MrHeater MHVFGH30LPBT Istruzioni per il montaggio
OPERATING INSTRUCTIONS
AND OWNER’S MANUAL
INSTALLER: Leave this manual with the appliance. CONSUMER: Retain this manual for future reference.
Model #
MR. HEATER, INC., 4560 W. 160TH ST., CLEVELAND, OHIO 44135 · 800-251-0001
WARNING:
- WHAT TO DO IF YOU SMELL GAS
WARNING
WARNING
2018 - CB
UNVENTED LP-GAS FIRED GARAGE HEATER
30,000 BTU Blue Flame Heaters
READ INSTRUCTIONS CAREFULLY: Read and follow all instructions. Place instructions in a safe
place for future reference. Do not allow anyone who has not read these instructions to assemble,
light, adjust or operate the heater.
CAUTION:
MHVFGH30LPBT
MHVFGH30LPT
2Installation Instructions and Owner’s Manual
Unvented LP-Gas Vent Free Heaters
IMPORTANT
WARNING:
WARNING: Do not use any accessory not
WARNING:
•
•
•
•
•
•
•
•
CONTENTS
WARNINGS ........................................................................2
SPECIFICATIONS ................................................................3
PRECAUTIONS ...................................................................3
IGNITION SYSTEM BATTERY INSTALLATION ......................4
BLOWER FAN CONTROL SWITCH OPERATION ...................4
DETERMINING THE TYPE OF HEATER LOCATION SPACE ....5
INSTALLATION ...................................................................6
FASTENING HEATER TO WALL ...........................................7
FLOOR MOUNTING AWAY FROM WALL ...........................8
CONNECTING TO GAS SUPPLY ..........................................8
OPERATING YOUR HEATER ..............................................10
CLEANING AND MAINTENANCE ......................................12
TROUBLESHOOTING ................................................... 13-14
EXPLODED-VIEW PARTS DRAWING ..................................15
PARTS LIST ......................................................................15
WARRANTY ....................................................................16
CAUTION: Never connect heater directly
to the Propane supply. This heater requires
an external regulator (not supplied). Install
the external regulator between the heater and
Propane/LP supply.
The installer must supply an external
regulator. The external regulator will reduce
the incoming gas pressure to between 11
and 14 inches of water. If you do not reduce
incoming gas pressure heater regulator
damage could occur. Install external regulator
with the vent pointing down. Pointing the
vent down protects it from freezing rain or
sleet.
In order to provide the best service possible Mr. Heater is now giving you
more ways to get in touch with us:
WEBSITE: Mr. Heater’s full line of product are now at:
WWW.MRHEATER.COM
FACEBOOK: Find us on Facebook
TWITTER: Find us on twitter
YouTube: There are now informational videos on YouTube.
SOCIAL MEDIA
3Installation Instructions and Owner’s Manual
Unvented LP-Gas Vent Free Heaters
Operating heater above elevations of 4,500 feet
could cause pilot/ODS to shutdown heater.
DANGER
Carbon Monoxide Poisoning:
Propane/LP Gas:
PRECAUTIONS:
Fresh Air for
Combustion and Ventilation
WARNING:
•
stored
•
SPECIFICATIONS
30,000
LP-Gas Only
Yes
Sides
**Operating heater above elevations of 4,500 feet could cause pilot/ODS to shutdown heater.**
4Installation Instructions and Owner’s Manual
Unvented LP-Gas Vent Free Heaters
Product Features
Figure 1
SAFETY DEVICE
IGNITION SYSTEM / BATTERY INSTALLATION
(AA Battery included)
To install or replace battery unscrew the igniter cap
(red button), insert battery positive (+) terminal up
and replace cap.
(AA Battery included)
THERMOSTATIC CONTROL
BLOWER FAN CONTROL SWITCH OPERATION
LOCAL CODES
Installation must conform to local codes or in the
UNPACKING
FRESH AIR FOR COMBUSTION AND
VENTILATION
WARNING
ESTABLISHING ADEQUATE VENTILATION
National Fuel Gas
Code, NFPA 54/ ANSI Z223.1, Section 5.3, Air for
Combustion and Ventilation
Unusually Tight Construction
Ventilation Air
from Outdoors
where:
2
windows and doors, and
If your home does not meet all of the three criteria
Determining the Type of Heater Location
Space
The National Fuel Gas Code, NFPA 54/ ANSI Z223.1
3
3
Ignitor Button
Control Knob
Grill
Front Panel
Burners
Heater
Cabinet
Fan Blower
Switch
(located on back
of heater)
5Installation Instructions and Owner’s Manual
Unvented LP-Gas Vent Free Heaters
DETERMINING THE TYPE OF HEATER
LOCATION SPACE:
Note:
-
WARNING:
National Fuel Gas Code, NFPA 54/ ANSI Z223.1,
You must provide additional fresh air. Your options
are as follows:
-
VENTILATION AIR
Ventilation from Inside Building
Ventilation
Gills into
Adjoining
Room -
Option 1
Ventilation Gills into
Adjoining Room - Option 2
12”
12”
Or remove
door into
Adjoining
Room -
Option 3
OUTLET
Figure 2.
