Outdoor Plus OPT-TT E Series Manuale utente
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 1
TOP TORCHES
ELECTRONIC IGNITION
OPT-TT(XX)E OR OPT-TT(XX)SE
INSTALLER: Leave this manual with the appliance
CONSUMER: Retain this manual for future reference.
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 2
AVERTISSEMENT
AVERTISSEMENT
AVERTISSEMENT
WARNING
WARNING
WARNING
Do not store or use gasoline, or other
ammable vapors and liquids, in the vicinity of
this or any other appliance.
An LP-cylinder not connected for use shall not
be stored in the vicinity of this or any other
appliance.
Improper installation, adjustment, alteration,
service, or lack of maintenance can cause injury
or property damage.
Read the installation, operating, and
maintenance instructions thoroughly before
installing or servicing this equipment.
FOR OUTDOOR USE ONLY.
Ne pas entreposer ne utilizer de l’essence ni
d’autres vapuers ou liquids inammables dans
le voisinage de l’appareil, ne de tout autre
appareil. Une bouteille de propane qui n’est
pas raccordee en vue de son utilisation, ne doit
pas etre entreposee dans le voisiange de cet
appariel ou de tout autre appreil.
Une installation, un ajustement, une
modication, une réparation ou un entretien
inapproprié peuvent être la cause de blessures
ou de dommages.
Veuillez lire attentivement les instructions
d’installation, d’utilisation et d’entretien avant
d’installer ou de réparer ce matériel.
POUR USAGE A L’EXTERIEUR SEULEMENT.
SAFETY WARNINGS
AVERTISSEMENTWARNING
For use with natural gas or liquid propane only.
Do not use charcoal or other solid fuel in gas
burning appliances.
Do not use your re feature for cooking.
Always adhere to the specied clearances listed in
this manual.
Never allow clothing or other ammable materials
come in contact with any hot surface until it has
fully cooled.
Never wear loose tting or hanging garments
while using your re pit. Fabric may ignite and
result in personal injury.
Pour utilisation avec du gaz naturel ou du propane
liquide seulement.
N’utilisez pas de charbon de bois ou d’autres
combustibles solides dans les appareils à gaz.
N’utilisez pas votre caractéristique de feu pour
cuisiner.
Respectez toujours les dégagements spéciés
dans ce manuel.
Ne laissez jamais des vêtements ou d’autres
matériaux inammables entrer en contact avec
une surface chaude avant d’avoir complètement
refroidi
Ne portez jamais de vêtements amples ou
suspendus lorsque vous utilisez votre foyer. Le
tissu peut s’enammer et entraîner des blessures.
TOP TORCH
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 3
AVERTISSEMENT
AVERTISSEMENT
WARNING
WARNING
If you smell gas:
õShut o gas to the appliance
õExtinguish any open ame
õIf odor continues, keep away from the
appliance and immediately call your gas
supplier or re department.
Si’l y une odeur de gaz:
õCoupez l’admission de gaz de l’appareil.
õÉteindre toute amme nue.
õSi l’odeur persiste, éloignez-vous de
l’appareil et appelez immédiatement le
fournisseur de gaz ou le service d’incendie.
SAFETY WARNINGS
TOP TORCH
For use with natural gas or liquid propane only.
Do not use charcoal or other solid fuel in gas
burning appliances.
Do not use your re feature for cooking.
Always adhere to the specied clearances listed in
this manual.
Never allow clothing or other ammable materials
come in contact with any hot surface until it has
fully cooled.
Never wear loose tting or hanging garments
while using your re pit. Fabric may ignite and
result in personal injury.
Pour utilisation avec du gaz naturel ou du propane
liquide seulement.
N’utilisez pas de charbon de bois ou d’autres
combustibles solides dans les appareils à gaz.
N’utilisez pas votre caractéristique de feu pour
cuisiner.
Respectez toujours les dégagements spéciés
dans ce manuel.
Ne laissez jamais des vêtements ou d’autres
matériaux inammables entrer en contact avec
une surface chaude avant d’avoir complètement
refroidi
Ne portez jamais de vêtements amples ou
suspendus lorsque vous utilisez votre foyer. Le
tissu peut s’enammer et entraîner des blessures.
