Nibe F2040 Series Guida utente

Installer manual

LEK

NIBE™ F2040

8, 12, 16 kW

Air/water heat pump

IHB GB 1512-3

231844

Table of Contents

21 Important information

2Safety information

62 Delivery and handling

6Transport and storage

6Assembly

8Supplied components

9Removing the covers

9Removing the front panel

10Removing the side panel

113 The heat pump design

11General

16Electrical connection

194 Pipe connections

19General

19Pipe coupling heating medium circuit

21Docking alternatives

225 Electrical connections

22General

24Connections

306 Commissioning and adjusting

30Preparations

Filling and venting the heating medium sys-

tem

30Compressor heater

31Start-up and inspection

32Readjusting, heating medium side

33Adjustment, charge flow

347 Control

358 Disturbances in comfort

35Troubleshooting

399 Alarm list

4210 Accessories

4311 Technical data

43Dimensions and setting-out coordinates

45Sound pressure levels

46Technical specifications

53Electrical circuit diagram

59Index

1Table of Contents |NIBE™ F2040

Safety information

This manual describes installation and service proced-

ures for implementation by specialists.

This appliance can be used by children

aged from 8 years and above and per-

sons with reduced physical, sensory or

mental capabilities or lack of experience

and knowledge if they have been given

supervision or instruction concerning

use of the appliance in a safe way and

understand the hazards involved. Chil-

dren shall not play with the appliance.

Cleaning and user maintenance shall

not be made by children without super-

vision.

Rights to make any design or technical

modifications are reserved.

©NIBE 2015.

Symbols

NOTE

This symbol indicates danger to machine or

person.

Caution

This symbol indicates important information

about what you should observe when main-

taining your installation.

TIP

This symbol indicates tips on how to facilitate

using the product.

Marking

The CE marking means that NIBE ensures that the

product meets all regulations that are placed on it

based on relevant EU directives. The CE mark is obligat-

ory for most products sold in the EU, regardless where

they are made.

Serial number

The serial number for F2040 can be found on the side

of the foot.

F2040-8

LEK

DATA

Serial number

F2040-12

LEK

DATA

Serial number

NIBE™ F2040Chapter 1 | Important information2

1 Important information

F2040-16

LEK

DATA

Serial number

Caution

Always give the product's serial number when

reporting a fault.

Country specific information

Installer manual

This installer manual must be left with the customer.

3Chapter 1 | Important informationNIBE™ F2040

Inspection of the installation

Current regulations require the heating installation to be inspected before it is commissioned. The inspection must

be carried out by a suitably qualified person. Fill in the page for information about installation data in the User

manual.

DateSignatureNotesDescription

✔

System flushed

System vented

Particle filter

Shut-off and drain valve

Charge flow set

Fuses property

Safety breaker

Communication cable connected

F2040 addressed (only when cascade

connection)

Miscellaneous

NIBE™ F2040Chapter 1 | Important information4

Contact information

KNV Energietechnik GmbH, Gahberggasse 11, 4861 SchörflingAT

Tel: +43 (0)7662 8963-0 Fax: +43 (0)7662 8963-44 E-mail: mail@knv.at www.knv.at

NIBE Wärmetechnik AG, Winterthurerstrasse 710, CH-8247 FlurlingenCH

Tel: (52) 647 00 30 Fax: (52) 647 00 31 E-mail: [email protected] www.nibe.ch

Druzstevni zavody Drazice s.r.o, Drazice 69, CZ - 294 71 Benatky nad JizerouCZ

Tel: +420 326 373 801 Fax: +420 326 373 803 E-mail: [email protected] www.nibe.cz

