual,

tool kit (see photo).

GENERAL INFORMATION

9GB

Get off the male end wrenches and hexa-

gon socket 3.

With these is possible to unscrew the

screw 4.3

Pull the left cover of rear fender and unhook

two rubber bande 5. Now the toolkit 6

is accessibile.

To take the tool kit, push the button 1to

get off the saddle. Pull back the saddle.

Pull the rear side panel 2to disassemble it.

GENERAL INFORMATION

STEERING LOCK

The vehicle is supplied with one key and

a spare to be used for the steering lock.

WARNING:

Do not keep the spare keys in the vehicle.

Keep the keys in a safe and easy-to-reach

place. The code number stamped on the

keys should be copied on this manual (or

elsewhere) so it can be used to ask for

duplicates should both keys be lost.

To engage the steering lock, fully turn the

handlebars to the left, insert the key, press

and turn it fully anticlockwise and then

release it.

Indice

Manuali Motociclo popolari di altre marche

OHVALE

OHVALE GP-0 Manuale elenco delle parti

Yamaha

Yamaha Star XV19CTSZ 2009 Manuale utente

KTM

KTM 350 XCF-W USA Manuale utente

HYOSUNG

HYOSUNG ST7 Manuale utente

Husqvarna

Husqvarna FC 250 2016 Manuale utente

Ducati

Ducati SCRAMBLER 800 Manuale di istruzioni

MOTO GUZZI

MOTO GUZZI QUOTA 1100 ES Manuale utente

APRILIA

APRILIA ETV MILLE CAPONORD - PART1 02-2001 Manuale utente

Yamaha

Yamaha 2006 YZF-R1V Manuale utente

KTM

KTM Freeride E-XC 2021 Manuale utente

Fantic

Fantic Enduro 125 Manuale utente

Ducati

Ducati Supersport 750 desmodue Manuale utente

MV Agusta

MV Agusta 2008 F4 312RR 1078 Manuale di istruzioni

Yamaha

Yamaha XVS650A Manuale utente

Yamaha

Yamaha YZF-R6T(C) Manuale

Ducati

Ducati 748 monoposto strada Manuale utente

ATK

ATK 1988 250 Manuale utente

Excelsior-HENDERSON

Excelsior-HENDERSON 1999 HCX Manuale utente