Outback Excelsior 3 Manuale utente

Assembly and Operating Instructions for Outback®

Excelsior 3 Burner and Excelsior 6 Burner Gas Barbecues

Photographs are not to scale.

Specifications subject to change

without prior notice.

WARNING

• For outdoor use only.

• Read instructions before using the appliance. Failure to follow instructions

could result in death, serious bodily injury, and/or property loss.

• Warning: accessible parts may be very hot. Keep young children away.

• Do not move the appliance during use.

• Turn off the gas supply at the gas bottle after use.

• Do not change the gas bottle when the appliance is hot.

• Any modification of the appliance, misuse, or failure to follow the instructions

may be dangerous and will invalidate your warranty. This does not affect your

statutory rights.

• Retain these instructions for future reference.

• Leak test your barbecue annually. Check the hose connections are tight and

leak test each time you reconnect the gas bottle.

FOR YOUR SAFETY

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open barbecue lid or hood.

4. If odour continues, discontinue use and

contact your local dealer.

FOR YOUR SAFETY

1. Do not store or use petrol or other flammable

vapours or liquids in the vicinity of this or any

other appliance.

2. A gas bottle not connected for use shall not be

stored in the vicinity of this or any other

appliance.

0359

CODE PART QTY Outback® Excelsior

3 Burner Outback® Excelsior

6 Burner

HOOD

A1 Hood Handle 1  

A2 Hood (Pre-Assembled to Body) 1  

A3 Hood Panel 1  

A4 Heat Indicator and Nuts 1  

BODY

B1 Barbecue Body 1  

B2 Burner 36

B3 Control Panel 1  

B4 Knob 36

B5 Drip Tray 1  

B6 Drip Tray Left Bracket 1 

B7 Drip Tray Right Bracket 1 

B8 Flame Tamer 2 4

B9 Large Cooking Grill 1  

B10 Small Cooking Grill 1  

B11 Cooking Griddle 1  

B12 Hose and Regulator Assembly 1 

B13 Warming Rack 1  

TROLLEY

C1 Side Burner Shelf 1  

C2 Side Shelf Shield 1  

C3 Front Left Endcap 1  

C4 Rear Left Endcap 1  

C5 Utensil Tray 2  

C6 Side Shelf 1  

C7 Right Insert 1  

C8 Left Front Leg 1  

C9 Left Rear Leg 1  

C10 Right Front Leg 1  

C11 Right Rear Leg 1  

C12 Bottom Slat Assembly 1  

C13 Base Tray 1  

C14 Gas Bottle Holder 1  

C15 Trolley Foot 1  

C16 Hubcap 2  

C17 Wheel 2  

C18 Axle 1  

C19 Retaining Rod 1  

C20 Gas Bottle Strap 1  

C21 Side Shelf Hook 2  

C22 Fixing Bracket 2  

C23 Side Burner Grid 1  

HARDWARE

D1 M4x15 Bolt 4  

D2 M5x15 Bolt 4  

D3 Ø5 Washer 4  

D4 M5 Nut 4  

D5 M6x15 Bolt 24  

D6 Ø6 Washer 4  

D7 M6x35 Bolt 16  

D8 1/4-20UNCx12 Bolt 6  

D9 Locknut 2  

Parts List

Quantities vary according to model purchased. Specifications subject to change without prior notice. For more

details on hardware, please see ‘Hardware Reference Diagram’.

Pre-Assembled Component

Quantity varies according to model purchased

 Appearance, size, and construction may differ according to model purchased

Parts Diagrams

Quantities vary according to model purchased. Specifications subject to change without prior notice. For more

details on hardware, please see ‘Hardware Reference Diagram.’

C5C4C1

C12

B11B9

C15

C14

C16

C17

C18

C11

C20

C19

C10

C13

C21

B12

C22

B6 B7

B10

C23

B13

Hardware Reference Diagram

Specifications subject to change without prior notice.

D2,D3,D4 D5,D6

Attach the Right Front Leg (C10) to the Trolley Foot (C15).

4. Assembly

IMPORTANT!

• Tools Required: Medium size flat blade or Phillips/Crosspoint screwdriver, adjustable spanner or metric

spanner set

• The assembly of this barbecue requires 2 people.

• Carefully unpack the parts from the box and remove all internal packaging before commencing assembly. All

loose items including the grills, griddle, flame tamers and warming basket must be removed from the body.

• The inlet connection of the gas rail assembly on the BBQ body is lower than the body. You must never allow

the pipe to rest on the ground during assembly as serious damage could result. We recommend the body is

left sitting in the box until required for assembly to trolley.

