Linear Technology LTC4007 Manuale utente

QUICK START GUIDE FOR DEMONSTRATION CIRCUIT 498

3 AND 4 CELL LI-ION BATTERY CHARGER BOARD WITH BUILT IN CHARGE TERMINATION

LTC4007

DESCRIPTION

Demonstration circuit 498 is a single battery stand-

alone battery charge controller with built in charge

termination featuring the LTC®4007. The input voltage

is 13 to 20V. The charger output voltage is pro-

grammed by jumpers to support 3- and 4-Cell Li-ion

batteries with a cell voltage of 4.1V or 4.2V/Cell. The

maximum charge current is 4A. The demo board is

initially configured for 12.6V Li-ion batteries. The

board will automatically charge a battery to termina-

tion as soon as input power is applied with a battery

connected prior to power up. Status LEDs are pro-

vided for CHG, ACP, FAULT, FLAG, ICL and LOBAT.

An onboard NTC thermistor is provided. Although this

charger is not a smart battery charger, a popular

smart battery connector is provided that can be used

for data logging with the optional DC1223A-B demo

board and software. To be clear, you do NOT need a

smart battery to use this board. The optional

DC1223A-B SMBUS to USB Port Adapter and asso-

ciated software to monitor a smart battery are for

demonstration purposes only. Contact your LT repre-

sentative for ordering a DC1223A-B.

Design files for this circuit board are available. Call

the LTC factory.

LTC is a registered trademark of Linear Technology Corporation.

Table 1. Performance Summary

PARAMETER CONDITION VALUE

Maximum Input Voltage Limited by input Capacitor Volt Ratings. 20V +/- 10 %

Recommended Minimum Input Voltage Vin > Vbat Termination voltage. 13V when using a 12.6V Li-ion battery.

Input Current Limit 3.5A

Maximum Charge Current Vin > Vbatmax > 6V 4A +/- 5%

QUICK START PROCEDURE

Demonstration circuit 498 is easy to set up to eva-

luate the performance of the LTC4007. Refer to Figure

1 for proper measurement equipment setup and fol-

low the procedure below:

NOTE: When measuring the input or output voltage

ripple, care must be taken to avoid a long ground lead

on the oscilloscope probe. Measure the input or out-

put voltage ripple by touching the probe tip directly

across the VIN or VOUT and GND terminals. See Figure

2 for proper scope probe technique.

1. Connect the input power source to DCIN termin-

als J1 or DCIN and GND using a power supply ca-

pable of handling 4A of current within an 11 to 20V

range. The input supply MUST be greater than the

full voltage value of the battery to allow a full

charge to take place.

2. Connect the load to VOUT and GND terminals.

3. Configure the jumpers for your specific battery.

4. Plug in the battery. The industry standard 5 Pin

AMP Smart Battery connector is provided as well

as generic soldering Test Points for hardwire con-

nections.

5. Turn on the input power supply.

6. Optionally use the provided DC1223A-B demon-

stration software to control and configure the

DC498A.

Downloaded from Arrow.com.

QUICK START GUIDE FOR DEMONSTRATION CIRCUIT 498

3 AND 4 CELL LI-ION BATTERY CHARGER BOARD WITH BUILT IN CHARGE TERMINATION

7. NOTE: If the board is allowed to get warm, the

onboard NTC thermistor may trip and momentarily

suspend the charge process. This can be con-

firmed by the fault LED turning on. When the board

cools down, charging will resume.

Figure 1: Proper Measurement Equipment Setup

Figure 2: Scope Probe Placement for Measuring Input or Output Ripple

OPTIONAL DC1223A-B SMBUS

TO USB ADAPTER

PROVIDES DATA LOGGING AND

BATTERY CONTROL

Downloaded from Arrow.com.Downloaded from Arrow.com.

QUICK START GUIDE FOR DEMONSTRATION CIRCUIT 498

3 AND 4 CELL LI-ION BATTERY CHARGER BOARD WITH BUILT IN CHARGE TERMINATION

Downloaded from Arrow.com.Downloaded from Arrow.com.Downloaded from Arrow.com.

Indice

Altri manuali Linear Technology Controllori

Linear Technology

Linear Technology LTC3875EUJ Guida rapida alla configurazione

Linear Technology

Linear Technology LTC1877 Guida rapida alla configurazione

Linear Technology

Linear Technology LTC4080 Manuale utente

Linear Technology

Linear Technology DC1830B-C Guida rapida alla configurazione

Linear Technology

Linear Technology LTM4612 Manuale utente

Linear Technology

Linear Technology LT8611 Manuale utente

Linear Technology

Linear Technology LT8705 Guida rapida alla configurazione

Linear Technology

Linear Technology mModule LTM8023 Guida rapida alla configurazione

Linear Technology

Linear Technology LTM8027 Guida rapida alla configurazione

Linear Technology

Linear Technology LTC3805/-5 Manuale utente

Linear Technology

Linear Technology 1158A Manuale utente

Linear Technology

Linear Technology DC1669A Guida rapida alla configurazione

Linear Technology

Linear Technology DC536 Manuale utente

Linear Technology

Linear Technology DC2087A Guida rapida alla configurazione

Linear Technology

Linear Technology DC2453A Guida rapida alla configurazione

Linear Technology

Linear Technology LTC3210 Manuale utente

Linear Technology

Linear Technology DC1738A Guida rapida alla configurazione

Linear Technology

Linear Technology LTC1736 Manuale utente

Linear Technology

Linear Technology LT3507 Guida rapida alla configurazione

Linear Technology

Linear Technology DC116 Series Guida rapida alla configurazione

Linear Technology

Linear Technology DC1900A Guida rapida alla configurazione

Linear Technology

Linear Technology LT1425 Manuale utente

Linear Technology

Linear Technology No Rsense LTC3736 Manuale utente

Linear Technology

Linear Technology DC2069A Guida rapida alla configurazione

Manuali Controllori popolari di altre marche

Digiplex

Digiplex DGP-848 Istruzioni operative

YASKAWA

YASKAWA SGM series Manuale utente

Sinope

Sinope Calypso RM3500ZB Manuale utente

Isimet

Isimet DLA Series Style 2 Manuale di installazione

LSIS

LSIS sv-ip5a Manuale utente

Rockwell Automation

Rockwell Automation 1769-L31 Manuale utente

Airflow

Airflow Uno hab Manuale utente

ABB

ABB ACS580-01 drives Manuale utente

Panasonic

Panasonic GM1 Series Manuale utente

Emerson

Emerson SW93 Manuale utente

AutoAqua

AutoAqua Smart ATO micro SATO-120P Manuale utente

Panasonic

Panasonic FP? Positioning Unit RTEX Manuale utente

Samson

Samson Type 5824 Manuale di servizio

Alpha IP

Alpha IP MIOB 21001 Manuale utente

Siemens

Siemens OpenAir GMA 1 Series Manuale utente

Surecom

Surecom SR-629 Manuale utente

Fishman

Fishman TriplePlay Manuale utente

Regulus

Regulus SRS1 T Manuale utente