Flight Display Systems FD70CV-M Manuale utente

Rev:

Revision Date:

06/19/2012

Page 1 of 14

MAN – FD70CV-M

FD70CV-M

Installation and Operation Manual

7” Widescreen LCD

TECHNICAL SUPPORT

678-867-6717, or

www.FlightDisplay.com

Rev:

Revision Date:

06/19/2012

Page 2 of 14

MAN – FD70CV-M

FD70CV-M

7” Widescreen LCD

Flight Display Systems

1765 Grassland Parkway

Alpharetta, GA 30004

678-867-6717 Phone

678-867-6742 Fax

[email protected]

www.flightdisplay.com

For the most current copy of all product manuals, please visit our website at

www.flightdisplay.com

Rev:

Revision Date:

06/19/2012

Page 3 of 14

MAN – FD70CV-M

Table of Contents

General Information......................................................................................................................4

1. Front View..........................................................................................................................4

Specifications................................................................................................................................5

Installation Instructions .............................................................................................................5

1. Power ..................................................................................................................................6

Video Wiring Suggestions .........................................................................................................6

1. S-Video/Composite & Audio Wiring............................................................................6

2. VGA Wiring.......................................................................................................................7

3. HDMI..................................................................................................................................7

4. Power & Ground Wiring..................................................................................................8

5. Power/Video .....................................................................................................................8

Operations Instructions ..............................................................................................................9

1. Monitor Button Controls..................................................................................................9

Technical Drawing.....................................................................................................................10

Troubleshooting.........................................................................................................................11

1. Video Noise......................................................................................................................11

2. VGA Shadowing .............................................................................................................11

3. Snow or Sweeping Lines................................................................................................11

4. No Power to Monitor, No Video Input........................................................................11

5. Color Distortion...............................................................................................................11

6. Remote Control Inoperable ...........................................................................................11

Technical Support......................................................................................................................12

Instructions for Continued Airworthiness ...........................................................................12

Warranty ......................................................................................................................................13

Log of Revisions.........................................................................................................................14

Rev:

Revision Date:

06/19/2012

Page 4 of 14

MAN – FD70CV-M

General Information

The FD70CV-M is the latest version of our popular 7” Widescreen LCD. The all metal case

is designed for installation in light jets, turboprops and piston aircraft. This unit is ideal in

situations where bulkhead space forward and aft is very limited. This unit is a full function

7-inch LCD housed in a metal case that will fit on most aircraft. The metal case makes it

easy to mount directly to the bulkhead or build the units into the cabinet wall. Mounting

holes are easily accessible on both sides of the unit.

Front View

Rev:

Revision Date:

06/19/2012

Page 5 of 14

MAN – FD70CV-M

Specifications

Display Type

7” TFT Color LCD

Supported Resolutions

640x480 1024x768

Display Brightness

450 cd/ m2

Contrast Ratio

500:1

Dimensions

6.80”(W) x 4.75”(H) x 1.20”(D)

LCD Dimension

6.00”(W) x 3.60”(H)

Weight

1 lb 5 oz

Viewing Angle

140 120

Power

12VDC @ .6 Amps

28VDC @ .3 Amps

Operating Temperature

0-50° C (32-122° F)

PC Video Input

VGA (Analog RGB 15 pin D-sub)

Standard Video Input

2 Composite Video

Video Type Supported

NTSC, PAL

Screen Control

On-Screen Display Menu

Remote Control

IR, included

Materials

Aluminum

DO-160 Testing

Section 21, Category B

Installation Instructions

All cabin entertainment equipment, such as the FD70CV-M, should be installed on a non-

essential bus and have a dedicated circuit breaker. It is a requirement that a switch be

installed in the cockpit so that the pilot can de-energize the entertainment system should it

become necessary.

The order in which you proceed is up to the installation center. We suggest that you first

look at the mounting plate prior to installing the LCD to make sure you have the proper

room and conditions in the aircraft to mount the display to the wall or bulkhead. Once it has

been determined that you have sufficient room and mounting locations for the FD70CV-M,

then it would be appropriate to start mounting the base to the frame. The unit can be

mounted to the bulkhead with fasteners which are located on the rear cover, or installer can

use “L” brackets and attach to the sides (2 located on each side of the display), from back

or sides using the 8-32 fastener. Length of the screw must not exceed .250” to the inside

of the screw. Screw length is dependent upon thickness of the “L” brackets. NOTE: Care

should be taken to ensure the unit is not installed in an area with poor ventilation, or

in an area with excessive heat.

Rev:

Revision Date:

06/19/2012

Page 6 of 14

MAN – FD70CV-M

Power

This is a 12-28VDC monitor that requires 0.3 Amps (@28V) to 0.6 Amps (@12V) of power

to operate.

