Perle IRG7440 Manuale utente

Perle IRG7440 5G/LTE

Cellular Router

Updated: January 2022

Version A.01.23,2022

Document Part#:5500486-10

www.perle.com

Preface

Perle IRG7440 5G/LTE Cellular Router Hardware Installation Guide

Preface

Audience

This guide is for the network or computer technician responsible for installing the Perle IRG7440

5G/LTE Cellular router also generically referred to as the IRG7440 within this document. Familiarity

with the concepts and terminology of Cellular Networks, GNSS, Ethernet, and LAN (local area net-

works) is required.

Purpose

Perle routers provide users, networking equipment, as well as M2M & IoT appliances with network

connectivity for fixed locations (i.e. buildings, POS, Kiosks, …etc.) and mobile (i.e. vehicle, trains,

robots) applications. In vehicular applications, the router provides connectivity and does not interact

with the vehicle’s operation or vehicle operators.

This document describes the hardware and physical characteristics of the Perle IRG7440 Series of

Routers. It covers hardware features as well as installation and operation. This document does not

cover how to configure your Perle IRG7440 router. Information to configure your Perle router can be

found in the Perle IRG7000/5000 5G/LTE Router User’s Guide and the Perle IRG7000/5000 5G/LTE

Router Command Line Reference Guide on the Perle website. Quick Start information can be found

in the IRG7440 5G Cellular Router Quick Start Guide (QSG) that comes with your product.

Key Features

• Supports bridging/switching and routing

• Support for 5G Sub-6 GHz: n1, n2, n3, n5, n28, n41, n66, n71, n78, n79

• 4G LTE: B1, B2, B3, B4, B5, B7, B8, B12, B13, B14, B18, B19, B20, B21, B25, B26, B28,

B29, B30, B32, B34, B38, B39, B40, B41, B42, B43, B46, B48, B66, B71

• Routing with Primary/Backup route

• 5G/LTE and VPN Fail-over

• Provides network connectivity via LTE, 5G, Ethernet, and USB-C

• Active GPS for tracking equipment

• Low voltage Standby function to prevent battery drain

• One GPIO pin for remote monitoring/control and one IGN (Ignition) pin

• Two digital Inputs and one Relay contact

• RS485 half-duplex capabilities

• Security via remote authentication (Radius and TACACS+)

• Processor Power Saving Mode–this feature optimizes idle power consumption, saving

energy by reducing performance where possible

• Power Saving Features including; LED power saving mode, Smart Standby Mode, Power

saving strategies such as turning off unused interfaces (USB, Serial, Ethernet), turning off

GPS and adjusting the Ethernet rate

• Meets industry-grade certifications

Preface

Perle IRG7440 5G/LTE Cellular Router Hardware Installation Guide

Additional Documentation

Document Description

Perle IRG7000/5000 5G/LTE Router

User’s Guide

User’s guide explaining how to configure the IRG7440

features using the Web Manager application. New users

should use this method to configure the router.

Perle IRG7000/5000 5G/LTE Router

Command Line Reference Guide

Command Line Interface Reference Guide using CLI

commands to configure the IRG 7440 (this is an

advanced way to configure the router).

Preface

III

Perle IRG7440 5G/LTE Cellular Router Hardware Installation Guide

Document Conventions

This document contains the following conventions:

Most text is presented in the typeface used in this paragraph. Other typefaces are used to help you

identify certain types of information. The other typefaces are:

Note: Means reader take note: notes contain helpful suggestions.

Caution: Means reader be careful. In this situation, you might perform an action that could result in

equipment damage or loss of data.

Warning: IMPORTANT SAFETY INSTRUCTIONS

Means danger. You are in a situation that could cause bodily injury. Before you work on any equipment, be

aware of the hazards involved with electrical circuitry and be familiar with standard practices for preventing

accidents.

