Linear Technology DC1723A Guida rapida alla configurazione

dc1723af

DEMO MANUAL DC1723A

DESCRIPTION

LTM8050

58VIN, 2A Step-Down

µModule Regulator

DemocircuitDC1723Afeatures the LT M

8050,aμModule

(micromodule) step-down converter that can deliver up to

2A of output current. DC1723A is designed for a 5V, 2A

output from a 7.5V to 58V input at 400kHz. The wide input

range of the LTM8050 allows a variety of input sources

such as automotive batteries and industrial supplies. At

light loads, the LTM8050 enters Burst Mode

operation

to maintain high efficiency and low output ripple over a

broad current range. The user adjustable features of the

LTM8050 such as output voltage, switching frequency,

soft-start, and power good can be changed on DC1723A

L, LT, LTC, LTM, Linear Technology, the Linear logo, µModule and Burst Mode are registered

trademarks of Linear Technology Corporation. All other trademarks are the property of their

respective owners.

PERFORMANCE SUMMARY

BOARD PHOTO

simply by modifying or installing the appropriate resistors

and/or capacitors.

The LTM8050 data sheet gives a complete description of

the part, operation and application information. The data

sheet must be read in conjunction with this Quick Start

Guide for the demo circuit 1723A.

Design files for this circuit board are available at

http://www.linear.com/demo

Specifications are at TA= 25°C

PARAMETER CONDITIONS MIN TYP MAX UNITS

Minimum Input Voltage, VIN VOUT = 5V 7.5 V

Maximum Input Voltage, VIN VOUT = 5V 58 V

Output Voltage, VOUT R4 = 93.1k 4.87 5.02 5.17 V

Maximum Output Current 2 A

Switching Frequency R6 = 97.6k 400 kHz

Efficiency VIN = 12V, IOUT = 2A 85 %

dc1723af

DEMO MANUAL DC1723A

QUICK START PROCEDURE

Demonstration circuit 1723A is easy to set up to evalu-

ate the performance of the LTM8050. Refer to Figure 1

for proper measurement equipment setup and follow the

procedure below:

Note: When measuring the input or output voltage ripple,

care must be taken to avoid a long ground lead on the

oscilloscope probe. Measure the input or output voltage

rippleby

touchingthe probe tip directly acrosstheterminals

of the input or output capacitors. See Figure 2 for proper

scope probe technique.

1. Place JP1 in the ON position.

2. With power off, connect the input power supply to VIN

and GND.

3. Turn on the power at the input.

Note:Makesurethatthe input voltage does not exceed 58V.

4. Check for the proper output voltage.

Note: If there is no output, temporarily disconnect the load

to make sure that the load is not set too high or is shorted.

5. Once the proper output voltage is established, adjust

the loads within the operating range and observe the

output voltage regulation, ripple voltage, efficiency and

other parameters.

Figure 1. Measurement Equipment Setup

dc1723af

DEMO MANUAL DC1723A

QUICK START PROCEDURE

Figure 2. Measuring Input or Output Ripple

FREQUENCY (MHz)

–140

INTENSITY (dBm)

–120

–80

–60

–40

0.5 2.5 3.5

DC1723A F03

–100

–20

24.5 5

11.5 3 4

Figure 3. DC1723A Output Noise Spectrum (VIN = 12V, VOUT = 5V, IOUT = 2A)

