Cardinal CLiC WD-02.1.4 Manuale utente

Rev.A

CARDINAL CLiC WD-02.1.4

GLASS CONTROLLER

INSTALLATION MANUAL

Page 2 of 14

Rev.A

PRECAUTIONS

IMPORTANTSAFETYINSTRUCTIONS

ReadInstructions:Readallsafetyandoperatinginstructionsbeforeusingthedevice.

RetainInstructions:Keepsafetyandoperatinginstructionsforfuturereference.

HeedWarnings:Adheretoallwarningsonthedeviceandintheoperatinginstructions.

FollowInstructions:Followoperatinginstructionsandinstallationinstructions.Failuretofollowtheseinstructions

maydamagetheproductorvoidtheproductwarranty.

Heat:Keepthedeviceawayfromheatsourcessuchasradiators,heatregisters,stoves,etc.

PowerSources:ConnectonlytotheClass2powersupplythatwasincludedwiththedevice.

PowerCordProtection:Routepowersupplycordssothattheyarenotlikelytobesteppedonorpinchedbyitems

placedonoragainstthem.Payingparticularattentiontothecordsatplugs,receptacles,andatthepointatwhich

theyconnecttothedevice.

WaterandMoisture:Donotusethedevicenearwater;forexample,nearasink,inawetbasement,neara

swimmingpool,nearanopenwindow,inadampmechanicalroom,etc.

ObjectandLiquidEntry:Donotallowobjectstofallorliquidstobespilledintotheenclosurethroughopenings.

IndoorUseOnly:Thedeviceshouldbeinstalledandusedindoorsonly.Donotusethedeviceoutdoors.

Servicing:Therearenouserserviceablepartsinsideofthedevice.Donotattempttoopentheenclosureorperform

anyservicebeyondthatdescribedintheoperatinginstructions.Referallotherserviceneedstoqualifiedservice

personnel.

CLiCGlassWiring:Controlleronlydetectsshortsuponglasstransition,willnotprotectagainstashortthatoccurs

whileintheclearstate

Damage:Discontinueuseofthecontrollerifanyofthesehaveoccurred:

Objectshavefallenorliquidhasbeenspilledintothedevice.

Thepowersupplycordortheplughasbeendamaged.

Thedevicedoesnotappeartooperatenormallyorexhibitsamarkedchangeinperformance.

Thedevicehasbeendroppedortheenclosurehasbeendamaged.

WARNING!

OREDUCETHERISKOFFIREORELECTRICSHOCK

DONOTEXPOSETHEDEVICETORAINORMOISTURE

.A

LLPROTECTIVEFILMSMUST

BEREMOVEDFROMTHE

CLiC

GLASSPANELPRIORTOCONNECTINGTHE

WD‐02.1.4



LASS

ONTROLLER

!

SAVETHESEINSTRUCTIONS

Page 3 of 14

Rev.A

DISCLAIMER

FCCINFORMATIONTOUSERS

FCCInformationtoUsers

ThisequipmenthasbeentestedandfoundtocomplywiththelimitsforaClassBdigitaldevice,pursuanttoPart15

SubpartBoftheFCCRules.Theselimitsaredesignedtoprovidereasonableprotectionagainstharmfulinterference

incommercial,industrial,andresidentialinstallations.Thisequipmentgenerates,andcanradiateradiofrequency

energyand,ifnotinstalledandusedinaccordancewiththeinstructionmanual,maycauseharmfulinterferenceto

radiocommunications.However,thereisnoguaranteethatinterferencewillnotoccurinaparticularinstallation.If

thisequipmentdoescauseharmfulinterferencetoradioortelevisionreception,whichcanbedeterminedbyturning

theequipmentoffandon,theuserisencouragedtotrytocorrecttheinterferencebyoneormoreofthefollowing

measures:

Reorientorrelocatethereceivingantenna

Increasetheseparationbetweentheequipmentandreceiver

Connecttheequipmentintoanoutletonacircuitdifferentfromthattowhichthereceiverisconnected

Consultthedealeroranexperiencedradio/TVtechnicianforhelp



Warning:ChangesormodificationsnotexpresslyapprovedbyCardinalIGCompanycouldvoidtheuser’sauthority

tooperatetheequipment.

