Priefert LOG22 Manuale utente

ASSEMBLY& OPERATING INSTRUCTIONS

LS123-806-0909

Rev 0

THIS SAFETY ALERT SYMBOL IDENTIFIES IMPORTANT SAFETY MESSAGES IN THIS MANUAL

Owner’s Manual

MODEL NO. LOG22

22 TON

MODEL NO. LOG28

28 TON

MODEL NO. LOG34

34 TON

VERTICAL/HORIZONTAL

LOG SPLITTERS

Table of Contents

Page(s)

Important Safety Information................................................................................................................. 1-6

Intended Use ......................................................................................................................... 1

Personal Protective Equipment ............................................................................................... 1

Safety Decals ....................................................................................................................... 1-2

General Safety ...................................................................................................................... 3

Preparation of the Log ........................................................................................................... 3

Work Area ........................................................................................................................... 3

Operation of the Log Splitter .................................................................................................. 3-4

Repair and Maintenance Safety ............................................................................................. 4

Hydraulic Safety .................................................................................................................. 5

Fire Prevention ..................................................................................................................... 5-6

Towing Safety ...................................................................................................................... 6

Assembly Instructions ...................................................................................................................... 7-19

LOG22 ................................................................................................................................ 7-9

LOG28 ................................................................................................................................ 11-13

LOG34 ................................................................................................................................ 16-19

Operating Instructions ....................................................................................................................... 22-23

Engine Oil Recommendations ................................................................................................ 22

Starting Instructions ............................................................................................................... 22

Towing .................................................................................................................................. 23

Operation .............................................................................................................................. 9

Maintenance ...................................................................................................................................... 23

Parts Lists .........................................................................................................................................

LOG22 ................................................................................................................................. 9-10

LOG28 ................................................................................................................................. 14-15

LOG34 ................................................................................................................................. 20-21

Notes ................................................................................................................................................ 24

Specifications .................................................................................................................................. Back Cover

WARNING: Read and thoroughly understand all instructions and safety information before assembling

or operating this log splitter. Failure to do so may cause serious injury or death. Do not allow anyone

to operate this log splitter who has not read this manual. As with all power equipment a log splitter

can be dangerous if assembled or used improperly. Do not operate this log splitter if you have doubts

or questions concerning safe operation. Call our customer service department at 1-800-527-8616 to

address these concerns.

Si no entiende ingles, se prefiere que busque alguien que interprete las instrucciones para usted.

NEVER use this log splitter for any other purposes than splitting wood. It is designed for this use only.Any other use can

cause serious injury or death.

PEPER

PERPERSONALSONAL PROTECTIVE EQUIPMENT

BEFORE operating this log splitter make sure that you wear safety gear such as goggles or safey glasses, steel toed

shoes and tight fitting gloves (without loose cuffs or draw strings). Always wear a protective hearing device when operat-

ing this log splitter.

NEVER wear loose clothing or jewelry that can be caught by moving parts of the log splitter. Keep clothing and hair away

from all moving parts when operating this log splitter.

PERSONAL PROTECTIVE EQUIPMENT

SAFETY DECALS

Make sure that all safety warning decals are in good condition and readable. Always replace missing or defaced decals.

Write us or call 1-800-527-8616 and they will be sent to you at no charge.

DL-52-8

DL52-2-8

INTENDED USE

Page 1

PARTNUMBER: 52020000

LOCATION: TOP, FRONT END OF TONGUE

Page 2

PARTNUMBER: 51018900

LOCATION: TOP OF HYDRAULIC CYLINDER

PARTNUMBER: 52023200

LOCATION: HYDRAULIC TANK

LOWER TANK, RIGHT CORNER

PARTNUMBER: 52055200

LOCATION: TOP, FORWARD

SECTION OF CYLINDER AND

SIDES OF STRIPPER PLATES

GENERAL SAFETY

EVER

NEVER allow children or adults lacking proper instructions and understanding to operate this log splitter.

KEEP all people and pets a minimum of 10 feet away from your work area when operating this log splitter. Only the

operator is to be near the log splitter during use.