Important Notice

Due to the nature of wireless communications, transmission and reception of data can never be

guaranteed. Data may be delayed, corrupted (i.e., have errors) or be totally lost. Although significant

delays or losses of data are rare when cellular devices such as the Perle IRG7440 Series Routers are

used in a normal manner with a well-constructed network. The Perle IRG7440 Series Routers should

not be used in situations where failure to transmit or receive data could result in damage of any kind

to the user or any other party, including but not limited to personal injury, death, or loss of property.

Perle accepts no responsibility for damages of any kind resulting from delays or errors in data trans-

mitted or received using our products.

Safety and Hazards

The driver or operator of any vehicle should not operate the IRG7440 while in control of a vehicle.

Doing so will detract from the driver or operator's control and operation of that vehicle. The IRG7440

is Listed to UL121201 and CSA C22.2 No. 213.

The following warnings and instructions apply:

Limitation of Liability

The information in this manual is subject to change without notice and does not represent a commit-

ment on the part of Perle for any and all direct, indirect, special, general, incidental, consequential,

punitive or exemplary damages including, but not limited to loss of profits or revenue or anticipated

profits or revenue arising out of the use or inability to use any Perle IRG7440 series router even if

Perle has been advised or the possibility of such damages or they are

foreseeable or for claims by any third party.

Notwithstanding the foregoing, in no event shall Perle aggregate liability arising under or in connec-

tion with the Perle product, regardless of the number of events, occurrences, or claims giving rise to

liability, be in excess of the price paid by the purchaser for the Perle

product.

Windows® is a registered trademarks of Microsoft Corporation.

Other trademarks are the property of their respective owners

Preface

Perle IRG7440 5G/LTE Cellular Router Hardware Installation Guide

General cautions and warnings

Warning: Power sources must be off prior to beginning the power connection steps. Read the

installation instructions before you connect the unit to its power source.

Avertissement: Les sources d'alimentation doivent être éteintes avant de commencer les étapes de

connexion d'alimentation. Veuillez lire les instructions d’installation avant de connecter l’appareil à

sa source d’alimentation.

Warning: Ensure that the voltage and current ratings of the intended power source are appropriate for

the IRG7440 Series of Routers as indicated on the product label.

Avertissement: Assurez-vous que les valeurs nominales de tension et de courant de la source d'ali-

mentation prévue conviennent aux routeurs de la série IRG7440, comme indiqué sur l'étiquette du

produit.

Warning: Ensure that the installation and electrical wiring of the equipment is performed by trained

and qualified personnel and that the installation complies with all local and national electrical codes.

Avertissement: Assurez-vous que l'installation et le câblage électrique de l'équipement sont effectués

par du personnel formé et qualifié et que l'installation est conforme à tous les codes électriques locaux

et nationaux.

Warning: This equipment must be used in the matter specified by the manufacturer.

Avertissement: Cet équipement doit être utilisé dans les matières spécifiées par le fabricant.

Warning: In case of malfunction or damage, no attempts at repair should be made by the user. Do not

dismantle this product. In case of malfunction or damage, contact Perle Technical support at

https://www.perle.com/support_services/support_request.aspx

or email at

https://www.perle.com/support_services/support_request.aspx#form

Avertissement: En cas de dysfonctionnement ou de détérioration, aucune tentative de réparation ne

doit être effectuée par l'utilisateur. Ne démontez pas ce produit. En cas de dysfonctionnement ou de

dommage, contactez le support technique de Perle à l'adresse

https://www.perle.com/support_services/support_request.aspx

ou par courrier électronique à

https://www.perle.com/support_services/support_request.aspx#form

Warning: If the ambient temperature is to exceed 50°C (122°F), the unit should be installed in a

restricted access location where access can only be gained by service personnel or users who have

been instructed about the reasons for the restrictions applied to the location and about any precautions

13 IEC 60417-5041 (2002-10) Caution, hot surface

14 Refer to manual/safety

Preface

Perle IRG7440 5G/LTE Cellular Router Hardware Installation Guide

that shall be taken; and access is through the use of a tool or lock and key, or any means of security,

and is controlled by the authority responsible for the location.