Carbon Monoxide Hazard
This appliance can produce carbon monoxide
which has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in enclosed
space such as a camper, tent, car or
home.
MONOXYDE DE CARBONE
Cette appareil peut produire du monoxyde de
carbone, un gaz inodore.
L’utilisation de cet appareil dan des espaces
clos peut entrainer la mort.
Ne jamais utiliser cet appareil dans
un espace clos comme un véhicule de
camping, une tente, une automobile ou
une maison.
AVERTISSEMENTWARNING
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 4
WARNING
California Proposition 65 Warning: Chemicals known to the State of California to cause cancer, birth
defects or other reproductive harm are found in and/or created by the combustion of natural gas, propane,
butane and other fuels. Always operate this unit as described in the owner’s manual and in well ventilated
areas.
SAFETY WARNINGS
WARNING
Installation must conform with local codes or, in the absence of local codes, with the
National Fuel Gas Code, ANSI Z223.1 / NFPA 54, or International Fuel Gas Code.
The appliance, when installed, must be electrically grounded in accordance with local codes or, in
the absence of local codes, with the National Electric Code, ANSI/NFPA 70, if applicable.
BURN HAZARD
SAFETY
While the re unit is operating, the outside surface may reach high temperatures which may cause burns.
Never leave children unattended in the area where the re unit is being used. Close supervision of children
is necessary when any appliance is used near children. Never leave the re pit unattended when in use.
Do not reach over your re unit when hot or in use.
Keep all electrical supply cords away from the heated areas of the re pit.
Clothing or other ammable materials should not be hung from the appliance, or placed on or near the
appliance.
DANGER
Propane gas source to the re pit must be regulated.
Do not operate if regulator has been removed. Fire or explosion can occur.
TOP TORCH
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 5
GENERAL INFORMATIONS
Fuel Type - Before making gas connections ensure appliance being installed is compatible with the available gas
type. Check the label on the appliance to conrm appliance gas type requirement.
Gas Pressure - Proper input gas pressures are required for optimum appliance performance.
GAS PRESSURE REQUIREMENTS
Natural Gas
Minimum 3.5” W.C. - Nominal: 7.0” W.C. - Maximum 1/2” PSI (14.0” W.C.)
Liquid Propane:
Minimum 8.0” W.C. - Nominal: 11.0” W.C. - Maximum 1/2” PSI (14.0” W.C.)
ELECTRICAL REQUIREMENTS
The All Weather Electronic Ignition System operates on 24 Volts AC power ONLY
DO NOT Attempt to Power using 110 Volts AC Power – Damage WILL RESULT
Acceptable Input Voltages to Supplied 24 Volt AC Transformer: 110 / 210 / 220 / 240 / 480 Volt AC
Supplied 24 Volt AC Transformer compatible with all voltages listed above
Read label on supplied transformer for proper connection information
Recommended Wire Size: 12 gauge wire for all installations
CLEARANCE FROM COMBUSTIBLES
Warning - Provide adequate clearance
from combustibles as shown below.
INSTALLATION & MAINTENANCE
We suggest that our products be
serviced by a professional certied
in the U.S. By the National Fireplace
Institute as a NFI Specialists
TOP TORCH
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 6
INSTALLATION
INSTALLATION OF BASE POLE
12”
8’
Note: Installation should be done by a qualied service technician that is locally licensed.
OPTION 1
Manual gas shut o located at torch
Manual Gas
Shuto Valve
Base Pole
Base Pole
Manual Gas
Shuto Valve
Electrical
Conduit
Electrical
Conduit
Gas Line Gas Line
Landscape
Box
OPTION 2
Manual gas shut o located on torch
pole (Requires you to drill a hole)
TIKI TORCH MANUAL SHUT OFF OPTIONS
Torch Head
Black Pole
Base Pole
Diagram 1 shows ½” gas stub and an electrical conduit
stubbed up inside a hole. The hole is 12” deep.
The wire installed inside the conduit is low voltage
landscape wire (12 gauge) and we pulled 8’ of wire
beyond the end of the conduit to have plenty to pull up
through the poles in the Tiki.
STEP 1
DIAGRAM 1 DIAGRAM 2
Diagram 2 shows the Base Pole. Slide it over the Gas &
Electric stubs.
Adjust the height of the Base Pole so that the tapered
top end of the Base Pole ended up above grade.