• Whilst every care is taken in the manufacture of this product, care must be taken during assembly in case

sharp edges are present.

Attach the Right Rear Leg (C11) to the Trolley Foot (C15). The leg is a push fit onto the trolley foot and on

the gas bottle holder. In case of difficulty, they may need tapping lightly with a soft face mallet. Take care

not to damage parts.

Attach the Bottom Slat Assembly (C12) to the Base Tray (C13) using the M6x15 Bolts (D5).

Attach the leg assembly to the Base Tray (C13) using the M6x15 Bolts (D5).

Align theGas Bottle Holder (C14) withthe Bottom Slat Assembly (C12).

Attach the Left Front Leg (C8) and Left Rear Leg (C9) to the Gas Bottle Holder (C14).

Note: Threaded inserts must be facing in the direction shown!

Threaded

Insert

Attach the Gas Bottle Holder (C14) to the Bottom Slat Assembly (C12) using the Screws

(D2) and Washers (D3).

Unscrew the Locknuts (D9) from both ends of the Axle (C19).

Insert the axle through the clamping brackets into the Gas Bottle Holder (C14) and tighten the clamp

screws. Take care not to over tighten these screws which will damage the plastic gas bottle holder.

Attach the Gas Bottle Holder (C14) to the Bottom Slat Assembly (C12) using M6x15 Bolts (D5)

and Ø6 Washers (D6).

Slide the Wheels (C17) over each end of the axle. Secure the wheels into place with the

locknuts.

Carefully turn the completed trolley over, right side up.

Remove all cooking components, flame tamer, and any internal packaging from the Barbecue

Body (B1).

Carefully turn the barbecue body upside-down.

CAUTION! Care must be taken to ensure the hood does not fall open unexpectedly or

becomes damaged when it is set on the ground.

Attach the Side Shelf (C6) to the barbecue body using M6x15 Bolts (D5).

Place the wheel Hubcaps (C16) onto the outsides of the wheels.

Questo manuale è adatto per i seguenti modelli

Indice

Altri manuali Outback Griglia

Outback

Outback Omega 150 Manuale utente

Outback

Outback SG-930 Manuale utente

Outback

Outback RG47F Manuale utente

Outback

Outback RC4340S Manuale utente

Outback

Outback OUTBACK TROOPER 359 Assembly and Manuale utente

Outback

Outback Omega 100 Manuale utente

Outback

Outback CD200 Manuale utente

Outback

Outback CS3200 Manuale utente

Outback

Outback Modern Classic Trooper Manuale utente

Outback

Outback Ranger 3 Manuale utente

Outback

Outback Trooper Plus Manuale utente

Outback

Outback Professional Range Pro 6 Manuale utente

Outback

Outback Cook Dome 703 Charcoal Manuale utente

Outback

Outback THG2710 Manuale utente

Outback

Outback Hunter THG3302PD Manuale utente

Outback

Outback Outback Excel 210 Manuale utente

Outback

Outback Omega 150 Manuale utente

Outback

Outback Omega 100 Manuale utente

Outback

Outback Hunter Manuale utente

Outback

Outback ONYX 4 Burner Manuale utente

Outback

Outback Excel 310 Manuale utente

Outback

Outback Trekker RG47B Manuale utente

Outback

Outback Trooper Manuale utente

Outback

Outback Comet Manuale utente

Manuali Griglia popolari di altre marche

Orbegozo

Orbegozo GR 2300 Manuale utente

bora

bora PT11 Manuale utente

Klarstein

Klarstein 10031664 Manuale utente

Garland

Garland MWE3W Manuale utente

Char-Broil

Char-Broil 463722714 Manuale utente

Nexgrill

Nexgrill 720-0830HK Manuale utente

Kenmore

Kenmore 415.16123800 Manuale utente

Camp Chef

Camp Chef PG24CLAU Manuale utente

Tucker Barbecues

Tucker Barbecues GTR Series Istruzioni per il montaggio

Monogram

Monogram ZGG540NCP1SS Manuale utente

Equipex

Equipex Sodir Savoy Manuale utente

Gaggenau

Gaggenau VR 414 610 Manuale utente

Miele

Miele KM 408-1 Manuale utente

George Foreman

George Foreman GGR50B Manuale utente

AOG

AOG T series Manuale utente

Gorenje

Gorenje TG2000CB Manuale di istruzioni

Weber

Weber Genesis Silver-B Permamount NG 051701 Manuale utente

Glen

Glen SA 3037 Manuale utente