If a helper is assisting in loading logs, NEVER actuate the control until the helper is clear of the work area.

NEVER operate the log splitter when under the influence of alcohol, drugs or medication.

NEVER allow a person who is tired or otherwise not alert to use your log splitter.

PREPARATION OF THE LOG

Both ends of the log should be cut as square as possible to help prevent the log from riding out of the splitter during

operation. Do not split logs greater than 26 in. in length.

WORK AREA

NEVER operate the log splitter on slippery, wet, muddy or icy ground.

ONLYoperate your log splitter on level ground. Operating on a slope could cause the log splitter to roll over or logs to fall

off.

NEVER operate your log splitter in an enclosed area. Exhaust fumes contain carbon monoxide which can be deadly when

inhaled.

NEVER attempt to move your log splitter over hilly or uneven terrain without a tow vehicle or adequate help.

ALWAYS block the wheels to prevent movement of the log splitter while in operation.

ONLYoperate your log splitter in daylight or under good artificial light.

ALWAYS keep the work area clean. Remove split wood around your log splitter immediately so that you don’t stumble

over it.

OPERATION OF THE LOG SPLITTER

ONLY operate the log splitter from the operator zone* as

shown in the diagrams. The operator has the safest and

most efficient access to the control valve and beam in

this

location. Failure to operate the log splitter in this location

can result in serious injury or death.

*Shown in horizontal position Page 3

Failure to follow these instructions may result in serious injury or death.

Operator

Zone LOG22 MODEL

ENGINE

TONGUE

BEAM

FOOT PLATE ENGINE

BEAM

TONGUE

Operator

Zone

LOG28 & LOG34

MODELS

KNOW how to stop the log splitter and disengage the controls before operating it.

NEVER place hands or feet between the log and splitting wedge during forward or reverse stroke. Serious injury or death

could result.

NEVER straddle or step over the log splitter during operation.

NEVER reach or bend over the log splitter to pick up a log.

NEVER try to split two logs on top of each other.

NEVER try to cross split a second log.

NEVER allow one person to operate the valve while another is positioning the log.

NEVER attempt to load your log splitter when the ram or wedge is in motion.

ALWAYS use your hand to operate the control lever on the valve. NEVER use your foot, a rope or any extension device.

NEVER move the log splitter while the engine is running. Shut off the engine even if you are leaving the log splitter for a

short period of time.

ALWAYS avoid contact with the muffler and other hot areas of the engine during operation to prevent burns.

REPAIR AND MAINTENANCE SAFETY

NEVER operate your log splitter when it is in poor mechanical condition or in need of repair.

Periodically check that all nuts, bolts, screws, hydraulic fittings and hose clamps are tightened.

NEVER alter your log splitter in any manner such as adding a rope or extenstion to the control lever or adding to the

width or height of the wedge. Such alterations may cause your log splitter to be unsafe and will void the warranty.

Perform all recommended maintenance procedures before using your log splitter.

Replace all damaged or worn parts immediately.

NEVER tamper with the engine to run it at excessive speeds. The maximum engine speed is preset by the manufacturer

and is within safety limits.

ALWAYS remove the spark plug wire before performing any service or repair on your log splitter.

ALWAYS check the level of hydraulic oil and engine oil before operation.

ALL replacement parts must meet manufacturer’s specifications.

Page 4

HYDRAULIC SAFETY

The hydraulic system of your log splitter requires careful inspection along with the mechanical parts. Be sure to

replace frayed, kinked, cracked or otherwise damaged hydraulic hose and components.

NEVER check for leaks of hydraulic fluid with your hand. Fluid escaping from a small hole can be almost invisible.

Escaping fluid under pressure can have sufficient force to penetrate skin causing serious personal injury or even death.

Leaks can be detected by passing a piece of cardboard over the suspected leak and looking for discoloration.

ALWAYS seek professional medical attention immediately if injured by escaping hydraulic fluid. Serious infection or

reaction can develop if proper medical treatment is not administered immediately.

ALWAYS be sure to relieve all pressure by shutting off the engine and moving the valve control handle back and forth

should it become necessary to loosen or remove any hydraulic fitting.