Video Wiring Suggestions

All shields should be grounded to the connector at the source, and floating at the display.

Avoid routing video wiring parallel to:

 AC wiring

 Strobe wiring

 DC motor supply cables

 Inverter cabling

 Or any other potential noise source.

S-Video/Composite and Audio Wiring

Recommended cable for s-video/composite and audio purposes is PIC 75 Ohm Coax, P/N

V75268. This is a lightweight, flexible, and low signal loss cable which meets FAA

flammability requirements of FAR 23.1359(d), FAR 25.853(a) and FAR 25.869(a)(4).

Similar aviation coaxial cable can be used from other vendors, as well.

Some aircraft are prone to AC noise - we recommend adding to the composite source a

75Ohm video isolation transformer such as Deerfield Laboratory, Inc. Part No. 162-1

(www.deerfieldlab.com, (650) 632-4090). In most cases this should be added to the video

output of the source.

Rev:

Revision Date:

06/19/2012

Page 7 of 14

MAN – FD70CV-M

VGA Wiring

Recommended cable for VGA purpose is ECS P/N 453005. This is a single shielded cable

containing 5 separate coaxial cables, color-coded to match the functions of the wires.

We recommend coax cables be terminated using solder sleeve coaxial cable terminators

such as Raychem Part Number CWT-4174-W122-5/9.

Rev:

Revision Date:

06/19/2012

Page 8 of 14

MAN – FD70CV-M

Power and Ground Wiring

22 AWG wire is recommended for Power and Ground applications.

Power/Video

Pin out for P1 (High Density DB-15 Receptacle)

Connector P/N: M24308/2-286 or Equivalent

Crimp Contacts P/N: M39029/57-354 or Equivalent

Number

Description

12-28VDC Power

12-28VDC Ground

N/C

Composite Video 1 - Signal

Composite Video 1 - Shield

N/C

Composite Video 2 - Signal

Composite Video 2 - Shield

Red Video (Pin 1 on Standard VGA)

Green Video (Pin 2 on Standard VGA)

Blue Video (Pin 3 on Standard VGA)

Red Ground (Pin 6 on Standard VGA)

Green Ground (Pin 7 on Standard VGA)

Horizontal Sync (Pin 13 on Standard VGA)

Vertical Sync (Pin 14 on Standard VGA)

Rev:

Revision Date:

06/19/2012

Page 9 of 14

MAN – FD70CV-M

Operation Instructions

The FD70CV-M is continuously on but can be de-energized by removing power from the

entertainment system. No pilot or aircrew action is necessary during flight or ground

operation. Passengers can change the video output from the FD70CV-M using the video

source select switch on the LCD monitor, or remotely throughout the cabin with the

included IR remote.

Monitor Control Buttons

BUTTON

FUNCTION

DESCRIPTION

POWER

Press to turn the monitor on if currently off. Hold to turn the

monitor off.

SOURCE

Press to switch between sources.

Press to increase the value of a menu item.

DOWN

Press to decrease the value of a menu item.

Press to activate Menu.

Rev:

Revision Date:

06/19/2012

Page 10 of 14

MAN – FD70CV-M

Technical Drawing

Troubleshooting

Indice

Altri manuali Flight Display Systems TV LCD

Flight Display Systems

Flight Display Systems FD201LIFT Manuale utente

Flight Display Systems

Flight Display Systems FD220CV Manuale utente

Flight Display Systems

Flight Display Systems FD171CV VER HD Manuale utente

Manuali TV LCD popolari di altre marche

LG 32LC4R* Manuale utente

ViewSonic

ViewSonic N4200w-1 VS10945-1M Manuale utente

Salora

Salora 22LED1600 Manuale utente

Samsung

Samsung LA32E420 Guida

Dell

Dell W1900 19 Istruzioni utente

Samsung

Samsung LN40C670M1F Manuale utente

Samsung

Samsung Series 4+ Manuale utente

Samsung

Samsung 5 Series Manuale utente

Grundig

Grundig 40 VLE 8230 BP Manuale utente

Philips

Philips 43PFL4901/F7 Manuale utente

Sony

Sony Bravia XBR-43X830C Manuale utente

LG 32LS350 Manuale utente

VIORE

VIORE LED32VF60 Manuale utente

Toshiba

Toshiba Regza 42HL167 Manuale utente

JVC

JVC LT-32A220 Manuale utente

Philips

Philips 20TA1000/93 Manuale utente

Philips

Philips 32PFL3158T/12 Manuale utente

Sony

Sony Bravia KDL-V32XBR2 Manuale utente