GNDVIN OR VOUT DC1723A F02

dc1723af

DEMO MANUAL DC1723A

PARTS LIST

ITEM QTY

REFERENCE PART DESCRIPTION MANUFACTURER/PART NUMBER

Required Circuit Components

1 2

C2, C9 CAP., X7R, 2.2µF, 100V, 10%, 1206 MURATA, GRM31CR72A225KA73

2 1

C3 CAP., X5R, 100µF, 6.3V, 20%, 1210 MURATA, GRM32ER60J107ME20L

3 1

C10 CAP., X7R, 0.1µF, 10V, 10%, 0603 AVX, 0603ZC104KAT2A

4 1

R2 RES., CHIP, 0Ω, 1/10W, 0603 NIC, NRC06ZOTRF

5 1

R4 RES., CHIP, 93.1k, 1/10W, 1% 0603 VISHAY, CRCW060393K1FKEA

6 1

R5 RES., CHIP, 100k, 1/10W, 1% 0603 NIC, NRC06F1003TRF

7 1

R6 RES., CHIP, 97.6k, 1/10W, 1% 0603 VISHAY, CRCW060397K6FKEA

8 1

R7 RES., CHIP, 0Ω, 1/4W, 1% 1206 NIC, NRC12Z0TRF

9 1

U1 IC., MODULE REGULATOR, LTM8050EY BGA-70 LEAD LINEAR TECH., LTM8050EY

Additional Demo Board Circuit Components

1 1

C1 CAP., ELECTROLYTIC, 10µF, 100V SUN ELECT., 100CE10BS

2 0

C4, C5, C8 (OPT) CAP., 0603

3 0

C6 (OPT.) CAP., 1210

4 0

C7 (OPT.) CAP., ALUM CAP.,

5 0

R1, R3 (OPT.) RES., CHIP, 0603

6 0

FB1 (OPT.) FERRITE BEAD, M TYPE TAIYO YUDEN, FBMJ3216HS800T

7 0

L1 (OPT.) IND., 10µH VISHAY, IHLP-2525CZ-01

Hardware-For Demo Board Only

1 8

E1-E8 TESTPOINT, TURRET, 0.094" PBF MILL-MAX, 2501-2-00-80-00-00-07-0

2 2

JP1-JP2 3 PIN 0.079" SINGLE ROW HEADER SULLINS, NRPN031PAEN-RC

3 1

XJP1-XJP2 SHUNT, 0.079" CENTER SAMTEC, 2SN-BK-G

4 1

Stencil

dc1723af

DEMO MANUAL DC1723A

Information furnished by Linear Technology Corporation is believed to be accurate and reliable.

However, no responsibility is assumed for its use. Linear Technology Corporation makes no representa-

tion that the interconnection of its circuits as described herein will not infringe on existing patent rights.

SCHEMATIC DIAGRAM

dc1723af

DEMO MANUAL DC1723A

Linear Technology Corporation

1630 McCarthy Blvd., Milpitas, CA 95035-7417

(408) 432-1900 ●FAX: (408) 434-0507 ●www.linear.com

 LINEAR TECHNOLOGY CORPORATION 2013

LT 0513 • PRINTED IN USA

DEMONSTRATION BOARD IMPORTANT NOTICE

Linear Technology Corporation (LT C ) provides the enclosed product(s) under the following AS IS conditions:

This demonstration board (DEMO BOARD) kit being sold or provided by Linear Technology is intended for use for ENGINEERING DEVELOPMENT

OR EVALUATION PURPOSES ONLY and is not provided by LT C for commercial use. As such, the DEMO BOARD herein may not be complete

in terms of required design-, marketing-, and/or manufacturing-related protective considerations, including but not limited to product safety

measures typically found in finished commercial goods. As a prototype, this product does not fall within the scope of the European Union

directive on electromagnetic compatibility and therefore may or may not meet the technical requirements of the directive, or other regulations.

If this evaluation kit does not meet the specifications recited in the DEMO BOARD manual the kit may be returned within 30 days from the date

of delivery for a full refund. THE FOREGOING WARRANTY IS THE EXCLUSIVE WARRANTY MADE BY THE SELLER TO BUYER AND IS IN LIEU

OF ALL OTHER WARRANTIES, EXPRESSED, IMPLIED, OR STATUTORY, INCLUDING ANY WARRANTY OF MERCHANTABILITY OR FITNESS

FOR ANY PARTICULAR PURPOSE. EXCEPT TO THE EXTENT OF THIS INDEMNITY, NEITHER PARTY SHALL BE LIABLE TO THE OTHER FOR

ANY INDIRECT, SPECIAL, INCIDENTAL, OR CONSEQUENTIAL DAMAGES.

The user assumes all responsibility and liability for proper and safe handling of the goods. Further, the user releases LT C from all claims

arising from the handling or use of the goods. Due to the open construction of the product, it is the user’s responsibility to take any and all

appropriate precautions with regard to electrostatic discharge. Also be aware that the products herein may not be regulatory compliant or

agency certified (FCC, UL, CE, etc.).

