Flight Display Systems FD600CAM-2 Manuale utente

Document Number:

MAN – FD600CAM-2/FD600CAM-2

Ver 28V

Rev:

Revision Date:

03/16/2011

Page 1 of 12

FD600CAM-2/FD600CAM-2 Ver 28V

Installation and Operation Manual

Glareshield Camera

TECHNICAL SUPPORT

678-867-6717, or

www.FlightDisplay.com

Document Number:

MAN – FD600CAM-2/FD600CAM-2

Ver 28V

Rev:

Revision Date:

03/16/2011

Page 2 of 12

FD600CAM-2/FD600CAM-2 Ver 28V

Glareshield Camera

Flight Display Systems

1765 Grassland Parkway

Alpharetta, GA 30004

678-867-6717 Phone

678-867-6742 Fax

[email protected]

www.flightdisplay.com

For the most current copy of all product manuals, please visit our website at

www.flightdisplay.com

Document Number:

MAN – FD600CAM-2/FD600CAM-2

Ver 28V

Rev:

Revision Date:

03/16/2011

Page 3 of 12

Table of Contents

General Information......................................................................................................................4

1. Front View..........................................................................................................................4

2. Specifications .....................................................................................................................4

Installation Instructions .............................................................................................................5

1. Power ..................................................................................................................................5

Wiring Suggestions .....................................................................................................................6

1. Composite Wiring.............................................................................................................6

2. Power & Ground Wiring .................................................................................................6

3. Power/Video .....................................................................................................................7

Technical Drawing.......................................................................................................................8

Troubleshooting...........................................................................................................................9

1. Video Noise........................................................................................................................9

2. VGA Shadowing ...............................................................................................................9

3. Snow or Sweeping Lines..................................................................................................9

4. No Power to Monitor, or No Video Input.....................................................................9

5. Color Distortion.................................................................................................................9

6. Remote Control Inoperable .............................................................................................9

Technical Support......................................................................................................................10

Instructions for Continued Airworthiness ...........................................................................10

Warranty ......................................................................................................................................11

Log of Revisions.........................................................................................................................12

Document Number:

MAN – FD600CAM-2/FD600CAM-2

Ver 28V

Rev:

Revision Date:

03/16/2011

Page 4 of 12

General Information

The FD600CAM-2 and the FD600CAM-2 Ver 28V are Glareshield Cameras. This small

color camera, when mounted in the cockpit, will provide passengers with an opportunity to

observe taxi, take-off, and landing, adding a whole new dimension to the In-Flight

Entertainment experience!

Front View

Specifications

Video System

NTSC or PAL

Video Output

1Vp-p, 75 Ohms

Camera Sensor

1/3” Color CCD

Camera Lens

4.0mm & 8.00mm (included)

Camera Shutter Speed

F 1.2

Picture Element

811H x 508V NTSC

(795H x 596V PAL)

Horizontal Resolution

480 Lines

Scanning System

2:1 Interlace

Signal to Noise Ratio

>48 dB

Minimum Illumination

.05 Lux

Dimensions, Camera

1.35” (W) x 1.35” (H) x 2.92” (D)

Dimensions, Mount

2.0” (W) x 1.75” (H) x 1.75” (D)

Weight

6 oz

Power

FD600CAM-2 - 12VDC @ 90 mA

FD600CAM-2 Ver 28V – 28VDC @ 45 mA

Operating Temperature

14°F to 140°F

Document Number:

MAN – FD600CAM-2/FD600CAM-2

Ver 28V

Rev:

Revision Date:

03/16/2011

Page 5 of 12

Installation Instructions

All cabin entertainment equipment, such as the FD600CAM-2 and the FD600CAM-2 Ver

28V, should be installed on a non-essential bus and have a dedicated circuit breaker. It is

a requirement that a switch be installed in the cockpit so that the pilot can de-energize the

entertainment system should it become necessary.

Mounting from the cockpit headliner is suggested. Excessive sunlight will make the video

image hard to see. Mounting inside the cockpit and out of direct sunlight will provide a

“visor” to the camera lens.

Remember to set the camera pointing down at an approximately 60° angle, as this will

optimize the picture for takeoff and landings. When looking at the image while on the

ground have the horizon 2/3 of the way up the video screen in the cabin.

Power

The FD600CAM-2 is a 12VDC camera that requires 90mA power and can operate at 9 -

15VDC. The FD600CAM-2 Ver 28V is a 28VDC camera that requires 45mA power and

can operate at 15 - 29VDC.

Document Number:

MAN – FD600CAM-2/FD600CAM-2

Ver 28V

Rev:

Revision Date:

03/16/2011

Page 6 of 12

Wiring Suggestions

All shields should be grounded to the connector at the source, and floating at the display.

Avoid routing video wiring parallel to:

•AC wiring

•Strobe wiring

•DC motor supply cables

•Inverter cabling

•Or any other potential noise source.