Page 4 of 14

Rev.A

CONTENTS

TABLEOFCONTENTS

ImportantSafetyInstructions.............................................................................................................................2



FCCInformationtoUsers...................................................................................................................................3



Overview...........................................................................................................................................................5



ImportantNotes................................................................................................................................................5



Compatibility.....................................................................................................................................................5



What’sInTheBox?............................................................................................................................................5



UnpackingandInspection..................................................................................................................................6



ControllerLayout...............................................................................................................................................6



Mounting...........................................................................................................................................................7



Power................................................................................................................................................................7



WireConnectionTerminals................................................................................................................................8



LEDOperatingModes........................................................................................................................................8



SiteWiringandPreparation...............................................................................................................................9



SystemLayoutExamples...................................................................................................................................11



Specifications....................................................................................................................................................12



CommonSymptomsandSolutions....................................................................................................................13



ContactingUs....................................................................................................................................................14



Page 5 of 14

Rev.A

CHAPTER 1 - INTRODUCTION

OVERVIEW

ThisguidepertainstotheCardinalCLiCWD‐02.1.4GlassController.ThisdeviceandtheassociatedCLiCGlassPanel

havebeendesignedasaClass‐3system.Thepurposeofthisdocumentistoprovideguidanceonhowtosetupand

installthedeviceintoacommercial,industrial,orresidentialenvironment.Thisdocumentincludesinstallationsite

requirements,wiringrequirements,systemconnectioninstructions,andbasictroubleshooting.

IMPORTANTNOTES

PleasereadtheseimportantnotesabouttheCLiCWD‐02.1.4GlassController:

TheWD‐02.1.4mustbeinstalledwithinadry,ventilatedareathatmaintainsanormalroomtemperature

(between10°Cto40°C).

AvoidinstallingtheWD‐02.1.4inalocationwhereitwillhaveexposuretoprolongeddirectsunlight.

DonotlettheWD‐02.1.4getwet.Itshouldnotbehandledwithwethandsorplacedinanareawhereit

couldgetwet.

InstallershallusetheprovidedULListedClass2powersupplywitha24Vdcpoweroutputforconnection

tothiscontroller.AllwiringandinstallationshallbeinaccordancewiththeNEC.Usingthewrongtypeof

powersupplymayresultindamage.

Donotdisassemblethedevice.ServiceoftheWD‐02.1.4shouldbeperformedbyauthorizedpersonnel

only.

COMPATIBILITY

ThisdeviceisspecificallydesignedforuseonlywithCLiCGlasspanels.Usethisdeviceonlyforitsintendeduseas

describedintheseinstructions.Donotuseattachmentsnotrecommendedbythemanufacturer.Connectingthis

devicetoloadtypesotherthanCLiCGlasspanelsmaydamagethedeviceortheunauthorizedloads.CardinalIG

Companywillnotberesponsibleforanydamagecausedbyinappropriateusageofthisdevice.

WHAT’SINTHEBOX?

ThefollowingitemsareincludedwiththeCLiCWD‐02.1.4GlassController:

QuickStartGuide

PowerSupply:24vDC100‐wattUL‐1310Class‐2

oWith2‐pinscrewterminalconnector(male)pre‐connected

RubberFeet

CardinalCLiCscrewdriverwithmagnetizedhandle



Page 6 of 14

Rev.A

UNPACKINGANDINSPECTION

AfteropeningtheWD‐02.1.4package,saveallthepackagingmaterialincaseyoueverneedtoshiptheunit.

Thoroughlyinspectandmakesurethedevicesareingoodconditionandthereisnovisibledamage.Ifyouhaveany

doubtabouttheproduct’sintegrity,pleasecontactyourreselleroranauthorizedsupportcenterimmediately.

CHAPTER 2 - FEATURES

CONTROLLERLAYOUT





Page 7 of 14

Rev.A

CHAPTER 3 – INSTALLATION

MOUNTING

TheCLiCWD‐02.1.4GlassControllercanbemountedwithinanenclosureorfreestanding.TheWD‐02.1.4doesnot

needtobemountedneartheCLiCGlasspanel.TheCLiCGlassoutputandthedrycontactinputcanbeextendedup

to100meters(328feet).

