Dometic 8700 Series MasterFlush Manuale utente

Dometic8700

Awning

Installation and Operating Manual

AWNINGS

8700 SERIES

Dometic8700_IOM_APAC(en).book Seite 1 Montag, 16. März 2020 6:28 18

protected by copyright and design law. The underlying technical design and the

products contained herein may be protected by design, patent or be patent

pending. The trademarks mentioned in this manual belong to Dometic Sweden AB.

All rights are reserved.

Dometic8700_IOM_APAC(en).book Seite 2 Montag, 16. März 2020 6:28 18

Dometic8700

Please read this instruction manual carefully before installation and first

use, and store it in a safe place. If you pass on the product to another

person, hand over this instruction manual along with it.

Table of contents

1 Explanation of symbols. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

2 Important safety instructions for installation. . . . . . . . . . . . . . . . . . . . . . . . . . .4

3 Scope of delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

4 Intended use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

5 Technical description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

6 Installing the awning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7

7 Using the awning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18

8 Cleaning and maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

9 Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

10 Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

Dometic8700_IOM_APAC(en).book Seite 3 Montag, 16. März 2020 6:28 18

Explanation of symbols Dometic8700

1 Explanation of symbols

2 Important safety instructions for

installation

Please observe the prescribed safety instructions and stipulations from the

vehicle manufacturer and service workshops.

The manufacturer accepts no liability for damage in the following cases:

• Faulty assembly or connection

• Damage to the product resulting from mechanical influences

• Alterations to the product without express permission from the manufacturer

• Use for purposes other than those described in the operating manual

!WARNING!

• If you do not have sufficient technical knowledge for installing

components in vehicles, you should have a specialist fit the awning to

your vehicle.

WARNING!

Safety instruction: Indicates a hazardous situation that, if not avoided,

could result in death or serious injury.

CAUTION!

Safety instruction: Indicates a hazardous situation that, if not avoided,

could result in minor or moderate injury.

NOTICE!

Indicates a situation that, if not avoided, can result in property damage.

NOTE

Supplementary information for operating the product.

Dometic8700_IOM_APAC(en).book Seite 4 Montag, 16. März 2020 6:28 18

Dometic8700 Scope of delivery

3Scopeofdelivery

The sail trackis not supplied by Dometic and must be purchased separately and

installed prior to the installtion of the awning and hardware.

Fabric roller tube assembly (must be ordered separately)

Hardware (must be ordered separately)

No. in

fig. 1Quantity Description

1 1 Fabric roller tube assembly

4x4x 2x 2x 2x 2x 2x 2x

45 3

Dometic8700_IOM_APAC(en).book Seite 5 Montag, 16. März 2020 6:28 18

Intended use Dometic8700

4 Intended use

The intended use of the awning is to provide shade.

The awning is to be used whilst the vehicle is stationary only.

5 Technical description

No. in

fig. 2Quantity Description

2 2 Hardware assemblies

3 1 Door Roller Kit

4 2 Bottom mounting bracket

5 1 Pull rod

6 1 set Fixing materials

– 1 Installation and Operating Manual

Hardware

878HT-WH

878HT-BK

(Tall – Black or white)

878HS-WH

878HS-BK

(Standard – Black or

white)

Height range 1892 mm – 2235 mm 1626 mm – 1930 mm

Main arm length 1854 mm 1549 mm

Adjustable arm length 1448 mm 1448 mm

Main rafter length 1676 mm 1372 mm

Secondary rafter length 826 mm 1130 mm

Dometic8700_IOM_APAC(en).book Seite 6 Montag, 16. März 2020 6:28 18

Dometic8700 Installing the awning

6 Installing the awning

6.1 Notes on the installation

!WARNING! Failure to obey these warnings could result in death

or serious injury.

Fire hazard/Electrocution hazard

• Make sure there are no obstacles (wires, pipes, etc.) on the RV‘s roof

and inside the RV‘s walls.

•Shutoff gas supply to the RV.

• Disconnect AC power from the RV, and disconnect the positive

+12 Vgterminal from the supply battery(s) before drilling or cutting

into the RV.

Impact or crush hazard

• The device may become unstable and could detach, bend, or col-

lapse. Make sure mounting surface on the RV is flat, has solid structural

backing where fasteners penetrate the surface, and will safely and

securely support the product.

• Find a solid structure in the RV wall for support of top mounting

brackets.

Impact or pinch hazard

• Rapid casting spin off may occur. Spring tension will attempt to close

the awning quickly and unexpectedly.

Do not remove the nail from the torsion rod (at end cap) untilboth top

castings are secured to the corresponding main arms, and the awning

safety lock lever is in roll down position.

Straighten, remove, and discard the nail from the left end of the

torsion rod only.

!CAUTION! Failure to obey these cautions could result in minor or

moderate injury.

