Heat Controller DMC09SB-0 Manuale utente
DMC09SB-0/DMH09SB-0, DMC12SB-0/DMH12SB-0
DMC18SB-1/DMH18SB-1, DMC24SB-1/DMH24SB-1
2Room Air Conditioner
Room Air Conditioner Installation Manual
TABLE OF CONTENTS
Safety Precautions.........................3
Introduction .....................................9
Symbols Used in This Manual....9
Features.......................................9
Installation .....................................10
Installation Parts........................10
Installation Tools ........................10
Installation Map..........................11
Confirm The Refrigerant ...........12
Select The Best Location .........13
Piping Length And Elevation.....14
How To Mount Installation Plate
..15
Drill a Hole In TheWall..............15
Flaring Work...............................16
Connecting The Piping..............17
Connection Of The Drain Hose
...22
Connection Of Piping -Outdoor
...22
Connection Of The Cable.........23
Checking The Drainage ............25
Forming The Piping...................26
Air Purging.................................27
Air Purging WithVacuum Pump
..27
Charging.....................................29
Test Running.................................30
❏ Installation plate
❏Four type "A" screws
❏Connecting cable
❏Pipes: Suction line
Evaporator line
(Refer to page 13)
❏Insulation materials
❏Additional drain pipe
(
Outer Diameter .........15.5mm(0.61in))
❏Two type "B" screws
❏Remote Control Holder
Installation
Requirements Required Parts Required Tools
❏Level gauge
❏Screwdriver
❏Electric drill
❏Hole core drill(ø70mm(2.76in))
❏Flaring tool set
❏Specified torque wrenches
4.2kg.m, 6.6kg.m
(different depending on model No.)
(Refer to page 17)
❏Spanner.....................Half union
❏A glass of water
❏Screw driver
❏Hexagonal
wrench(4mm(0.16in))
❏Gas Leak Detector
❏Vacuum pump
❏Manifold Gauge
❏Owner's manual
❏Thermometer
Installation Manual 3
Safety Precautions
To prevent the injury of the user or other people and property damage, the following instructions
must be followed.
■Incorrect operation due to ignoring instruction will cause harm or damage.The seriousness is
classified by the following indications.
■The meanings of the symbols used in this manual are as shown below.
This symbol indicates the possibility of death or serious injury.
This symbol indicates the possibility of injury or damage to properties only.
■Installation
Be sure not to do.
Be sure to follow the instruction.
Safety Precautions
For electrical work, contact the
dealer, seller, a qualified
electrician, or an Authorized
Service Center.
• There is risk of fire or electric shock.
Install the panel and the cover of
control box securely.
• There is risk of fire or electric shock.
Do not install, remove, or re-
install the unit by yourself
(customer).
• There is risk of fire, electric shock,
explosion or injury.
Be cautious when unpacking and
installing the product.
• Shape edges could cause injury. Be
especially careful of the sharp edges.
For installation, always contact
the dealer or an Authorized
Service Center.
• There is risk of fire, electric shock,
explosion, or injury.
Do not install the product on a
defective installation stand.
• It may cause injury, accident, or
damage to the product.
4Room Air Conditioner
Safety Precautions
■Operation
Be sure the installation area
does not deteriorate with age.
• If the base collapses, the air
conditioner could fall with it, causing
property damage, product failure, and
personal injury.
Install the indoor unit on the wall
where the height from the floors
more than 8ft(2.4m)
• There are sharp moving parts that
could cause personal injury.
Do not handle the pipe by
yourself(customer)
• High-Pressure refrigent may cause
personal injury.
Do not allow water to run into
electric part.
• There is risk of fire, failure of the
product, and/or electric shock.
Do not let the air conditioner run
for a long time when the
humidity is very high and a door
or a window is left open.
• Moisture may condense and wet or
damage furnishings.
Do not store of use flammable
gas or combustibles near the air
conditioner.
• There is risk of fire or product failure.
Do not use the product in a
tightly closed space for a long
time.
• Oxygen deficiency could occur.
• Some ventilation by opeing window
is necessary for the fresh air.
When flammable gas leaks, turn off
the gas and open a window for
ventilation before turning the product
on. Do not use the telephone or turn
switches on or off.
• There is risk of explosion or fire.
Turn of breaker to the unit if
strange sounds odors or smoke
comes from it.
•
There is risk of fireproduct failure
and/or electric shock.
8ft(2.4m)
Wax
Thinner
Installation Manual 5
Safety Precautions
Stop operation and close any
window in storm or hurricane.
before the hurricane arrives.
• There is risk of property damage,
failure of product, or electric shock.
Do not open the inlet grill of the
product during operation. (Do
not touch the electrostatic filter,
if the unit is so equipped.)
• There is risk of physical injury, electric
shock, or product.
When the product is soaked
(flooded or submerged), contact
an Authorized Service Center.
• There is risk of electrical shock.
Ventilate the product from
time to time when operating
it together with a stove, etc.
• There is risk of fire or electrical
shock.
Turn off breaker to the
appliance before performing
cleaning or maintenance.
• There is risk of electric shock.
When the product is not
being used for a long time
turn off the breaker.
• There is risk of product damage
or failure, or unintended
operation.
Take care to ensure that nobody could step
on or fall onto the outdoor unit.
• There could result in personal injury and product
damage.
Do not insert hands or other objects
through the air inlet or outlet while the air
conditioner is on.
• There are sharp and moving parts that could
cause personal injury.
6Room Air Conditioner
Safety Precautions
■Installation
■Operation
Do not direct airflow at
room occupants.
• This could damage your health.