NIBE Systemtechnik GmbH, Am Reiherpfahl 3, 29223 CelleDE

Tel: 05141/7546-0 Fax: 05141/7546-99 E-mail: [email protected] www.nibe.de

Vølund Varmeteknik A/S, Member of the Nibe Group, Brogårdsvej 7, 6920 VidebækDK

Tel: 97 17 20 33 Fax: 97 17 29 33 E-mail: [email protected] www.volundvt.dk

NIBE Energy Systems OY, Juurakkotie 3, 01510 VantaaFI

Puh: 09-274 697 0 Fax: 09-274 697 40 E-mail: inf[email protected] www.nibe.fi

NIBE Energy Systems France Sarl, Zone industrielle RD 28, Rue du Pou du Ciel, 01600 ReyrieuxFR

Tel : 04 74 00 92 92 Fax : 04 74 00 42 00 E-mail: [email protected] www.nibe.fr

NIBE Energy Systems Ltd, 3C Broom Business Park, Bridge Way, Chesterfield S41 9QGGB

Tel: 0845 095 1200 Fax: 0845 095 1201 E-mail: [email protected].uk www.nibe.co.uk

NIBE Energietechniek B.V., Postbus 634, NL 4900 AP OosterhoutNL

Tel: 0168 477722 Fax: 0168 476998 E-mail: [email protected] www.nibenl.nl

ABK AS, Brobekkveien 80, 0582 Oslo, Postadresse: Postboks 64 Vollebekk, 0516 OsloNO

Tel. sentralbord: +47 23 17 05 20 E-mail: [email protected] www.nibeenergysystems.no

NIBE-BIAWAR Sp. z o. o. Aleja Jana Pawła II 57, 15-703 BIAŁYSTOKPL

Tel: 085 662 84 90 Fax: 085 662 84 14 E-mail: sekretariat@biawar.com.pl www.biawar.com.pl

Tel./fax +7 831 419 57 06 E-mail: [email protected] www.nibe-evan.ru

NIBE AB Sweden, Box 14, Hannabadsvägen 5, SE-285 21 MarkarydSE

Tel: +46-(0)433-73 000 Fax: +46-(0)433-73 190 E-mail: [email protected] www.nibe.se

For countries not mention in this list, please contact Nibe Sweden or check www.nibe.eu for more information.

5Chapter 1 | Important informationNIBE™ F2040

Transport and storage

F2040 must be transported and stored vertically.

Assembly

■Place F2040 outdoors on a solid level base that can

take the weight, preferably a concrete foundation.

If concrete slabs are used they must rest on asphalt

or shingle.

■The concrete foundation or slabs must be positioned

so that the lower edge of the evaporator is at the

level of the average local snow depth, although a

minimum of 300 mm.

■The F2040 should not be positioned next to sensitive

walls, for example, next to a bedroom.

■Also ensure that the placement does not inconveni-

ence the neighbours.

■F2040 must not be placed so that recirculation of the

outdoor air can occur. This causes lower output and

impaired efficiency.

■The evaporator should be sheltered from direct wind,

which negatively affects the defrosting function.

Place F2040 protected from wind against the evap-

orator.

■Large amounts of condensation water as well as melt

water from defrosting can be produced. Condensa-

tion water must be led off to a drain or similar (see

page 7).

■Care must be exercised so that the heat pump is not

scratched during installation.

LEK

Cirka 1 m

LEK

Cirka 1 m

min 300 mm

Min. 300 mm

Do not place F2040 directly on the lawn or other non

solid surface.

If there is a risk of snow slip from roof, a protective roof

or cover must be erected to protect the heat pump,

pipes and wiring.

NIBE™ F2040Chapter 2 | Delivery and handling6

2 Delivery and handling

Condensation run off

Condensation water trough

The condensation water trough is used to collect and

lead away condensation water from the heat pump.

NOTE

It is important to the heat pump function that

condensation water is led away and that the

drain for the condensation water run off is not

positioned so that it can cause damage to the

house.

NOTE

Pipe with heating cable for draining the con-

densation water trough are not included.

NOTE

To ensure this function the accessory KVR 10

should be used.

NOTE

The electrical installation and wiring must be

carried out under the supervision of an author-

ised electrician.

NOTE

Self regulating heating cables must not be

connected.

