Pentair SHURFLO Manuale utente

WATER PURFICATION 911-585 REV. E 1

SHURFLO® LO-FLO 105 SERIES RV PUMPS

INSTALLATION MANUAL

SHURFLO Lo-Flo 105 Series RV pumps are rugged, lightweight, compact and provide the ability to self-prime and run dry.

Standard features include a pressure demand switch, built in 3/8” hose barb ports, ﬂexible mounting feet, splash proof motor,

and thermal protector. All with the security that comes with a UL Recognized Component.

INSTALLATION

SHURFLO Lo-Flo 105 Series RV pumps are self-priming and can be located up to 2.5

feet above the water level. Horizontal and vertical prime vary depending on the ﬂuid

viscosity and pump conﬁguration. The pump can be at the same level or below the

tank.

❚ The pump should be located in an area that is dry and properly ventilated to pre-

vent heat build-up.

❚ Use 50-mesh strainer minimum at the inlet side of the pump. Use ﬂexible hose on

inlet.

❚ The pump can be mounted in any position. However, if mounting the pump verti-

cally the pump head should be in the down position so that in the event of a leak,

ﬂuid will not enter the motor.

❚ 12 Volt pump must be provided with a 5-amp fuse.

❚ Recommended wire size is 16 gauge (1.3 mm) or larger wire as determined by volt-

age drop. Negative (-) must be connected to a known ground. Ground wire must be

the same (gauge/mm) as the positive.

TROUBLESHOOTING

PUMP WILL NOT START

√ For correct voltage (+10%) and

electrical connections

√ Fuse or breaker

√ Pressure switch operation and

correct voltage at switch

√ Rectiﬁer or motor for open or

grounded circuit

√ For locked drive assembly

PUMP WILL NOT PRIME

(No Discharge/Motor Runs)

√ Strainer for debris

√ Inlet/Outlet tube severely restricted

(kinked)

√ Inlet /Outlet valves for debris or

swelling

PUMP WILL NOT SHUT-OFF

√ Output line closed and no leaks

√ For air trapped in outlet line or

pump head

√ For correct voltage to pump

√ Debris in pump Inlet/Outlet valves

√ For loose drive assembly or pump

head screws

√ Pressure switch operation/adjust-

ment

LEAKS FROM PUMP HEAD OR SWITCH

√ For loose screws at switch or pump

head

√ Switch diaphragm ruptured or

pinched

√ For punctured diaphragm if ﬂuid is

present at drain holes

To Faucet

City Water

Check Valve

Alternate Plumbing

for City Water Entry

From Pump

“T” Fitting

RED(+)

PUM P

SWITCH

BLACK(-)

FUSE BATTERY

50 Mesh Strainer Required if using SHURFLO P/N 170-06X-00

A 1/2” to 3/8” Barb splicer is required.

Water Tank

Plumbing Systems can vary.

Consult SHURFLO for detailed

information.

WATER PURIFICATION

3545 HARBOR GATEWAY SOUTH, SUITE 103, COSTA MESA, CA 92626, (800) 854-3218 WWW.SHURFLO.COM

All Pentair trademarks and logos are owned by Pentair, Inc. All other brand or product names are trademarks or registered marks of their respective owners.

Because we are continuously improving our products and services, Pentair reserves the right to change speciﬁcations without prior notice.

Pentair is an equal opportunity employer.

PRODUCT SPECIFICATIONS

Model Number: 105 Series

Pump Design: Positive Displacement Pump

Motor: Placement Magnet, 11-262-00

Voltage: 12 VDC

Pressure Switch: Factory Set: 30 PSI Shut-off, Turn-on 25+/- 5 PSI

Liquid Temperature: 100° Max F [43° C]

Prime: Self Priming up to 2.5 ft. vertical

Ports: 3/8" Barb

Net Weight: 1.27 lbs.

Duty Cycle: Intermittnet

Max Amps: 105-003, 2.5 Amps @ 30 PSI

MATERIALS OF CONSTRUCTION

Motor Housing: Nylon

Plastic: Polypropylene

Valves: EPDM

Diaphragm: Santoprene

Fasteners: Zinc Plated /

Stainess Steel

#10 Screw Mounting Hole

3/8” Hose Barb Port

Pressure Switch

18 AWG Red Positive

18 AWG Black Negative

5.01.70”1.55”3.94”

2.45”

1.87”

2.25”

3.20”

6.82”

FLOW: GPM [LPM]

0.30

[1.14]

0.65

[2.46]

1.00

[3.79]

[2.1]

[1.4]

[0.7]

PRESSURE: PSI [BAR]

Indice

Altri manuali Pentair Pompa dell'acqua

Pentair

Pentair HYDROMATIC PUMP VAULT Manuale

Pentair

Pentair SC Series Manuale utente

Pentair

Pentair Myers AWS-1 Manuale

Pentair

Pentair ONGA VF150 Manuale utente

Pentair

Pentair Berkeley SG11200B Series Manuale utente

Pentair

Pentair HYDROMATIC HPGX200 Manuale

Pentair

Pentair PTS Jung Multicut 08/2 ME Manuale utente

Pentair

Pentair Hydromatic S3S Manuale

Pentair

Pentair AURORA LAYNE VERTI-LINE Series Manuale utente

Pentair

Pentair OMNIA Series Manuale utente

Pentair

Pentair MYERS MCI033 Manuale utente

Pentair

Pentair HEBEFIX 100 Manuale utente

Pentair

Pentair DD Series Manuale utente

Pentair

Pentair LINCOLN POWER-MASTER III 84981 Manuale del proprietario

Pentair

Pentair SHURFLO 4008 RV REVOLUTION Manuale utente

Pentair

Pentair STA-RITE DS2 Series Manuale utente

Pentair

Pentair Hydromatic C4SP Manuale

Pentair

Pentair AURORA 654A Istruzioni operative

Pentair

Pentair Myers CMP Series Guida alla risoluzione dei problemi

Pentair

Pentair HYDROMATIC EZ OUT SYSTEM Manuale

Pentair

Pentair Berkeley LT Series Manuale utente

Pentair

Pentair Myers MDC33 Series Manuale utente

Pentair

Pentair ONGA 112 Series Manuale utente

Pentair

Pentair myers aplex Series Manuale

Manuali Pompa dell'acqua popolari di altre marche

Neptun

Neptun NPHW 5500 Manuale utente

Sensidyne

Sensidyne Gilian BDX-II Istruzioni per l'installazione e il funzionamento

Draper

Draper 47808 Manuale utente

Trolla

Trolla 12820 Manuale utente

Sunfab

Sunfab SVH Series Manuale utente

WilTec

WilTec 50740 Manuale utente

Fieldmann

Fieldmann FVC 5015 EK Manuale utente

Everbilt

Everbilt EFSUB5-122HD Manuale utente

Graco

Graco Husky 3300e Manuale utente

esotec

esotec 101018 Manuale utente

moyno

moyno 2000 CC Manuale utente

Becker

Becker BASIC VASF 2.80/1-0.AC230 Manuale utente

Sykes AmeriPumps

Sykes AmeriPumps GP100M Guida alla risoluzione dei problemi

DUROMAX

DUROMAX XP WX Series Manuale utente

BRINKMANN PUMPS

BRINKMANN PUMPS SBF550 Manuale utente

Franklin Electric

Franklin Electric IPS Manuale utente

Xylem

Xylem e-1532 Series Manuale utente

Milton Roy

Milton Roy PRIMEROYAL Manuale utente