Follett Symphony Plus Manuale utente

Order parts online:

www.follettice.com

01089820R01

801 Church Lane • Easton, PA 18040, USA

Toll free (877) 612-5086 • +1 (610) 252-7301

www.follettice.com

Installation Instructions

Symphony Plus™ Pressurized Water

Sanitizing Kit

P/N 01089580

For use with systems with no lter

ATTENTION!

These instructions are for Symphony Plus dispensers only.

Instructions for sanitizing Symphony Series dispensers are

located on the reverse side of this document.

Description

Periodic cleaning/descaling and sanitizing of Follett’s ice and water dispenser and ice machine system is required

to ensure peak performance and delivery of clean, sanitary ice. Immediately perform Cleaning/Sanitizing procedure

(according to instructions shipped with dispenser) when this Pressurized Water Sanitizing procedure is completed.

If you experience any problems during the installation process, please call Follett Technical Service toll-free at

(877) 612-5086 or +1(610)252-7301 for assistance.

Materials Required

§(1) 1.5 Gallon (or larger) plastic bucket

§Sanitary gloves

§Safety glasses

§1.6  oz of Nu-Calgon IMS-II Sanitizer (P/N 00979674 - 16 . oz bottle)

Materials Supplied

(1) Pre-lter bowl

(1) Filter head and bracket

(1) Dip tube

(1) 3/8" ID john guest tubing, 12' (3.6 m)

(2) 1/2" NPT x 3/8" john guest tting

(1) 3/8" to 3/8" compression tting

2 Symphony Plus Pressurized Water Sanitizing Kit - No Filter

Sanitizing

CAUTION!

§Immediately perform Cleaning/Sanitizing procedure (according to instructions shipped with

dispenser) when Pressurized Water Sanitizing procedure is completed.

§Only qualied technicians should attempt to service or maintain this equipment.

§Wear rubber gloves and safety goggles (or face shield) when handling cleaner or sanitizer mixtures.

§Use only Follett approved cleaners.

§It is a violation of Federal law to use Sanitizing solution in a manner inconsistent with its labeling.

§Do not use solvents, abrasive cleaners, metal scrapers or sharp objects to clean any part of the

dispenser.

1. Unplug dispenser.

2. Turn OFF water supply.

3. Depress red pressure release button to

relieve pressure.

4. Remove pre-lter bowl.

Fig. 1

5. Install dip tube (Fig. 2).Fig. 2

Symphony Plus Pressurized Water Sanitizing Kit - No Filter 3

6. Mix a 200 ppm active quaternary sanitizing

solution of 1 gal. (3.8 L) 100F (38 C)

water and 1.6 oz (47 ml) Nu-Calgon IMS-II

Sanitizer (P/N 00979674).

7. Fill pre-lter bowl to just below the o-ring

with sanitizing solution (Fig. 3).

Fig. 3

8. Re-install pre-lter bowl (Fig. 4). Fig. 4

4 Symphony Plus Pressurized Water Sanitizing Kit - No Filter

9. Turn ON water supply.

10. Plug in dispenser.

11. Dispense 3 cups (24 oz) of water into a

container (Fig.5). Sanitizer will ll the

dispenser water lines.

Note: Maximum length of water line between

dispenser and lter system must not exceed

30ft.(9 m).

12. Discard water collected in container.

Fig. 5

3 cups

13. Remove the front cover and set aside.

14. Locate the ice machine electrical box

(Fig.6.1) and press CLEAN switch

(Fig.6.2). The MAINTENANCE light will turn

on and the machine will drain.

15. Wait for the LOW WATER light to turn on.

16. Locate the dispenser electrical box and

ensure that the BIN SIGNAL switch is ON.

1 7. Unplug the dispenser, wait 5 seconds and

plug back in.

18. Ice machine will resume ice making mode

(wait for MAKING ICE light to turn on) and

sanitizer will ll the ice machine water lines

and also the water reservoir.

Fig. 6

Symphony Plus Pressurized Water Sanitizing Kit - No Filter 5

19. Unplug unit and allow sanitizer to remain in

water lines and water reservoir for at least

5minutes.

20. Turn OFF water supply.

2 1. Depress red pressure release button to

relieve pressure.

22. Remove pre-lter bowl (Fig.7.1), discard

sanitizer (Fig.7.2), rinse with potable water,

and re-install (Fig.7.3).

Fig. 7

23. Turn ON water supply.

24. Plug in dispenser and dispense water into

a container for 30 seconds (Fig.8) to ush

sanitizer from the dispenser water lines.

25. Discard water collected in container.

26. Press the CLEAN switch to purge sanitizer

from the water reservoir.

2 7. Wait for the LOW WATER light to turn on.

28. Unplug the dispenser, wait 5 seconds and

plug back in.

29. Ice machine will resume ice making mode

(wait for MAKING ICE light to turn on) and

ush water reservoir lines.

30. Turn OFF the BIN SIGNAL switch.

3 1. Immediately perform Cleaning/Sanitizing

procedure according to instructions shipped

with dispenser.

Fig. 8

30 sec

01089820R01

801 Church Lane • Easton, PA 18040, USA

Toll free (877) 612-5086 • +1 (610) 252-7301

www.follettice.com

Follett is a registered trademark of Follett Corporation, registered in US.