Figure 3.
6Installation Instructions and Owner’s Manual
Unvented LP-Gas Vent Free Heaters
LOCATING HEATER
•
•
•
CAUTION:
CAUTION:
WARNING:
•
• In windy or drafty areas
WARNING:
WARNING:
Ventilation from Outdoors
*IMPORTANT:
IMPORTANT: Vent-free heaters add moisture to
INSTALLATION
NOTICE: -
-
WARNING:
CHECK GAS TYPE
Use only LP-gas. LP-gas, do
THIS INSTALLATION REQUIRES:
•
•
•
•
•
•
•
•
7Installation Instructions and Owner’s Manual
Unvented LP-Gas Vent Free Heaters
Figure 4
FASTENING HEATER TO WALL
Mounting Bracket
-
Figure 5
Figure 6
WARNING: Maintain minimum clearances shown in
Figure 7
-
Note:
Adjoining Wall
18” Min.
SEE CLEARANCE
SPECIFICATIONS ON PG. 3
16” (Lg)
12-9/64” (Sm)
Mark mounting hole locations
and drill holes where indicated.
Allow for minimum clearances
Left
Side
Side
from sides
Floor
Mounting
Bracket
8Installation Instructions and Owner’s Manual
Unvented LP-Gas Vent Free Heaters
Figure 8.
-
Figure 9.
Figure 10
Horizontal Slots
Mounting Bracket
mounted to wall
FLOOR MOUNTING AWAY FROM WALL:
Figure 11
CONNECTING TO GAS SUPPLY
WARNING:
WARNING:
Screw
hole
Screw
hole
9Installation Instructions and Owner’s Manual
Unvented LP-Gas Vent Free Heaters
CAUTION:
CAUTION:
IMPORTANT:
CAUTION: LP-Gas
-
IMPORTANT:
CHECKING GAS CONNECTIONS
WARNING:
WARNING:
PRESSURE TESTING GAS SUPPLY PIPING
SYSTEM
Figure 12
10 Installation Instructions and Owner’s Manual
Unvented LP-Gas Vent Free Heaters
Pressure Testing Heater Gas Connections:
-
Operating Your Heater
To Turn OFF Gas to Appli-
ance ELECTRICAL WIRING DIAGRAM:
o
WARNING:
OPERATING YOUR HEATER
FOR YOUR SAFETY READ BEFORE LIGHTING
WARNING: If you do not follow these instructions
-
WHAT TO DO IF YOU SMELL GAS
•
•
• Do not touch any electrical switch; do not use any
•
•
-
Control Valve
Equipment
To regulated propane
source
Figure 13
Figure 14
Equipment
Open
Closed
Figure 15
Caution:
to disconnection
errors can
Questo manuale è adatto per i seguenti modelli
1
Indice
Altri manuali MrHeater Stufa
MrHeater
MrHeater BIG Buddy MH18B Istruzioni per il montaggio
MrHeater
MrHeater MHS15t Istruzioni per il montaggio
MrHeater
MrHeater MH15T Istruzioni per il montaggio
MrHeater
MrHeater MHVFRD20BT LP Istruzioni per il montaggio
MrHeater
MrHeater MH18CH Istruzioni per il montaggio
MrHeater
MrHeater MHU100NGPALP Istruzioni per il montaggio
MrHeater
MrHeater MHVFRD20NG Istruzioni per il montaggio
MrHeater
MrHeater MHVFRD20NGBT Istruzioni per il montaggio
MrHeater
MrHeater MH400FAVT Istruzioni per il montaggio
MrHeater
MrHeater HEATSTAR 170FAV Istruzioni per il montaggio
MrHeater
MrHeater MHVFBF30TNGT Istruzioni per il montaggio
MrHeater
MrHeater CONTRACTOR MH75KT Manuale utente
MrHeater
MrHeater MH170QFAVT Istruzioni per il montaggio
MrHeater
MrHeater MHVFRD10LP Istruzioni per il montaggio
MrHeater
MrHeater MH40 NG Istruzioni per il montaggio
MrHeater
MrHeater MR. HEATER MH125FAV Istruzioni per il montaggio
MrHeater
MrHeater MH38QFA Istruzioni per il montaggio
MrHeater
MrHeater MH360FAET Istruzioni per il montaggio
MrHeater
MrHeater MH4GC Istruzioni per il montaggio
MrHeater
MrHeater Portable Buddy Manuale
Manuali Stufa popolari di altre marche
Empire Heating Systems
Empire Heating Systems WCC65 Manuale utente
Wetekom
Wetekom 92 86 43 Manuale utente
Desa
Desa SPC170-F Manuale utente
Watlow
Watlow Watrod Electric Tubular Heaters Manuale utente
Haverland
Haverland ECO-DRY GPS Series Manuale elenco delle parti
Stelpro
Stelpro ASILVC2060 Series Manuale utente