Generac Power Systems SD600 Manuale utente

Generator image used for illustration purposes only

1 of 4

Industrial Diesel Generator Set

EPA Certified Stationary Emergency

600 kW Diesel

Standby Power Rating

750kVA 600kW 60Hz

features benefits

primary codes and standards

Generator Set

=PROTOTYPE & TORSIONALLY TESTED 4PROVIDES A PROVEN UNIT

=UL2200 TESTED 4ENSURES A QUALITY PRODUCT

=RHINOCOAT PAINT SYSTEM 4IMPROVES RESISTANCE TO ELEMENTS

=WIDE RANGE OF ENCLOSURES AND TANKS 4PROVIDES A SINGLE SOURCE SOLUTION

Engine

=EPA COMPLIANT 4MEETS EPA STANDARDS

=INDUSTRIAL TESTED, GENERAC APPROVED 4ENSURES INDUSTRIAL STANDARDS

=POWER-MATCHED OUTPUT 4ENGINEERED FOR PERFORMANCE

=INDUSTRIAL GRADE 4IMPROVES LONGEVITY AND RELIABILITY

Alternator

=TWO-THIRDS PITCH 4ELIMINATES HARMFUL 3RD HARMONIC

=LAYER WOUND ROTOR & STATOR 4IMPROVES COOLING

=CLASS H MATERIALS 4HEAT TOLERANT DESIGN

=DIGITAL 3-PHASE VOLTAGE CONTROL 4FAST AND ACCURATE RESPONSE

Controls

=ENCAPSULATED BOARD W/ SEALED HARNESS 4EASY, AFFORDABLE REPLACEMENT

=4-20mA VOLTAGE-TO-CURRENT SENSORS 4NOISE RESISTANT 24/7 MONITORING

=SURFACE-MOUNT TECHNOLOGY 4PROVIDES VIBRATION RESISTANCE

=ADVANCED DIAGNOSTICS & COMMUNICATIONS 4HARDENED RELIABILITY

SD600

ENGINE SPECIFICATIONS

General Cooling System

Make Perkins Cooling System Type Closed Recovery

EPA Emissions Compliance Stationary Emergency Water Pump Centrifugal Type, Belt-Driven

EPA Emissions Reference See Emissions Data Sheet Fan Type Pusher

Cylinder # 6 Fan Speed (rpm) 1439

Type In-Line Fan Diameter mm (in.) 965 (38)

Displacement - L 18.13 Coolant Heater Standard Wattage 1500

Bore - mm (in.) 145(5.71) Coolant Heater Standard Voltage 120VAC

Stroke - mm (in.) 183(7.20)

Compression Ratio 14.5:1 Fuel System

Intake Air Method Turbocharged/Aftercooled Fuel Type Ultra Low Sulfur Diesel #2

Cylinder Head Type 4 Valve Fuel Specifications ASTM

Piston Type Aluminum Fuel Filtering (microns) Primary 10 - Secondary 2

Connecting Rod Type I-Beam Section Fuel Injection Electronic

Fuel Pump Type Engine Driven Gear

Engine Governing Injector Type MEUI

Governor Electronic Isochronous Engine Type Pre-Combustion

Frequency Regulation (Steady State) ± 0.25% Fuel Supply Line - mm (in.) 12.7 (½"NPT)

Fuel Return Line - mm (in.) 12.7 (½"NPT)

Lubrication System

Oil Pump Type Gear Engine Electrical System

Oil Filter Type Full-Flow Cartridge System Voltage 24VDC

Crankcase Capacity - L (Gal) 60 (15.8) Battery Charging Alternator 70 Amps at 24V

Battery Size (at 0ºC) 1155 CCA

Battery Group 8D

Battery Voltage (2) - 12VDC

Ground Polarity Negative

ALTERNATOR SPECIFICATIONS

Standard Model WEG Voltage Regulator Type Digital

Poles 4 Number of Sensed Phases All

Field Type Revolving Regulation Accuracy (Steady State) ± 1%

Insulation Class - Rotor H

Insulation Class - Stator H

Total Harmonic Distortion < 3%

Telephone Interference Factor (TIF) < 50

Standard Excitation Permanent Magnet

Bearings Single Sealed Cartridge

Coupling Direct, Flexible Disc

Load Capacity - Standby 100%

Prototype Short Circuit Test Yes

CODES AND STANDARDS COMPLIANCE (WHERE APPLICABLE)