Do this to make the connection between the Base Pole
and the Tiki Pole easier later on.
STEP 2
TOP TORCH
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 7
INSTALLATION
STEP 3
If you are installing the Manual Gas Shuto on the Tiki Pole
(Option 2 from page 7) rst remove the handle from the Ball
Valve and then install the ball valve on the ½” gas riser as shown
in diagram 3.
The use of pipe dope or Gas Teon tape is highly recommended
to prevent a possible gas leak.
STEP 4
Once the Manual Gas Shuto is installed measure from the
center of the Gas Shuto to the top of the Black Base Pole.
This dimension we shall refer to as measurement “A”.
See diagram 4
STEP 5
Temporarily install the longer pole and measure from the
seam between the Base Pole and the top of the long tiki
pole. This dimension we will refer to as measurement “B”.
DIAGRAM 3
DIAGRAM 4
DIAGRAM 5
A
Base Pole
Inner Sleeve
B
TOP TORCH
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 8
INSTALLATION
STEP 6
Install ½” gas hose to your gas riser (or manual gas
shuto valve) so that the end of the ½” gas line is 1”
SHORTER than the pole (measurement “B” from the
previous page)
In addition, bring the wires previously installed
up along the gas line and tape it to the gas line in
anticipation of installing the longer tiki pole.
STEP 7
As shown in diagram 6, Measure from
the bottom of the long tiki pole up to
measurement “A” and mark the pole. Then
drill a 1” diameter hole in the side of the pole
for the Manual Gas Shuto Valve.
STEP 9
In diagram 8, you are looking at a close up of the
bottom of the Tiki Torch Head. Unless a custom
conguration is requested there will be the 2 wires as
shown along with a ½” coupling.
STEP 9
Next install the Manual Gas Shuto Valve as shown in diagram 7.
A A
DIAGRAM 6
DIAGRAM 7
DIAGRAM 8
TOP TORCH
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 9
INSTALLATION THE TORCH HEAD
HOME-RUN WIRING ON MULTIPLE ELECTRONIC TORCHES
STEP 11
STEP 10
Insert the pole into the torch head.
Secure by tightening the 3 set screws
in the base of the torch head.
See diagram 10.
Attach the wires from the torch head to the 2
wires coming up inside the center of the pole. We
recommend wrapping the wires that are coming
up through the pole counter clockwise around the
gas line 3 full turns in anticipation of threading
the torch head onto the gas line.
See diagram 9
DIAGRAM 10
DIAGRAM 9
GAS LINE
GAS LINE
WIRE NUT
WIRE
NUT
COUPLING
COUPLING
HEX BOLT
ALLEN WRENCH
LOW
VOLTAGE
WIRING
HEX BOLT
TOP TORCH
THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 10
WARNING
WARNING
HOT – DO NOT TOUCH - SEVERE BURNS MAY RESULT - CLOTHING IGNITION MAY RESULT
• CAREFULLY SUPERVISE children in same area as the appliance.
• Alert children and adults to hazards of high temperatures.
• Clothing or other ammable materials should not be hung from the appliance or placed
on or near the appliance.
If re feature fails to turn o completely (small ames still visible)
Turn o gas supply using the manual gas shuto.
WARNING
Do NOT use this appliance if any part has been under water
Immediately call a qualied service technician to inspect the appliance and to replace any part of the control
system any gas control which has been under water.
OPERATION
FIRE FEATURE START UP
FIRE FEATURE SHUTDOWN
1. Prior to turning appliance on visually inspect re feature to ensure debris such as leaves or other combustible
material has not collected inside the feature which could burn and emit embers once the re feature is turned on.
Also ensure any person standing close to the re feature is aware you will be turning the re feature on prior to
actually turning it on.
2. Turn re feature on by turning on the electrical device used to power the re feature.
1. Turn re feature o by turning o the electrical device used to power the re feature.
Sequence of Operation during Ignition
• Power is applied
• Hot Surface Igniter (Glow Plug) becomes hot and 4 seconds later the Gas Valve opens
• Within 10 seconds of power application Flame should be visible (at night only)
TOP TORCH
Questo manuale è adatto per i seguenti modelli
1
Indice
Altri manuali Outdoor Plus Bruciatore