01089820R01

801 Church Lane • Easton, PA 18040, USA

Toll free (877) 612-5086 • +1 (610) 252-7301

www.follettice.com

Follett is a registered trademark of Follett Corporation, registered in US.

Symphony Series Pressurized Water Sanitizing Kit - Single Filter 5

1 7. Unplug unit and allow sanitizer to remain in

water lines and water reservoir for at least

5minutes.

18. Turn OFF water supply.

19. Depress red pressure release button to

relieve pressure.

20. Remove pre-lter bowl (Fig.7.1), discard

sanitizer (Fig.7.2), rinse with potable water,

and re-install (Fig.7.3).

Fig. 7

2 1. Turn ON water supply.

22. Plug in dispenser and dispense water into

a container for 30 seconds (Fig.8) to ush

sanitizer from the dispenser water lines.

23. Discard water collected in container.

24. Drain water for 30 seconds from the

water reservoir by releasing evaporator

drain tubefrom oat reservoir bracket,

removing plug from drain tube and releasing

(unclamping) pinch clamp (if equipped).

25. Plug drain hose, replace drain tube in

reservoir bracket.

26. Immediately perform Cleaning/Sanitizing

procedure according to instructions shipped

with dispenser.

Fig. 8

30 sec

4 Symphony Series Pressurized Water Sanitizing Kit - Single Filter

9. Turn ON water supply.

10. Plug in dispenser.

11. Dispense 3 cups (24 oz) of water into a

container (Fig.5). Sanitizer will ll the

dispenser water lines.

Note: Maximum length of water line between

dispenser and lter system must not exceed

30ft.(9 m).

12. Discard water collected in container.

Fig. 5

3 cups

13. Remove any panels required to gain access

to water reservoir, evaporator drain tube, and

compressor switch.

Note: Consult the Operation and Service manual

shipped with your unit.

14. Locate the Compressor Switch and put in the

OFF position.

15. Drain 2 cups (16 oz) of water from the water

reservoir by releasing evaporator drain

tube (Fig.6.1) from oat reservoir bracket

(Fig.6.2), removing plug (Fig.6.3) from drain

tube and releasing (unclamping) pinch clamp

(Fig.6.4) (if equipped).

16. Plug drain hose, replace drain tube in

reservoir bracket.

Fig. 6

12CI Shown

Symphony Series Pressurized Water Sanitizing Kit - Single Filter 3

6. Mix a 200 ppm active quaternary sanitizing

solution of 1 gal. (3.8 L) 100F (38 C)

water and 1.6 oz (47 ml) Nu-Calgon IMS-II

Sanitizer (P/N 00979674).

7. Fill pre-lter bowl to just below the o-ring

with sanitizing solution (Fig. 3).

Fig. 3

8. Re-install pre-lter bowl (Fig. 4). Fig. 4

Altri manuali per Symphony Plus

Indice

Altri manuali Follett Distributore d'acqua

Follett

Follett Symphony 12CI400A-LI Guida all'installazione

Follett

Follett 25 Guida all'installazione

Follett

Follett VU155N Series Manuale

Follett

Follett 50HI425A Guida all'installazione

Follett

Follett EVU155NW Guida all'installazione

Follett

Follett 7UC100A Guida all'installazione

Follett

Follett 25CI400A Guida all'installazione

Follett

Follett 50Hz Manuale utente

Follett

Follett EU155N Series Guida all'installazione

Follett

Follett 50 Manuale utente

Follett

Follett C/E25CI425A Guida all'installazione

Follett

Follett Symphony Plus 25 series Guida all'installazione

Follett

Follett Symphony Plus 25 series Manuale utente

Follett

Follett Symphony 25CT400A Guida all'installazione

Follett

Follett E7CI100A Guida all'installazione

Follett

Follett L90815 Manuale utente

Follett

Follett U155N Series Guida all'installazione

Follett

Follett Symphony E12CI425A Manuale operativo

Follett

Follett 25CI425A/W Guida all'installazione

Follett

Follett Symphony Plus 25 series Manuale operativo

Follett

Follett 25 Guida all'installazione

Follett

Follett Symphony C110FB400A/W Guida all'installazione

Follett

Follett 7UC100A Guida all'installazione

Follett

Follett MU155N Series Supplemento

Manuali Distributore d'acqua popolari di altre marche

Monarch Water

Monarch Water ULTIMATE MINI AQUA HE Manuale utente

Haier

Haier HLM-109B Manuale utente

abc

abc Fleck 5600SXT Manuale utente

GE GXOF18G Istruzioni operative

Kenmore

Kenmore 625.385560 UltraFilter 650 Manuale utente

Innova

Innova CEV+ Guida rapida

Aries

Aries Hydra DI Manuale

GE GNCF02H Manuale utente

ProFlo

ProFlo PFB Series Manuale utente

Hydrotech

Hydrotech 89DF HIM Manuale utente

A.O. Smith

A.O. Smith FREZYA 300S Manuale utente

Frakco

Frakco Travelsoft RV 2400HD Manuale utente

GE GXSF30V Istruzioni operative

Avanti

Avanti WD31EC Manuale utente

Avanti

Avanti WD360 Manuale utente

BRIO

BRIO CLCTTL520 Guida utente

3M HCD-1 Manuale utente

Elkay

Elkay EFHFA8_2CJO Manuale di installazione