FujiFilm X-Pro1 Manuale utente

Confidential: FUJIFILM Service Center Use Only

X-Pro1 Service Manual

X-Pro1

CAUTION

BECAUSE THIS PRODUCTIS RoHS LEAD-FREE COMPLIANT, USE THE DESIGNATED

AFTER-SELES PARTS AND THE DESIGNATED LEAD-FREE SOLDER WHEN

PERFORMING REPAIRS. (Refer to page 3)

WARNING

THE COMPONENTS IDENTIFIED WITH THE MARK " " ON THE SCHEMATIC

DIAGRAM AND IN THE PARTS LIST ARE CRITICAL FOR SAFETY.

PLEASE REPLACE ONLY WITH THE COMPONENTS SPECIFIED ON THE SCHEMATIC

DIAGRAM AND IN THE PARTS LIST.

IF YOU USE PARTS NOT SPECIFIED, IT MAY RESULT IN A FIRE AND AN ELECTRICAL

SHOCK.

Ref. No.: ZM00984-109

Revised on 17 Oct 2013

Confidential: FUJIFILM Service Center Use Only

X-Pro1 Service Manual

SAFETY CHECK-OUT

After correcting the original problem, perform the following

safety check before return the product to the customer.

1. Check the area of your repair for unsoldered

or poorly soldered connections. Check the

entire board surface for solder splasher and

bridges.

2. Check the interboard wiring to ensure that no

wires are "pinched" or contact high-wattage

resistors.

3. Look for unauthorized replacement parts,

particularly transistors, that were installed

during a previous repair. Point them out to the

customer and recommend their replacement.

4. Look for parts which, though functioning, show

obvious

signs of deterioration. Point them out to the

customer and recommend their replacement.

5. Check the B + voltage to see it is at the values

specified.

6. Make leakage - current measurements to

determine that exposed parts are acceptably

insulated from the supply circuit before

returning the product to the customer.

7. CAUTION: FOR

CONTINUED PROTECTION

AGAINST FIRE HAZARD,

REPLACE ONLY WITH

SAME TYPE 2.5 AMPERES

125V/250V FUSE.

ATTENTION: AFIN

D'ASSURER UNE

PROTECTION

PERMANENTE CONTRE

LES RISQUES D'INCENDIE,

REMPLACER

UNIQUEMENT PAR UN

FUSIBLE DE MEME, TYPE

2.5 AMPERES, 125/250

VOLTS.

8. WARNING:

TO REDUCE THE

ELECTRIC SHOCK, BE

CAREFUL TO TOUCH THE

PARTS.

RISK OF FIRE-

REPLACE FUSE

AS MARKED

2.5A 125V/250V

WARNING!

HIGH VOLTAGE

Confidential: FUJIFILM Service Center Use Only

X-Pro1 Service Manual

RoHS lead-free compliance

With the exception of parts and materials expressly excluded from the RoHS directive, all the internal connections and

component parts and materials used in this product are lead-free compliant under the European RoHS directive (*1). Use the

designated after-sales parts and the designated lead-free solder when performing repairs.

*1:Definition of lead-free

A lead content ratio of 0.1 wt% or less in the applicable locations (solder, terminals, electronic components, etc.)

<Lead-free soldering>

When lead-free solder is used, the solder tends to be less workable than when eutectic solder is used. When carrying out

repairs, use a designated lead-free solder, bearing in mind the differing work practices for eutectic solder and lead-free

solder.

■Differences in the soldering work for lead-free and eutectic solder

Eutectic solder (Sn-Pb) Lead-free solder

(Sn-Ag-Cu)

Remark

Melting point 183°C 220°C

Soldering iron temperature 283°C 320°C The bonding temperature that will

give the best bond strength.

Wetting Good Poor

Surface Gloss Matte

■Recommended equipment

■Soldering iron maintenance

Because of the high soldering iron temperature in lead-free soldering, there is rapid carbonization of the flux adhering to

the tip of the soldering iron.

(1) Always cover the tip of the soldering iron with solder when it is not being used.

(2) If the tip is black from carbonization, wipe it gently with a paper towel soaked in alcohol until the solder will wet.

lead-free

Wire diameter

Solder type (Displayed symbol)

SnAgCu

Confidential: FUJIFILM Service Center Use Only

X-Pro1 Service Manual

MEMO

Confidential: FUJIFILM Service Center Use Only

X-Pro1 Service Manual

5

CONTENTS

1. Disassembly ............................................................................................................1-1

2. Schematics ..............................................................................................................2-1

3. Adjustments ............................................................................................................3-1

4. Inspection ................................................................................................................4-1

5. Parts List 1 (Packing and Accessories) ......................................................................5-1

6. Parts List 2 (Mechanical Block) .................................................................................6-1

7. Electrical parts ........................................................................................................7-1

8. Appendix...................................................................................................................8-1

Confidential: FUJIFILM Service Center Use Only

X-Pro1 Service Manual

6

MEMO

Confidential: FUJIFILM Service Center Use Only

X-Pro1 Service Manual

1-1

1. Disassembly

1-1. Removing the CASE

(1) Remove the DECO PLATE LEVER.