NFPA 99 BS5514

NFPA 110 SAE J1349

ISO 8528-5 DIN6271

ISO 1708A.5 IEEE C62.41 TESTING

ISO 3046 NEMA ICS 1

ETL certified to UL2200 Standards

2 of 4

Rating Definitions:

Standby – Applicable for a varying emergency load for the duration of a utility power outage with no overload capability. (Max. load factor = 70%)

Prime – Applicable for supplying power to a varying load in lieu of utility for an unlimited amount of running time. (Max. load factor = 80%) A 10% overload capacity is available for 1 out of

every 12 hours.

SD600 application and engineering data

600 kW Diesel

Deration – Operational characteristics consider maximum ambient conditions. Derate factors may apply under atypical site conditions. Please consult a Generac Power Systems Industrial

Dealer for additional details. All performance ratings in accordance with ISO3046, BS5514, ISO8528 and DIN6271 standards.

POWER RATINGS (kW)

STARTING CAPABILITIES (sKVA)

FUEL

COOLING

COMBUSTION AIR REQUIREMENTS

ENGINE EXHAUST

STANDBY

Three-Phase 120/208VAC @0.8pf 600 kW Amps: 2081

Three-Phase 120/240VAC @0.8pf 600 kW Amps: 1804

Three-Phase 277/480VAC @0.8pf 600 kW Amps: 903

Three-Phase 346/600VAC @0.8pf 600 kW Amps: 723

sKVA vs. Voltage Dip

480VAC 208/240VAC

Alternator kW 10% 15% 20% 25% 30% 35% Alternator kW 10% 15% 20% 25% 30% 35%

Standard 600 743 1114 1486 1857 2229 2600 Standard 600 543 814 1086 1357 1629 1900

Upsize 1 832 757 1136 1514 1893 2271 2650 Upsize 1 723 571 857 1143 1429 1714 2000

Upsize 2 - - - - - - - Upsize 2 - - - - - - -

Fuel Consumption Rates*

STANDBY

Fuel Pump Lift - m (ft) Percent Load gph lph

3.7 (12) 25% 18.4 69.7

50% 28.2 88.7

75% 35.6 134.8

100% 41.4 156.7

* Refer to "Emissions Data Sheet" for maximum fuel flow for EPA and SCAQMD permitting purposes.

STANDBY

Coolant Flow per Minute gpm (lpm) 114.1 (432)

Heat Rejection to Coolant BTU/hr 1,589,760

Inlet Air cfm (m3/min) 30,088 (852)

Max. Operating Radiator Air Temp Fº (Cº) 122 (50)

Max. Operating Ambient Temperature Fº (Cº) 104 (40)

Coolant System Capacity gal (L) 13 (49)

Maximum Radiator Backpressure in H2O 0.5

STANDBY

Flow at Rated Power cfm (m3/min) 1836 (52)

STANDBY

Rated Engine Speed rpm 1800

Horsepower at Rated kW** hp 909

Piston Speed ft/min 2161.4

BMEP psi 361

** Refer to “Emissions Data Sheet” for maximum bHP for EPA and SCAQMD

permitting purposes.