MountingPatternDrawings





POWER

ONOTAPPLYPOWERPRIORTOCOMPLETINGALLWIRINGCONNECTIONSANDTERMINATIONS

!

LLPROTECTIVEFILMSMUSTBEREMOVEDFROMTHE

CLiC

GLASSPANELPRIORTOCONNECTINGTHEWD‐

02.1.4GLASSCONTROLLER



Theincludedpowersupply(A/CAdapter)shouldbeconnectedtothe‘24VDCin’and‘Ground’inputterminalson

theWD‐02.1.4.Theterminalconnectorwillbepre‐attachedtothepowersupply.TheCLiCWD‐02.1.4willpoweron

andbeginfunctioninguponapplyingpower.

UsetheprovidedULListedClass2powersupplywitha24VDCpoweroutputforconnectiontothiscontrol.Allwiring

andinstallationshallbeinaccordancewiththeNEC.DonotconnectmorethanoneWD‐02.1.4toapowersupply.



Page 8 of 14

Rev.A

WIRECONNECTIONTERMINALS

Terminal:+24DCIn

Positive24‐voltDCpowersupplyconnection.Thisistopowerthedevice.

Terminal:Ground

Commongroundconnection.Usethisgroundreferenceforpowersupplygroundconnection.

Terminal:GlassOutA

ThisisthesignaloutputusedforcontrollingtheCLiCGlasspanel.BothGlassOutAandGlassOutBmustbe

connectedtotheCLiCGlasspanel.GlassOutAandGlassOutBmusteachconnecttoasingleCLiCglass

panel.Thereisnopolarityontheseconnections.Shortingtheoutputswhilepoweredcoulddamagethe

WD‐02.1.4andshouldbeavoided.

OTE

:OnlyconnectasingleCLiCGlasspanel.MultiplecontrollersmustbeusedformultipleCLiCGlass

panels.

Terminal:GlassOutB

ThisisthesignaloutputusedforcontrollingtheCLiCGlasspanel.BothGlassOutAandGlassOutBmustbe

connectedtotheCLiCGlasspanel.GlassOutAandGlassOutBmusteachconnecttoasingleCLiCglass

panel.Thereisnopolarityontheseconnections.Shortingtheoutputswhilepoweredcoulddamagethe

WD‐02.1.4andshouldbeavoided.

OTE

:OnlyconnectasingleCLiCGlasspanel.MultiplecontrollersmustbeusedformultipleCLiCGlass

panels.

Terminal:DryContactIn

TheWD‐02.1.4hasadrycontactinputthatisusedtoallowexternaldevicestocontrolthestateoftheCLiC

Glasspanel.Thetriggeringdeviceshalluseagroundreferencedswitchorrelaytypeoutput.TheCLiCGlass

panelwillgototheclearstatewhenthecontactclosureisclosed.TheCLiCGlasspanelwillgototheprivate

statewhenthecontactclosureisopen.

Terminal:Ground

Commongroundconnection.Usethisgroundreferencefordrycontactgroundconnections.

LEDOPERATINGMODES

TheLEDsareincludedtoindicatethestatusoftheCLiCcontroller.ThebehavioroftheLEDswillchangeunder

differentoperatingconditions.Thefollowingtabledetailsthatbehavior:

BlueLEDGreenLEDDescription

OffOffNopowertotheunit

SolidOffControllerhaspowerandtheCLiCGlasspanelisprivate

SolidSolidControllerhaspowerandtheCLiCGlasspanelisclear

SolidFlashingControllerhasdetectedawiringissuebetweentheGlassOutterminalsand

theCLiCGlasspanel.





Page 9 of 14

Rev.A

INSTALLATION AND OPERATION

SITEWIRINGANDPREPARATION

WiringfromtheWD‐02.1.4totheCLiCGlasspanelshouldberunpriortotheCLiCGlasspanelinstallation.Allwiring

mustbeperformedinaccordancewiththeapplicablebuildingcodesandelectricalwiringrequirementsasdenoted

forClass3systemsoftheNationalElectricCode(NEC).Allwiringshouldbecompletedbyaqualifiedandexperienced

technician.