(2) Remove the 1 screw.（MS2M 1.4X2.0）

(3) Remove the LEVER FINDER.



(4) Peel off the GRIP F.

(5) Peel off the TAPE GRIP F.

(6) Remove the 4 screws.（MS2M 1.7X3.5）

(7) Remove the BASE GRIP F.



4 4

Confidential: FUJIFILM Service Center Use Only

X-Pro1 Service Manual

1-2



(8) Peel off the SHEET GRIP R LEFT.

(9) Peel off the SHEET GRIP R RIGHT.

(10) Peel off the SHEET GRIP F RIGHT.

(11) Peel off the SHEET GRIP F LEFT.



(12) Peel off the SHEET FRONT.



[Assembly]

Assemble by performing the disassembly procedure in reverse.

Refer to the sheet sticking procedure.

Recycling prohibition of SHEET.



8 9

Confidential: FUJIFILM Service Center Use Only

X-Pro1 Service Manual

1-3

1-2. Removing the CONST REAR

(1) Remove the 1 screw.（N-MSGM 1.7X2.5）

(2) Remove the 4 screws.（N-MSGM 1.7×2.5D）



(3) Remove the 3 screws.（N-MS2M 1.7X3.0）



(4) Remove the 2 screws.（N-MSGM 1.7X4.0）





1 22

Confidential: FUJIFILM Service Center Use Only

X-Pro1 Service Manual

1-4



(5）Open the CONST REAR in the direction of the arrow.

(6）Remove the REAR FFC from theMAIN PWB ASSY.



(7) Peel off the ULTAPE.

(8) Peel off the CUSHION CN LCD.

(9) Unlock the connector and remove theLCD FPC.



[Assembly]

Assemble by performing the disassembly procedure in reverse.



7 8

Altri manuali per X-Pro1

Indice

Altri manuali FujiFilm Macchina fotografica digitale

FujiFilm

FujiFilm FINEPIX S1 Series Manuale utente

FujiFilm

FujiFilm FinePix E550 Manuale utente

FujiFilm

FujiFilm X-T30 Manuale utente

FujiFilm

FujiFilm Finepix Z20 Manuale utente

FujiFilm

FujiFilm FINEPIX A340 Manuale utente

FujiFilm

FujiFilm FinePix F450 Manuale utente

FujiFilm

FujiFilm Instax Mini 11 Manuale utente

FujiFilm

FujiFilm Finepix S6800 series Manuale utente

FujiFilm

FujiFilm FinePix J150w Manuale utente

FujiFilm

FujiFilm axia ix-10 Manuale utente

FujiFilm

FujiFilm FINEPIX JZ100 series Manuale utente

FujiFilm

FujiFilm FinePix REAL 3D W1 Manuale utente

FujiFilm

FujiFilm X-S20 Manuale utente

FujiFilm

FujiFilm X-T30II Manuale utente

FujiFilm

FujiFilm Zoom Date 1000 Manuale utente

FujiFilm

FujiFilm instax Mini 40 Manuale utente

FujiFilm

FujiFilm FinePix S9000 Manuale utente

FujiFilm

FujiFilm FinePix FinePix A920 Manuale utente

FujiFilm

FujiFilm FINEPIX A330 Manuale utente

FujiFilm

FujiFilm FinePix F50fd Manuale utente

FujiFilm

FujiFilm FinePix FinePix Z200fd Manuale utente

FujiFilm

FujiFilm Finepix HS50EXR Manuale utente

FujiFilm

FujiFilm Finepix A610 Manuale utente

FujiFilm

FujiFilm FINEPIX S2900 Series Manuale utente

Manuali Macchina fotografica digitale popolari di altre marche

Mercury

Mercury 350K Manuale utente

Pentax

Pentax Optio LS 465 Manuale utente

Sanyo

Sanyo VPC-S1085 Manuale utente

GE SMART A1255 Manuale utente

Point Grey

Point Grey Gazelle Manuale utente

Nikon

Nikon COOLPIX A Manuale utente

Pentax

Pentax P-5 Manuale utente

BlazeVideo

BlazeVideo A280 Manuale utente

Sony

Sony MCA-20 Manuale utente

Sony

Sony Alpha DSLR-A290 Manuale utente

ATIK Cameras

ATIK Cameras One Manuale utente

CohuHD Costar

CohuHD Costar 3930 Series Manuale utente

Leica

Leica M10-R Manuale utente

Lorex

Lorex LNZ81P25 Series Manuale utente

GE J1470S Manuale utente

Sony

Sony A6700 Guida utente

Canon

Canon EOS ELAN7 Manuale utente

Nikon

Nikon Coolpix 100 Manuale utente