Do not use the product for
special purposes, such as
preserving foods, works of
art, etc. It is a consumer air
conditioner, not a precision
refrigeration system.
• There is risk of damage or loss
of property.
Do not block the inlet or
outlet of air flow.
• It may cause product failure.
90˚
Do not install the product
where the noise or hot air
from the outdoor unit could
offend the neighbors.
•It may cause a problem for your
neighbors.
Use two or more people to
lift and transport the air
conditioner
•Avoid personal injury.
Do not install the product
where it will be exposed to
sea wind (salt spray)
directly.
•It may cause corrosion in the
product. Corrosion, particularly
on the condenser and
evaporator fins, could cause
product malfunction or inefficient
operation.
Always check for
gas(refrigerant) leakage
after installation or repair of
product.
•Low refrigerant levels may
cause product failure.
Install the drain hose to
ensure that water is drained
away properly.
•A bad connection may cause
water leakage.
Keep level even when
installing the product.
•To avoid vibration or water
leakage.
Safety Precautions
Installation Manual 7
Use a soft cloth to clean.
Do not use harsh
detergents, solvents, etc.
•There is risk of fire, electric
shock or damage to the plastic
parts of the product.
Do not touch the metal
parts of the product when
removing the air filter.They
are very sharp!
•There is risk of personal injury.
Do not step on or put
anything on the product.
(outdoor unit)
•There is risk of personal injury
and failure of product.
■Disuse
Always insert the filter securely.
Clean the filter every two weeks
or more often if necessary.
•A dirty filter reduces the efficiency of
the air conditioner and could cause
product malfunction or damage.
Do not drink the water drained
from the unit.
•It is not sanitary and could cause
serious health issues.
Use a firm stool or ladder when
cleaning or maintaining the air
conditioner.
•Be careful and avoid personal injury.
Replace all the batteries in the
remote.
•There is risk of fire or explosion.
Do not recharge or disassemble
the batteries. Do not dispose of
batteries in a fire.
•They may burn or explode.
If the liquid from the batteries
gets onto your skin or clothes,
wash it well with clean water.
Do not use the remote if the
batteries have leaked.
•The chemicals in batteries could
cause burns or other health hazards.
This symbol alerts you to the risk of electric shock.
This symbol alerts you to hazards that may cause harm to
the air conditioner.
This symbol indicates special notes.
NOTICE
Introduction
Symbols Used In This Manual
Features
Air Intake Vents
Air Outlet Vents
Connecting
Wires
Piping
Drain Hose
Base Plate
Air Outlet
Vents
Air Intake
Vents Piping
Connecting
Wires
Drain Hose
Base Plate
Air Inlet
Front Panel
Air Filter Signal Receptor
8Room Air Conditioner
Introduction
Installation
Installation Manual 9
Type "A" screw and plastic anchor
Type "B" screw Remote Control Holder
Installation plate
Figure FigureName
Screw driver
Electric Drill
Measuring Tape, Knife
Hole Core Drill
Spanner
Torque wrench
Ohmmeter
Hexagonal wrench
Ammeter
Gas Leak Detector
Thermometer,
Level
Flaring Tool Set
Name
Installation Parts
Installation Tools
Installation
Read carefully, and then follow step by step.
10 Room Air Conditioner
Installation
Installation Map
Base Plate
Air Inlet Vents
Air Outlet Vents
Installation parts you should purchase.
Air Discharge
Forced Operation Button
Operation Indication Lamps/
Signal Receptor Vinyl tape (Wide)
•Apply after carrying out a
drainage test.
•To carry out the drainage
test, remove the air filters
and pour water into the heat
exchanger.
Saddle
Gas side piping (Optional Parts)
Liquid side piping (Optional Parts)
Additional drain pipe
Vinyl tape (Narrow)
Drain Hose
Connecting cable
(Optional Parts)
Installation plate
Sleeve
Bushing-Sleeve
Putty(Gum Type Sealer)
Bend the pipe as closely
on the wall as possible,
but be careful that it
doesn't break.
NOTICE
Questo manuale è adatto per i seguenti modelli
7
Indice
Altri manuali Heat Controller Condizionatore d'aria
Heat Controller
Heat Controller B-MMC09FA-1 Manuale utente
Heat Controller
Heat Controller DMH36TB-1 Manuale utente
Heat Controller
Heat Controller BG-81J Manuale utente
Heat Controller
Heat Controller CD-101J Manuale utente
Heat Controller
Heat Controller BG-81G Manuale utente
Heat Controller
Heat Controller COMFORT-AIRE RG-51-5 Manuale utente
Heat Controller
Heat Controller BGE H-Series Guida all'applicazione
Heat Controller
Heat Controller Comfort-Aire BG-123A Manuale utente
Heat Controller
Heat Controller Comfort-Aire RAD-101A Manuale utente
Heat Controller
Heat Controller RADS-253A Manuale
Heat Controller
Heat Controller RG-51M Manuale utente
Heat Controller
Heat Controller RSE1318-1A Manuale utente
Heat Controller
Heat Controller PTAC09A130A Manuale utente
Heat Controller
Heat Controller REG-183A Manuale utente
Heat Controller
Heat Controller COMFORT AIRE RADS-51B Istruzioni per la costruzione
Heat Controller
Heat Controller BGE-123J Manuale utente
Heat Controller
Heat Controller Comfort-Aire BDE-103-A Manuale utente
Heat Controller
Heat Controller Comfort-Aire REG-71A Manuale utente
Heat Controller
Heat Controller DMC24CA-1 Manuale utente
Heat Controller
Heat Controller RG-51G Manuale utente