Caution

If none of the recommended alternatives is

used good lead off of condensation water

must be assured.

■The condensation water (up to 50 litres/day) collec-

ted in the trough should be routed by pipe to an

appropriate drain, it is recommended that the

shortest outdoor stretch possible is used.

■The section of the pipe that can be affected by frost

must be heated by the heating cable to prevent

freezing.

■Route the pipe downward from F2040.

■The outlet of the condensation water pipe must be

at a depth that is frost free or alternatively indoors

(with reservation for local ordinances and regula-

tions).

■Use a water trap for installations where air circulation

may occur in the condensation water pipe.

■The insulation must be tight against the bottom of

the condensation water trough.

Drain pan heater, control

The drain pan heater is supplied with power when one

of the following conditions is met:

1. Operating mode "Heating" or "Hot water" is activ-

ated.

2. The compressor has been in operation for at least

30 minutes after last start.

3. The ambient temperature is lower than 1 C.

Recommended alternatives

Stone caisson

LEK

Frostfritt djup

Frost proof depth

If the house has a cellar the stone caisson must be po-

sitioned so that condensation water does not affect

the house. Otherwise the stone caisson can be posi-

tioned directly under the heat pump.

The outlet of the condensation water pipe must be at

frost free depth.

Drain indoors

Water seal

The condensation water is lead to an indoor drain

(subject to local rules and regulations).

Route the pipe downward from F2040.

7Chapter 2 | Delivery and handlingNIBE™ F2040

The condensation water pipe must have a water seal

to prevent air circulation in the pipe.

Gutter drainage

Frostfritt

djup

LEK

Frost proof depth

Water seal

The outlet of the condensation water pipe must be at

frost free depth.

Route the pipe downward from F2040.

The condensation water pipe must have a water seal

to prevent air circulation in the pipe.

Installation area

The distance between F2040 and the house wall must

be at least 150 mm. Clearance in front of F2040 should

be at least one metre.

255

Ställbar 40-50 955

243

512

110

395

265

452 1075

1145

108

Ø40*

3000 mm

400 mm

Minimalt

fritt utrymme

Minimalt

fritt utrymme

Fritt utrymme

framför

150 mm

Fritt

utrymme

bakom

600mm

Minimum

free space

Minimum

free space

Free

space

behind

400 mm 600 mm

150 mm

3000 mm

Free space

in front

Supplied components

LEK

Particle filter R25 (HQ1).

2 flexible hoses (R25) with

4 seals

NIBE™ F2040Chapter 2 | Delivery and handling8

Altri manuali per F2040 Series

Indice

Altri manuali Nibe Pompa di calore

Manuali Pompa di calore popolari di altre marche

MICROWELL

MICROWELL HP 1000 GREEN Manuale utente

Sanyo

Sanyo SAP120FCH Manuale utente

Daikin

Daikin EHYHBH05AA Manuale utente

Panasonic

Panasonic WH-SDF03E3E5 Guida

Bryant

Bryant 544B Manuale utente

Airxcel

Airxcel 45000 Series Manuale

Mitsubishi Electric

Mitsubishi Electric PUZ-SWM60VAA Manuale utente

Dimplex

Dimplex LI 16I-TUR Guida utente

Carrier

Carrier WSHP Open v3 Guida rapida alla configurazione

TGM

TGM CTV14CN018A Manuale utente

Carrier

Carrier 38MGQ Series Manuale utente

Kokido

Kokido K2O K880BX/EU Guida alla risoluzione dei problemi

Viessmann

Viessmann VITOCAL 300-G PRO Type BW 2150 Guida rapida

Carrier

Carrier 48EZN Manuale utente

Viessmann

Viessmann KWT Vitocal 350-G Pro Series Istruzioni operative

Ariston

Ariston NIMBUS Manuale utente

Weishaupt

Weishaupt WWP L 7 Guida utente

GE Zoneline AZ85H09EAC Manuale utente