Health hazard

• Use proper lifting technique and control when lifting the device.

• Maintain a horizontal distance of at least 410 mm between the fully

open awning and any permanent objects.

Dometic8700_IOM_APAC(en).book Seite 7 Montag, 16. März 2020 6:28 18

Installing the awning Dometic8700

ANOTICE! Damage hazard

• Ensure that the awning rail is parallel to the RV floor, and is not warped

or curved before installing awning fabric. If the awning rail is not

straight, the awning fabric may wrinkle or stretch.

• Install back channels on a flat surface, level, and keep parallel with

each other to ensure correct function and appearance.

• Use sealant after cleaning the parts and surfaces where fasteners enter

the RV’s roof and/or walls to prevent moisture from entering.

• Observe the sealant manufacturer's instructions.

INOTE

• A stepladder may be necessary to reach awning rail.

• Make sure arm assemblies do not restrict use of doors, windows, etc.

• It‘s recommended 2 people install the awning. There are instances

detailed in the installing instructions that require 3 people to fit the

awning.

Dometic8700_IOM_APAC(en).book Seite 8 Montag, 16. März 2020 6:28 18

Dometic8700 Installing the awning

6.2 Installing the awning

➤Proceed as shown to install the awning (fig. 3, page 10 to fig. e, page 17).

INOTE

• The awning length is set to suit the Dometic 8300 awning length.

• Adjust the RH top casting to outer hole (fig. 3, page 10) to fit the

Dometic 8500 awning length.

• The LH top casting does not require adjustment.

NOTICENOTICE

Dometic8700_IOM_APAC(en).book Seite 9 Montag, 16. März 2020 6:28 18

Installing the awning Dometic8700

25 mm

Dometic8700_IOM_APAC(en).book Seite 10 Montag, 16. März 2020 6:28 18

Altri manuali per 8700 Series MasterFlush

Questo manuale è adatto per i seguenti modelli

Indice

Altri manuali Dometic Accessori

Dometic

Dometic 8700 Series MasterFlush Manuale utente

Dometic

Dometic PERFECTWALL PW3800 Manuale utente

Dometic

Dometic TROPICOOL TF14 Manuale utente

Dometic

Dometic CF-110 Manuale utente

Dometic

Dometic TROPICOOL TCX07 Manuale utente

Dometic

Dometic 935002.120 Manuale

Dometic

Dometic CoolFreeze CF-35 Manuale utente

Dometic

Dometic Waeco CoolFun PB 306 Manuale utente

Dometic

Dometic CoolFreeze CF-18 Manuale utente

Dometic

Dometic 3316518 Manuale utente

Dometic

Dometic Club/Ace AIR Pro Extensions Manuale utente

Dometic

Dometic CFX3 35 Manuale utente

Dometic

Dometic CFX3 Series Manuale utente

Dometic

Dometic 9108672221 Manuale utente

Dometic

Dometic 9200 Series Manuale utente

Dometic

Dometic RTX1000 Manuale utente

Dometic

Dometic PERFECTROOF PR2000 Manuale utente

Dometic

Dometic Kampa RALLY AIR ALL-SEASON 330 D/A Manuale utente

Dometic

Dometic Coolmatic CSMP2 Manuale utente

Dometic

Dometic CFX28 Manuale utente

Dometic

Dometic Cabana Lightweight RV Dome Awning Manuale utente

Dometic

Dometic POWER AWNING PRO Manuale

Dometic

Dometic PERFECTROOF PR2500 Manuale utente

Dometic

Dometic CFX3 Series Manuale utente

Manuali Accessori popolari di altre marche

Hillco

Hillco 2810 Manuale utente

Siemens

Siemens QSA2700D Manuale dell'operatore

Contours

Contours ZY024 Manuale utente

Saivod

Saivod VS621 Manuale utente

Virtuox

Virtuox VirtuCLEAN 2.0 Manuale utente

SCE

SCE ENVIRO-THERM SCE-TE170B24VSS Manuale utente

Z-Wave

Z-Wave HSD-200Z Manuale utente

turck

turck FMX-IM-2UPLI63FX Manuale utente

Decagon Devices

Decagon Devices 10HS Manuale utente

UPPAbaby

UPPAbaby Cup Holder Manuale utente

Elko

Elko SmartSensor Leakage Wireless Manuale utente

Grizzly

Grizzly H8371 Manuale utente

Panasonic

Panasonic HG-T Series Manuale utente

IFM Electronic

IFM Electronic Efector 250 Series Guida di riferimento

DigiDesign

DigiDesign 888/24 I/O Manuale utente

PROZIS

PROZIS QUAY Manuale utente

patagonia

patagonia PSI Vest Manuale utente

SFC Energy

SFC Energy EFOY GO! Manuale utente