Avertissement: Si la température ambiante doit dépasser 50 ° C, l'unité doit être installée dans un

emplacement à accès restreint, auquel seul le personnel de service ou les utilisateurs informés des rai-

sons des restrictions appliquées peuvent accéder. sur le lieu et sur les précautions à prendre; et l'accès

se fait au moyen d'un outil ou d'un verrou et d'une clé, ou de tout moyen de sécurité, et est contrôlé

par l'autorité responsable du lieu.

Warning: The working voltage inputs are designed for operation with Safety extra low Voltage

(SELV). Connect only to SELV circuits with voltage restrictions in line with IEC/EN 62368-1.

Avertissement: Les entrées de tension sont conçues pour fonctionner avec une tension de sécurité

très basse (SELV). Connectez uniquement aux circuits SELV avec des restrictions de tension con-

formes à IEC / EN 62368-1.

Warning: For equipment installed within the same end-product enclosure ensure leads are segregated

or insulated the leads from different circuits.

Avertissement: Pour les équipements installés dans le même boîtier de produit final, assurez-vous

que les conducteurs sont séparés ou isolés des conducteurs de circuits différents.

RF Exposure

In accordance with FCC/IC requirements of human exposure to radio frequency fields, the radiating

element shall be installed such that a minimum separation distance of 20 cm should be maintained

from the antenna and the user's body.

Conformément aux exigences de la FCC/IC relatives à l’exposition humaine aux champs de

radiofréquences, l’élément de rayonnement doit être installé de manière à ce qu’une distance de

séparation minimale de 20 cm soit maintenue par rapport à l’antenne et au corps de l’utilisateur.

THE SPECIFICATIONS AND INFORMATION REGARDING THE PRODUCTS IN THIS

GUIDE ARE SUBJECT TO CHANGE WITHOUT NOTICE. ALL STATEMENTS,

INFORMATION, AND RECOMMENDATIONS IN THIS GUIDE ARE BELIEVED TO BE

ACCURATE BUT ARE PRESENTED WITHOUT WARRANTY OF ANY KIND, EXPRESS OR

IMPLIED. USERS MUST TAKE FULL RESPONSIBILITY FOR THEIR APPLICATION OF

ANY PRODUCTS.

This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of the

FCC rules. These limits are designed to provide reasonable protection against harmful interference when the equipment is

operated in a commercial environment. This equipment generates, uses, and can radiate radio-frequency energy and, if not

installed and used in accordance with this hardware guide may cause harmful interference to radio communications.

Modifications to this product not authorized by Perle could void the FCC approval and negate your authority to operate the

product.

Perle reserves the right to make changes without further notice, to any products to improve reliability, function, or design.

Perle, the Perle logo, and IRG7440 Series of Routers are trademarks of Perle.

60 Renfrew Drive, Markham, Ontario, L3R 0E1, Canada

Preface

Perle IRG7440 5G/LTE Cellular Router Hardware Installation Guide

Publishing History

Date Revision Update Details

March 2020 A.03.23.2020 Initial release.

Dec 2020 A.12.31.2020 Updates

June 2021 A.03.06.2021 Update to label

Jan 2022 A.01.30.2022 Added IRG7440 model (5G) and updates to other

models

Table Of Contents

Preface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . I

Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

What’s Included . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

What You Need to Supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

SIM Card . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Antenna/s . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

USB-C Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Ethernet LAN Ports . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

Ethernet Link Status. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

GNSS Connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

Connecting the Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

AUX/IO . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Relay Alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Inserting the SIM card . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Connecting the 5G/LTE Antenna/s . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Connecting to the Ethernet Ports . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Connecting to the Serial Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Female Serial Pin out . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Connecting to the USB-C port in Console Mode. . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Connecting the Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

Reset / Factory Default / Safe Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

Fast Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

Managing the IRG7440 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

WebManager . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

CLI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

SNMP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

Fast Setup Mode. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

PerleView. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

Power Management . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

Power Modes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

IRG7440Fixed Installation without I/O . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