STANDBY

Exhaust Flow (Rated Output) cfm (m3/min) 4980 (141)

Max. Backpressure (Post Silencer) inHg (Kpa) 2.03 (6.9)

Exhaust Temp (Rated Output) ºF (ºC) 1029 (554)

Exhaust Outlet Size (Open Set) 8"

3 of 4

SD600 operating data (60Hz)

600 kW Diesel

GENERATOR SET

Genset Vibration Isolation Std

IBC/OSHPD Seismic Certified Opt

Extended warranty Opt

Gen-Link Communications Software Opt

Steel Enclosure Opt

Aluminum Enclosure Opt

ENGINE SYSTEM

General

Oil Drain Extension Std

Oil Heater Opt

Air cleaner Std

Fan guard Std

Radiator duct adapter Std

Stainless steel flexible exhaust connection Std

Critical Exhaust Silencer Opt

Fuel System

Secondary fuel filter Std

Flexible fuel lines Opt

Primary fuel filter Std

UL 142 Fuel Tank Opt

Cooling System

120VAC Coolant Heater Std

Closed Coolant Recovery System Std

UV/Ozone resistant hoses Std

Factory-Installed Radiator Std

Radiator Drain Extension Std

Engine Electrical System

Battery charging alternator Std

Battery cables Std

Battery heater Opt

Solenoid activated starter motor Std

10A UL float/equalize battery charger Opt

Rubber-booted engine electrical connections Std

ALTERNATOR SYSTEM

GENprotect™ Alternator Protection Algorithm Std

Main Line Circuit Breaker Opt

2nd Circuit Breaker Opt

3rd Circuit Breaker -

Alternator Upsizing Opt

Anti-Condensation Heater Opt

Tropical coating Opt

Permanent Magnet Generator Std

CONTROL SYSTEM

Control Panel

Digital H Control Panel - Dual 4x20 Display Std

Digital G-200 Paralleling Control Panel - Touchscreen na

Programmable Crank Limiter Std

21-Light Remote Annunciator Opt

Remote Relay Panel (8 or 16) Opt

7-Day Programmable Exerciser Std

Special Applications Programmable PLC Std

RS-232 Std

RS-485 Std

All-Phase Sensing DVR Std

Full System Status Std

Utility Monitoring (Req. H-Transfer Switch) Std

2-Wire Start Compatible Std

Power Output (kW) Std

Power Factor Std

Reactive Power Std

All phase AC Voltage Std

All phase Currents Std

Oil Pressure Std

Coolant Temperature Std

Coolant Level Std

Oil Temperature Opt

Engine Speed Std

Battery Voltage Std

Frequency Std

Date/Time Fault History (Alarm & Event Log) Std

Low-Speed Exercise -

Isochronous Governor Control Std

-40deg C - 70deg C Operation Std

Waterproof Plug-In Connectors Std

Audible Alarms and Shutdowns Std

Not in Auto (Flashing Light) Std

Auto/Off/Manual Switch Std

E-Stop (Red Mushroom-Type) Std

Remote E-Stop (Break Glass-Type, Surface Mount) Opt

Remote E-Stop (Red Mushroom-Type, Surface Mount) Opt

Remote E-Stop (Red Mushroom-Type, Flush Mount) Opt

NFPA 110 Level I and II (Programmable) Std

Remote Communication - RS232 Std

Remote Communication - Modem Opt

Remote Communication - Ethernet Opt

10A Run Relay Opt

Alarms (Programmable Tolerances, Pre-Alarms and Shutdowns)

Low Fuel Opt

Oil Pressure (Pre-programmed Low Pressure Shutdown) Std

Coolant Temperature (Pre-programmed High Temp Shutdown) Std

Coolant Level (Pre-programmed Low Level Shutdown) Std

Oil Temperature Opt

Engine Speed (Pre-programmed Overspeed Shutdown) Std

Voltage (Pre-programmed Overvoltage Shutdown) Std

Battery Voltage Std

4 of 4

SD600 standard features and options

600 kW Diesel

Tank Options

MDEQ OPT

Florida DERM/DEP OPT

Chicago Fire Code OPT

IFC Certification CALL

ULC CALL

Other Custom Options Available from your Generac Industrial Power Dealer

*All measurements are approximate and for estimation purposes only. Weights and dBA are available on install drawings and sound data sheets, respectively.