Composite Wiring

Recommended cable for s-video/composite and audio purposes is PIC 75 Ohm Coax, P/N

V76261. This is a lightweight, flexible, and low signal loss cable which meets FAA

flammability requirements of FAR 23.1359(d), FAR 25.853(a) and FAR 25.869(a)(4).

Similar aviation coaxial cable can be used from other vendors, as well. Some aircraft are

prone to AC noise - we recommend adding to the composite source a 75Ohm video

isolation transformer such as Deerfield Laboratory, Inc. Part No. 162-1

(www.deerfieldlab.com, (650) 632-4090). In most cases this should be added to the video

output of the source.

Power and Ground Wiring

22 AWG wire is recommended for Power and Ground applications.

Document Number:

MAN – FD600CAM-2/FD600CAM-2

Ver 28V

Rev:

Revision Date:

03/16/2011

Page 7 of 12

Power/Video

Standard Density DB-9 Receptacle (supplied)

Connector P/N: M24308/2-281 or Equivalent

Crimp Contacts P/N: M39029/63-368 or Equivalent

Number

FD600CAM-2

Description

FD600CAM-2 Ver 28V

Description

12VDC Power

28VDC Power

12VDC Ground

28VDC Ground

N/C

Composite Video – Shield

Composite Video – Signal

N/C

Document Number:

MAN – FD600CAM-2/FD600CAM-2

Ver 28V

Rev:

Revision Date:

03/16/2011

Page 8 of 12

Technical Drawing

Document Number:

MAN – FD600CAM-2/FD600CAM-2

Ver 28V

Rev:

Revision Date:

03/16/2011

Page 9 of 12

Troubleshooting

Video Noise

Check for an incorrect ground in the installation wiring. See specific examples of video

noise below, or visit http://flightdisplay.com/Grounding.pdf

VGA Shadowing

Most of shadowing problems are due to shielding on the wire. Locate the point where all of

the shields are connected. Cut away the shields, one at a time, while viewing the display on

the screen to observe which shield is causing the noise. Cutting away one shield at a time

will allow you to focus and isolate the video noise issue.

•Twisted pair wiring is prone to video noise. ECS VGA Wire

(Detailed under “Video Wiring Suggestions”) is recommended.

Snow or Sweeping Lines

Lines that slowly sweep up and down are a result of AC noise. This AC noise can be

generated by a power cart on the aircraft. Take the power cart off of the aircraft. Be careful

of inverter wiring, which can also cause noise. Stand off the wires, if necessary.

If snow or sweeping lines persist, it is possible that the ground is at an incorrect point in the

aircraft. Try moving the ground to another location.

No power to Monitor, or No video Input

• Verify correct wiring. Check the base receptacle connectors for possibly damaged pins.

• Check that the video source is:

1. Powered on,

2. In Play mode, and

3. Displaying video.

Color Distortion

• Adjust brightness and contrast settings using the buttons on the monitor.

Remote Control Inoperable

• Confirm that the infrared eye on the LCD screen is visible.

• Replace battery in remote control.

Document Number:

MAN – FD600CAM-2/FD600CAM-2

Ver 28V

Rev:

Revision Date:

03/16/2011

Page 10 of 12

Technical Support

Should you have any questions concerning this product or other Flight Display Systems

products, please contact our Product Support representatives at (678) 867-6717.

Flight Display Systems

1765 Grassland Parkway

Alpharetta, GA 30004

Phone: 678-867-6717

Fax: 678-867-6742

Email: [email protected]

For further product information, technical data and sample wiring diagrams, please click on

the Dealers section of our web site at www.flightdisplay.com

Instructions for Continued Airworthiness

The FD600CAM-2 and the FD600CAM-2 Ver 28V is designed not to require regular

general maintenance.

Questo manuale è adatto per i seguenti modelli

Indice

Manuali Macchina fotografica digitale popolari di altre marche

Mercury

Mercury 350K Manuale utente

Pentax

Pentax Optio LS 465 Manuale utente

Sanyo

Sanyo VPC-S1085 Manuale utente

GE SMART A1255 Manuale utente

Point Grey

Point Grey Gazelle Manuale utente

Nikon

Nikon COOLPIX A Manuale utente

Pentax

Pentax P-5 Manuale utente

BlazeVideo

BlazeVideo A280 Manuale utente

Sony

Sony MCA-20 Manuale utente

Sony

Sony Alpha DSLR-A290 Manuale utente

ATIK Cameras

ATIK Cameras One Manuale utente

CohuHD Costar

CohuHD Costar 3930 Series Manuale utente

Leica

Leica M10-R Manuale utente

FujiFilm

FujiFilm FinePix A700 Manuale utente

Lorex

Lorex LNZ81P25 Series Manuale utente

GE J1470S Manuale utente

Sony

Sony A6700 Guida utente

Canon

Canon EOS ELAN7 Manuale utente