Emerson Fisher FIELDVUE DVC6200 SIS Guida alla configurazione

www.Fisher.com

Fisher™FIELDVUE™DVC6200 SIS Digital Valve

Controller PST Calibration and Testing using

ValveLink™Software

The test procedure contained in this Instruction Manual Supplement is to be considered as a guideline only and should

be modified to address site‐specific requirements. Use this procedure in conjunction with the DVC6200 Series quick

start guide (D103556X012) and the DVC6200 SIS instruction manual (D103557X012). In addition, exercise good

engineering practices and abide by specific plant safety guidelines for safe operation.

WARNING

This document is not intended to be used as a stand‐alone document. It must be used in conjunction with the following

documents:

Safety Manual for FIELDVUE DVC6200 SIS Digital Valve Controller and Position Monitor (D103601X012)

Fisher FIELDVUE DVC6200 SIS Instruction Manual (D103557X012)

Failure to use this instruction manual supplement in conjunction with the above referenced manuals could result in

personal injury or property damage. If you have any questions regarding these instructions or need assistance in obtaining

any of these documents, contact your Emerson sales office.

For additional information on Partial Stroke Testing and associated parameters refer to Partial Stroke Test Information

on page 19.

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

PST Calibration

This document covers the basic PST calibration, as well as details for making adjustments to the normal end, using

Advanced Settings (see figure 11).

Figure 1. Calibration > Partial Stroke

Confirm SIS Tier

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 2. Set Instrument Out of Service and start Partial Stroke Test calibration

Refer to figure 11 for

information on Advanced

Settings

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 3. Enter the Desired Outgoing Ramp Rate

Supports separate ramp

rates for outing and

incoming strokes

Figure 4. Enter the Desired Incoming Ramp Rate

Additional ramp

rates for the

incoming stroke

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 5. Enter the Travel Target Movement

Target Travel Movement is the

percentage of travel from the

normal end

Figure 6. Partial Stroke Calibration progress

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 7. Partial Stroke Calibration progress

Will calibrate to 30% from

the normal end

Figure 8. Configuring SIS Triggers

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 9. Partial Stroke Calibration Progress

Figure 10. Calibration Procedure Complete

List of parameter values

being downloaded to the

device

If you need to make adjustments to the normal end default settings, select Advanced Settings, as shown in figure 11,

and make the necessary adjustments.

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 11. Select Advanced Settings to Make Adjustments to the Normal End

Select to define the

normal end

Figure 12. Set Travel High End

Defines the normal end of travel

(where the valve is when the

process is running normally)

The point at which valve

seating occurs will vary slightly

every time. Do not set this

higher than 99.5% or lower

than 0.5%.

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Figure 13. Enter Target Travel Movement

Figure 14. Partial Stroke Calibration Progress

Running a PST calibration will enable Short Duration PST. If this is not desired, refer to figure 24 for information on

disabling Short Duration PST.

Instruction Manual Supplement

D104299X012

DVC6200 SIS

October 2018

Configuration

After successfully calibrating the valve for PST go to the Detailed Setup SIS/Partial Stroke tab and verify the values for

the parameters in the Test Configuration group box are correct. Then go to the SIS Options group box and enable any

of the behaviors required for the PST.

Figure 15. Verify Test Configuration and Test Acceptance Criteria

Altri manuali per Fisher FIELDVUE DVC6200 SIS

Indice

Altri manuali Emerson Controllori

Emerson

Emerson FISHER CS200 Series Manuale utente

Emerson

Emerson Fisher 67CS Manuale utente

Emerson

Emerson Fisher Fieldvue DVC6030f Manuale utente

Emerson

Emerson Dixell XWi70K Schema elettrico

Emerson

Emerson FISHER T208 Series Manuale utente

Emerson

Emerson dixell XW60K Manuale utente

Emerson

Emerson Dixell XR30CX-4S1C1 Schema elettrico

Emerson

Emerson MR105 Manuale utente

Emerson

Emerson Fisher Y696 Manuale utente

Emerson

Emerson SP Manuale utente

Emerson

Emerson Bettis GVO LP DA Manuale utente

Emerson

Emerson Fisher Accu-Pressure Y693 Manuale utente

Emerson

Emerson 818-2050 Guida all'installazione

Emerson

Emerson FISHER 657 Manuale utente

Emerson

Emerson Fisher 656 Manuale utente

Emerson

Emerson FISHER SR8 Manuale utente

Emerson

Emerson Digistart IS1x0043B series Manuale utente

Emerson

Emerson Liebert PEX+ Series Manuale utente

Emerson

Emerson Fisher 299HR Manuale utente

Emerson

Emerson Bettis TEC2 Manuale utente

Emerson

Emerson Fisher 1069 Manuale utente

Emerson

Emerson REGAL 3F Manuale utente

Emerson

Emerson EXD-HP1 Manuale utente

Emerson

Emerson Fisher HSR Istruzioni per il montaggio

Manuali Controllori popolari di altre marche

Digiplex

Digiplex DGP-848 Istruzioni operative

YASKAWA

YASKAWA SGM series Manuale utente

Sinope

Sinope Calypso RM3500ZB Manuale utente

Isimet

Isimet DLA Series Style 2 Manuale di installazione

LSIS

LSIS sv-ip5a Manuale utente

Rockwell Automation

Rockwell Automation 1769-L31 Manuale utente

Airflow

Airflow Uno hab Manuale utente

ABB

ABB ACS580-01 drives Manuale utente

Panasonic

Panasonic GM1 Series Manuale utente

AutoAqua

AutoAqua Smart ATO micro SATO-120P Manuale utente

Panasonic

Panasonic FP? Positioning Unit RTEX Manuale utente

Samson

Samson Type 5824 Manuale di servizio

Alpha IP

Alpha IP MIOB 21001 Manuale utente

Siemens

Siemens OpenAir GMA 1 Series Manuale utente

Surecom

Surecom SR-629 Manuale utente

Fishman

Fishman TriplePlay Manuale utente

Regulus

Regulus SRS1 T Manuale utente

3M MicroTouch EX113 Manuale utente