No License is granted under any patent right or other intellectual property whatsoever. LT C assumes no liability for applications assistance,

customer product design, software performance, or infringement of patents or any other intellectual property rights of any kind.

LT C currently services a variety of customers for products around the world, and therefore this transaction is not exclusive.

Please read the DEMO BOARD manual prior to handling the product. Persons handling this product must have electronics training and

observe good laboratory practice standards. Common sense is encouraged.

This notice contains important safety information about temperatures and voltages. For further safety concerns, please contact a LT C applica-

tion engineer.

Mailing Address:

Linear Technology

1630 McCarthy Blvd.

Milpitas, CA 95035

Mouser Electronics

Authorized Distributor

Click to View Pricing, Inventory, Delivery & Lifecycle Information:

Analog Devices Inc.:

DC1723A

Questo manuale è adatto per i seguenti modelli

Indice

Altri manuali Linear Technology Controllori

Linear Technology

Linear Technology LTC4007 Manuale utente

Linear Technology

Linear Technology LTC1877 Guida rapida alla configurazione

Linear Technology

Linear Technology LTM4630EY-1 Guida rapida alla configurazione

Linear Technology

Linear Technology LT3759 Guida rapida alla configurazione

Linear Technology

Linear Technology LTC3875EUJ Guida rapida alla configurazione

Linear Technology

Linear Technology LTC3210-1 Manuale utente

Linear Technology

Linear Technology DC1700A Guida rapida alla configurazione

Linear Technology

Linear Technology LTM4650EY-1 Guida rapida alla configurazione

Linear Technology

Linear Technology LTC1872 Manuale utente

Linear Technology

Linear Technology DC1817B Guida rapida alla configurazione

Linear Technology

Linear Technology LTC4232 Guida rapida alla configurazione

Linear Technology

Linear Technology DC 1090A Manuale utente

Linear Technology

Linear Technology DC1488A Series Manuale utente

Linear Technology

Linear Technology DC1084A-B Manuale utente

Linear Technology

Linear Technology LTC1624 Manuale utente

Linear Technology

Linear Technology DC1989A-A Guida rapida alla configurazione

Linear Technology

Linear Technology DC1366B Manuale utente

Linear Technology

Linear Technology DC2007A-B Guida rapida alla configurazione

Linear Technology

Linear Technology LTM4649EY Guida rapida alla configurazione

Linear Technology

Linear Technology LTC4080 Manuale utente

Linear Technology

Linear Technology DC1855A Guida rapida alla configurazione

Linear Technology

Linear Technology LTM4650-1 Guida rapida alla configurazione

Linear Technology

Linear Technology No Rsense LTC3736 Manuale utente

Linear Technology

Linear Technology DC1830B-C Guida rapida alla configurazione

Manuali Controllori popolari di altre marche

Digiplex

Digiplex DGP-848 Istruzioni operative

YASKAWA

YASKAWA SGM series Manuale utente

Sinope

Sinope Calypso RM3500ZB Manuale utente

Isimet

Isimet DLA Series Style 2 Manuale di installazione

LSIS

LSIS sv-ip5a Manuale utente

Rockwell Automation

Rockwell Automation 1769-L31 Manuale utente

Airflow

Airflow Uno hab Manuale utente

ABB

ABB ACS580-01 drives Manuale utente

Panasonic

Panasonic GM1 Series Manuale utente

Emerson

Emerson SW93 Manuale utente

AutoAqua

AutoAqua Smart ATO micro SATO-120P Manuale utente

Panasonic

Panasonic FP? Positioning Unit RTEX Manuale utente

Samson

Samson Type 5824 Manuale di servizio

Alpha IP

Alpha IP MIOB 21001 Manuale utente

Siemens

Siemens OpenAir GMA 1 Series Manuale utente

Surecom

Surecom SR-629 Manuale utente

Fishman

Fishman TriplePlay Manuale utente

Regulus

Regulus SRS1 T Manuale utente