PondMAX PM700SB Manuale utente
SOLAR KIT
BATTERY BACKUP
INSTRUCTION MANUAL
TOLL FREE 888.868.1185
DATE
NOV 2017 v1.0
MODEL
22PS570
PMAX US Battery Backup Instructions.indd 1 30/11/17 11:16 am
WATERGARDENING TO THE MAXPONDMAX.COM
CONGRATULATIONS ON YOUR PURCHASE OF THIS
PRODUCT BY PONDMAX, THE ANSWERS FOR YOUR
WATERGARDEN MADE EASY.
TECHNICAL SPECIFICATIONS
DESIGN HIGHLIGHTS
• This Solar Battery Backup is designed to store solar energy for the PondMAX Solar Pump Kits and has
enough charge to run pump for 3-4 hours on its own.
• 1 Year Warranty
• The battery backup has built-in overcharge protection.
• LED indicator lights provide the working status of the battery backup.
• The output voltage can be adjusted in the range of 12V-24V, for optimal pump performance.
Description PM700SB
PART NUMBER 22PS570
LEAD ACID BATTERY 12V, 7AH
CHARGING VOLTAGE 12V-24V
OUTPUT VOLTAGE 12V-24V
MAXIMUM INPUT POWER 20W
MAXIMUM OUTPUT POWER 12W
SIZE 7.5" X 6" X 5"
NET WEIGHT 6.5 LBS
CABLE LENGTH 16 FT
• Do not connect the solar battery backup to any
AC voltage power for charging; it is ONLY for
DC voltage power.
• Do not leave this battery backup in bad
weather conditions or a bad ambient
environment.
• Do not leave the battery backup in direct
sunlight or expose it to extreme heat or cold
temperatures.
• Do not expose this battery backup system to
water.
IMPORTANT SAFEGUARDS
Please read these instructions and familiarize yourself with the equipment before placing it in service. Correct and
safe use of the system requires strict compliance with the safety instructions. For safety reasons persons less than 16
years of age or people that are not familiar with these instructions should not use this equipment.
PMAX US Battery Backup Instructions.indd 2 30/11/17 11:16 am
WARNING: Batteries are known to contain toxic chemicals.
NEVER DISPOSE OF A BATTERY BY THROWING IT INTO THE TRASH OR A LANDFILL.
Take it to a authorized hazardous waste service center to dispose of properly.
WATERGARDENING TO THE MAXPONDMAX.COM
SOLAR KIT
BATTERY BACKUP
INSTALLATION AND MAINTENANCE
AVAILABLE REPLACEMENT PARTS
1.
For first time use, check that the wires are connected to battery inside plastic casing and
connect if needed. You can access the battery by removing 6-Phillips head screws from
bottom side, where the lid and bottom portion of plastic casing meet.
2.
Next connect the “INPUT” cable from the battery backup to the solar panel
(provided separately with solar pump kit) and tighten the threaded connection.
3.
The "CHARGE" yellow LED indicator should illuminate when the battery begins to charge,
regardless of whether the system switch is On or Off.
4.
Now insert the pump cable to the “OUTPUT” socket on the battery backup, and tighten the
threaded connection.
5.
Then press the “System On/Off” switch to the “On” position and the "SYSTEM" green LED
indicator should then illuminate and the solar pump should start to operate. However if the
red LED illuminates while it operates for the first time, it indicates that the battery lost
charge while in inventory. In this case the battery will need to be charged for 2 to 3 hours
while the solar panel is in direct sunshine. Once its charged the green LED indicator will
illuminate to let you know that the battery is charged and the pump is ready to operate
6.
The pump will automatically stop running when the battery is at its minimal voltage, and the
"SYSTEM" indicator will be red.
7.
The "SYSTEM" indicator will stay red until the battery is recharged to its maximum voltage.
While the voltage rises, the "SYSTEM" indicator will change to flashing red-green twice
every 10 seconds. It will take another 2 hours before indicator changes back to green and
then pump will start to run again.
8.
The “Timer On/Off” switch allows the pump to operate in intermittent mode and continuous
mode. In the intermittent mode (i.e. “Timer On”), the timer will allow the pump to operate 10
minutes per hour to conserve the battery's energy, and can be especially useful during
winter or on cloudy days. When the Timer is off (continuous mode), the built-in timer is
disabled and the pump will run continuously. The Timer function is available only when the
system LED indicator shows green. NOTE: While the timer is used, the "TIMER" indicator will
be green while the pump operates and will flash green (once per second), when the pump is
not operating due to the intermittent function.
9.