Recommended Vehicle Installation (Ignition Mode). . . . . . . . . . . . . . . . . . . . . . . . . 18

Fixed Installation with Analog Input . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

I/O Configurations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

Pulse Counter / Digital Input . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

High Side Pull-up / Dry Contact Switch Input. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

Digital Output / Low Side Current Sink . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21

Digital Output / Open Drain. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

AUX /I/O . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

Pulse Counter / Digital Input . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

High Side Pull-up / Dry Contact Switch Input. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

Relay Alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

Appendix A—Technical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

Appendix B—Sample Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29

Appendix C—Mounting the IRG7440 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

Appendix D—Mechanical . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

Appendix E—Maintaining and Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . 33

Overview

Perle IRG7440 5G/LTE Cellular Router Hardware Installation Guide

Overview

The Perle IRG7440 routers are generically referred to as the IRG7440 in this guide. The IRG7440

router is a compact, rugged, fully featured communications platform for real-time wireless capabili-

ties. It has multiple communication ports including Serial, Ethernet, and a USB port . It supports

5G/LTE wireless solutions for both fixed and mobile applications (IoT). The 5G/LTE supports peak

download rates of 4.5 Gbps and uploads speeds of 660 Mbps. It offers global coverage of frequency

bands, supports Cat-20 technology with automatic fall-back to 4G and 3G (HSPA+, UMTS) net-

works. The IRG7440 includes integrated GNSS receiver (GPS, GLONASS, Beidou, and Galileo) sat-

ellite support.

Application uses:

• Monitoring and controlling remote equipment such as pipelines, meters, pumps, and valves

in energy, utility, or industrial applications

• Tracking the location of heavy equipment and assets in the field

• Providing reliable Internet access to a mobile workforce

What’s Included

The following components may be included with your product. Components will vary depending for

each model. See the Perle website for updates.

• The router

• Quick Start Guide that came with your product

• 5G/LTE antenna pack (#08000530)

• GPIO Cable with 4 Pin plug (#2500468)

• GPIO Cable with 8 Pin plug (#2500476)

• 12VDC/2A 4 Pin (NA-#08000150, EU #08000160, UK #08000170, #08000180) power

supply

What You Need to Supply

Before you can begin, you need to have the following:

• A SIM card (provided by your mobile network operator)

• #1 Phillips screwdriver (if you are installing the SIM card)

• Computer or laptop computer with Ethernet interface and cable

• An Ethernet CAT5e or CAT6 10/100/1000BASE-T cable/to connect the

router to the network

Altri manuali per IRG7440

Indice

Altri manuali Perle Router wireless

Perle

Perle IRG5410 Series Manuale utente

Perle

Perle IRG5140+ Manuale utente

Perle

Perle P2600 Manuale utente

Manuali Router wireless popolari di altre marche

Milesight

Milesight UG67 Manuale utente

Airlogic

Airlogic AirSync Class 1 Manuale del proprietario

Samsung

Samsung WCH730B Manuale utente

TELEFONICA

TELEFONICA USB Adapter Manuale utente

NETGEAR

NETGEAR PowerLINE WiFi 1000 Series Manuale utente

Askey

Askey RAC2V1K Manuale utente

Alloy

Alloy WLF2454AP-S Manuale utente

TP-Link

TP-Link TL-WR542G Manuale utente

NETGEAR

NETGEAR WNR2000v4 Manuale utente

Hama

Hama 53120 Manuale utente

Intellinet

Intellinet 524582 Manuale utente

Asus

Asus RT-N10P Manuale utente

D-Link

D-Link DIR-506L Manuale utente

Sapido

Sapido GR297n Manuale utente

Asus

Asus DSL-N55U Manuale utente

AMTC

AMTC WR7502 Manuale utente

Compaq

Compaq CP-2W - iPAQ Connection Point Manuale utente

SMC Networks

SMC Networks WBR14-N2 FICHE Manuale utente