Placement

TheWD‐02.1.4shouldbeinstalledwithinanaccessibleareawithadequateproximitytoplugthepowersupplyinto

astandard120vacoutlet.Theincludedpowersupplyismountableifdesired.Pleaseallowadequatespacefor

ventilationandheatdissipationaroundthedevices.

NOTE

:

INTHEEVENTTHATTHESEDEVICESAREUSEDINA

COMMERCIALAPPLICATIONANDINSTALLEDWITHINANAIR‐EXCHANGESPACE(PLENUMAIRSPACE)THEYSHALLBE

MOUNTEDWITHINANAPPROPRIATECERTIFIEDPLENUM‐SAFEENCLOSURE.



WireSizeandMaximumLength

ThewireutilizedforconnectionsontheWD‐02.1.4shallbeaminimumof18AWG.Itisimportantthatthecorrect

gaugewireisusedtoassurethecorrectvoltageandsignalreachestheCLiCGlasspanel.Themaximumwiredistance

betweentheWD‐02.1.4andtheCLiCGlasspanelis100meters(328feet).

WiringTerminationatCLiCGlassPanel

ThewiringterminationsattheCLiCGlasspanelwilloccurattheuppercornersoftheglasspanel.Therewillbeone

wireleadateachcorner.Therefore,theframingandpre‐wiringfortheCLiCGlasspanelmustprovideenough

roomalongthetopedgetohidethewireandallowforsecurewireconnections.Seethediagrambelow:

(Note:Customwirelocationsmaybeused)



WireLeadLocations

CLiCGlassPanel

Page 10 of 14

Rev.A

IMPORTANT:REMOVALOFPROTECTIVEFILMSCANPRODUCEELECTRICSHOCKSANDSPARKSWHICHCOULDCAUSE

DAMAGETOCONNECTEDELECTRONICS!

ALLPROTECTIVEFILMSMUSTBEREMOVEDPRIORTOCONNECTIONOFTHEGLASSCONTROLLER!

WD‐02.1.4DryContactConnections

TheWD‐02.1.4hasbeendesignedtoaccommodatemanyinstallationconfigurationsandscenariosbyutilizinga

flexibleDryContactInputCircuit.Thiscircuitallowsawidevarietyofswitchdevices,relays,orotherautomation

controllerstoprovideendusercontroloftheCLiCGlasspanel.Thetriggeringdeviceshalluseagroundreferenced

switchorrelaytypeoutput.ThereshallbenopowerapplieddirectlytotheDryContactconnections.Thesedevices

caninclude,butarenotlimitedto:

Standardlightswitches

NOTE:

U

SEDFORLOW

‐

VOLTAGETRIGGER

ONLY

AND

NOT

CONNECTEDTOPOWER



OccupancySensors

RelaysandSwitchoutputsfromautomationcontrollersorremote‐controlsystems

DoorjambPlungerSwitches

MagneticSecurityStyleDoorSwitches



Indice

Altri manuali Cardinal Controllori

Cardinal

Cardinal CLiC HC-198 Manuale utente

Manuali Controllori popolari di altre marche

Digiplex

Digiplex DGP-848 Istruzioni operative

YASKAWA

YASKAWA SGM series Manuale utente

Sinope

Sinope Calypso RM3500ZB Manuale utente

Isimet

Isimet DLA Series Style 2 Manuale di installazione

LSIS

LSIS sv-ip5a Manuale utente

Rockwell Automation

Rockwell Automation 1769-L31 Manuale utente

Airflow

Airflow Uno hab Manuale utente

ABB

ABB ACS580-01 drives Manuale utente

Panasonic

Panasonic GM1 Series Manuale utente

Emerson

Emerson SW93 Manuale utente

AutoAqua

AutoAqua Smart ATO micro SATO-120P Manuale utente

Panasonic

Panasonic FP? Positioning Unit RTEX Manuale utente

Samson

Samson Type 5824 Manuale di servizio

Alpha IP

Alpha IP MIOB 21001 Manuale utente

Siemens

Siemens OpenAir GMA 1 Series Manuale utente

Surecom

Surecom SR-629 Manuale utente

Fishman

Fishman TriplePlay Manuale utente

Regulus

Regulus SRS1 T Manuale utente