The pump performance can be adjusted by the potentiometer (output voltage adjustment
knob). Adjust the potentiometer to minimal output power (operating voltage of 12V) and
the pump runs at minimal performance but with extended run-time capacity. If adjusted to
maximum output power(operating voltage of 24V), the pump runs at maximum
performance but will exhaust the battery at a faster rate, so that pump operating time will
be shorter.
10.
The battery will still charge in the daylight, even if the switch is "Off". The system will
automatically cut off the charging current when the battery is fully charged.
DESCRIPTION PART NO.
REPLACEMENT BATTERY FOR BATERY BACKUP 31SP366
REPLACEMENT PLASTIC CASING FOR BATTERY BACKUP 31SP367
PMAX US Battery Backup Instructions.indd 3 30/11/17 11:16 am
Please consult with your retailer for additional replacement parts.
Visit www.pondmax.com for your nearest dealer.
WARRANTY
• This product is warranted to the initial purchaser
to be free of defects in materials and manufacture
workmanship at the time of initial purchase and for
a period of 1 year after. Some parts are consumable
(e.g. battery) and may need to be replaced as part of
ongoing product maintenance and are not covered by
this Warranty. In the event this unit malfunctions within 1
year from the date of purchase, the sole obligation of
PondMAX™ (hereinafter referred to as PondMAX™) will
be to repair the unit or replace with an equivalent new or
factory refurbished unit at PondMAX’s discretion, subject
to the following condition:
• The malfunction is proved attributable to a defect
in materials or manufacture workmanship, including
repairs performed under this warranty. Malfunction for
any other reason including but not limited to misuse,
negligence, accident, or tampering with parts, incorrect
wiring, or improper installation-will not be remedied
under this warranty.
• PondMAX™ specifically does not guarantee chemical
compatibility, and expressly does not warrant units from
any problems caused by chemical attack or failure due to
incompatibility of fluid used near this aeration system.
• All warranty repairs must be performed by PondMAX™ or
a PondMAX™ authorized company.
• Purchaser must retain the purchase receipt and present it
with this certificate as proof of ownership and
entitlement to warranty repairs. Unauthorized repairs will
not be compensated by PondMAX™, and are not the
responsibility of PondMAX™, and if such repairs damage
the product, such damages are not remedied under this
warranty.
• Purchaser shall bear all onsite labor, shipping, packing
and insurance costs and all other costs, excluding in
house labor and parts necessary to effectuate repairs
under this warranty.
• This warranty is in lieu of all other express warranties
which now or hereafter might otherwise arise with
respect to this product. Any and all limited warranties,
including the warranties of merchantability and fitness
for particular purpose, shall have no greater duration
than the duration period of the express written warranty
applicable to this product, and shall terminate
automatically the expiration of such duration period.
• Some states do not allow limitations on how long an
implied warranty lasts, so the above limitation may not
apply to you. No action shall be brought for breach
of any implied or express warranty after one year
subsequent to the expiration of the duration period of
the express written warranty.
• Incidental and consequential damages caused by
malfunction, defect, or otherwise, and with respect
to breach of any express or implied warranty, are not the
responsibility of PondMAX™, and, to the extent
permitted by law, are hereby excluded for property
damage, loss of livestock and, to the extent not
unconscionable, for personal injury damage. Some states
do not allow the exclusion or limitation of incidental or
consequential damages, so the above limitation or
exclusion may not apply to you.
• This warranty does not apply to any malfunction arising
out of any application of this product other than normal
use, unless such application is upon request specifically
approved in writing by PondMAX™.
• The provisions of this warranty are severable and if any
provision shall be deemed invalid, the remaining
provisions shall remain in full force and effect.
• Rights under this warranty are not assignable without
the express prior consent in writing by PondMAX™ and,
regardless of the terms of such consent in writing, such
assignee shall have no greater rights than his assignor
had against PondMAX™.
Please consult your retailer for quality original PondMAX replacement parts.
Visit www.pondmax.com for your nearest dealer.
PONDMAX USA
Toll Free 888.868.1185
email: info@pondmax.com
www.pondmax.com
PMAX US Battery Backup Instructions.indd 4 30/11/17 11:16 am
TROUBLESHOOTING
If the SYSTEM indicator shows RED and the pump does not work even though the solar module is in full
sunlight, please check the possible failures below:
1.The CHARGE yellow indicator doesn’t light - Check connection to the solar module.
2. The battery is out of its service life and needs to be replaced - Replace the battery (Part No. 31SP366)
If the SYSTEM indicator is GREEN but the pump still doesn't work, please check possible options below:
1. Check if the “Timer On/Off” switch is on. Please note, in this mode, the pump runs intermittently.
2. The pump is blocked, clean the pump by referring to pump manuals.
Questo manuale è adatto per i seguenti modelli
1
Indice
Altri manuali PondMAX Accessori per fotocamere