YOUR FACTORY RECOGNIZED GENERAC INDUSTRIAL DEALER

OPEN SET

RUN TIME HOURS USABLE CAPACITY (GAL)

NO TANK -

8 334

24 1001

48 2002

STANDARD ENCLOSURE

RUN TIME HOURS USABLE CAPACITY (GAL)

NO TANK -

8 334

24 1001

48 2002

LEVEL 1 SOUND ENCLOSURE

RUN TIME HOURS USABLE CAPACITY (GAL)

NO TANK -

8 334

24 1001

48 2002

LEVEL 2 SOUND ENCLOSURE

RUN TIME HOURS USABLE CAPACITY (GAL)

NO TANK -

8 334

24 1001

48 2002

5 of 4

SD600 enclosure and tank configurations

Generac Power Systems, Inc. • S45 W29290 HWY. 59, Waukesha, WI 53189 • generac.com

Specification characteristics may change without notice. Dimensions and weights are for preliminary purposes only. Please consult a Generac Power Systems Industrial Dealer for detailed installation drawings.

Indice

Altri manuali Generac Power Systems Invertitore

Generac Power Systems

Generac Power Systems 04673-2 Istruzioni per l'installazione

Generac Power Systems

Generac Power Systems 006180-0 Manuale utente

Generac Power Systems

Generac Power Systems Quietsource 004916-0 Manuale utente

Generac Power Systems

Generac Power Systems 004702-0, 004703-0, 004704-0, Manuale utente

Generac Power Systems

Generac Power Systems Guardian 004188-1 Manuale utente

Generac Power Systems

Generac Power Systems QT022 Manuale utente

Generac Power Systems

Generac Power Systems Generator Manuale utente

Generac Power Systems

Generac Power Systems 1470-0 Manuale utente

Generac Power Systems

Generac Power Systems Guardian 004721-0 Manuale utente

Generac Power Systems

Generac Power Systems ECOGEN 005818-0 Manuale di installazione e funzionamento

Generac Power Systems

Generac Power Systems quietpact 85d Manuale utente

Generac Power Systems

Generac Power Systems 005221-0 Manuale utente

Generac Power Systems

Generac Power Systems MD500 Manuale utente

Generac Power Systems

Generac Power Systems MPSG350 Manuale utente

Generac Power Systems

Generac Power Systems MLG8K Manuale utente

Generac Power Systems

Generac Power Systems Liquid Cooled Gas Engine Generator Sets None Manuale utente

Generac Power Systems

Generac Power Systems 005040-2 Manuale utente

Generac Power Systems

Generac Power Systems 004812-3 Manuale utente

Generac Power Systems

Generac Power Systems MGG155 Manuale utente

Generac Power Systems

Generac Power Systems MMG480DI4 Manuale utente

Generac Power Systems

Generac Power Systems PWRcell X7602 Manuale utente

Generac Power Systems

Generac Power Systems 04673-2 Istruzioni per l'installazione

Generac Power Systems

Generac Power Systems 91355 Manuale utente

Generac Power Systems

Generac Power Systems QT025A Manuale utente

Manuali Invertitore popolari di altre marche

Fourgroup

Fourgroup Easy Manuale utente

Velleman

Velleman PI300M Manuale utente

Sungrow

Sungrow SG350HX-US Manuale utente

WilTec

WilTec 61897 Manuale utente

SMA

SMA SUNNY BOY STORAGE 2.5 Manuale utente

Simplicity

Simplicity LANDLORD 316 Manuale utente

Santak

Santak SMAX 3000 Manuale utente

ATON

ATON RA.Store-3 Manuale utente

ZIEHL-ABEGG

ZIEHL-ABEGG FXET4AMQ Manuale utente

Tektronix

Tektronix CFG250 Manuale utente

Champion

Champion 200989 Manuale utente

Vanner

Vanner 20-500 Series Manuale utente

GE GEP Manuale utente

Astrel Group

Astrel Group Power Reducer Guida rapida

MULTIQUIP

MULTIQUIP GDP-5H Guida

GoWISE

GoWISE PS1007 Manuale utente

Promate

Promate PM13500D ES Manuale utente

Mastervolt

Mastervolt WHISPER 3.5M3000 RPM Manuale utente