NEVER remove the cap from the hydraulic tank or reservoir while the log splitter is running. Hot oil under pressure

could result in serious injury.

NEVER adjust the hydraulic valve. The pressure relief valve on your log splitter is preset at the factory. Only a qualified

service technician should perform this adjustment.

FIRE PREVENTION

NEVER operate your log splitter near a flame or spark. Hydraulic oil and gasoline are flammable and can explode.

NEVER fill the gas tank while the engine is hot or running. Allow the engine to cool before refueling.

NEVER smoke while operating or refueling your log splitter. Gas fumes can easily explode.

ONLYrefuel your log splitter in a clear area with no gas fumes or spilled gas.

ALWAYS use an approved fuel container.

ALWAYS replace the gas cap securely.

If gasoline has spilled, move the log splitter away from the area of the spill and avoid creating any source of ignition

until the spilled gas has evaporated.

ALWAYS take a Class B fire extinguisher with you when operating this log splitter in dry areas as a precautionary

measure against possible flying sparks.

ALWAYS drain the fuel tank prior to storage to avoid the potential fire hazard.

ALWAYS store gasoline in an approved, tightly sealed container. Store the container in a cool, dry place.

NEVER store gasoline in the house or near a heating appliance.

Page 5

IMPORTANT NOTE:

This log splitter is equipped with an internal combustion engine and should not be used on or near any unimproved

forest-covered, brush-covered or grass-covered land unless the engine’s exhaust system is equipped with a spark ar-

rester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained in efffective

working order by the operator. In the state of California a spark arrester is required by law. Other states have similar laws.

Federal laws apply on federal lands. Aspark arrester muffler (optional by manufacturer) is available as an accessory at

your nearest engine dealer. Always check the legal requirements in your area.

TOWING SAFETY

ALWAYS check all local and state regulations regarding towing, licensing, and lights before towing your log splitter.

ALWAYS check before towing to make sure that the log splitter is correctly and securely attached to the towing vehicle

and that the safety chains are secured to the hitch or bumper of the vehicle with enough slack to allow turning. Always

use a Class I, 2” ball with this log splitter.

NEVER carry any cargo or wood on your log splitter.

NEVER allow anyone to sit or ride on your log splitter.

ALWAYS disconnect your log splitter from the towing vehicle before operating it.

ALWAYS be careful when backing up with your log splitter in tow. It could jackknife.

ALWAYS allow for added length of your log splitter when turning, parking, crossing interesections and in all driving

situations.

NEVER exceed 45 mph when towing your log splitter. Towing the log splitter at speeds higher than 45 mph could result in

loss of control, damage to the equipment, serious injury or death. Adjust towing speed for terrain and conditions. Be

extra cautious when towing over rough terrain especially railroad crossings.

Page 6

ASSEMBLYINSTRUCTIONS LOG22

NOTE: This log splitter was partially assembled at the factory. Refer to the drawings and parts list should it become neces-

sary to disassemble the unit for repair or replacement of parts

1401411B22 Beam Assembly 1

2401193B22 Tank/Engine Assembly 1

3400312B0 Tire and Wheel assembly 2

440126300 Tongue Assembly 1

40115500 Hardware Kit 1

STEP 1: Remove all the components from the shipping container.Inspect each piece for shipping damage. If any part is

damaged, contact your dealer or delivering carrier.

STEP 2: Attach the two wheels (2) to the tank assembly (1) wheel spindles using the 3/4” light flat washers(3) ,3/4” NF

slotted nuts (4), 1/8” x 1-1/2” cotter pins (5) and the hub caps (6). These items are in the hardware package.

Tighten the slotted nuts and make sure the wheels rotate freely.

ITEM NO. PART NO. DESCRIPTION QTY.

1401193B22 Tank Assembly 1

2400312B0 Wheel Assembly 2

3O/L 3/4” Light Flatwasher 2

417012000 3/4” Slotted Nut 2

5O/L 1/8*’ x 1-1/2” Cotter Pin 2

640033200 Hub Cap 2

Page 7

O/L- Obtain locally. Common fasteners available through hardware

and farm stores.

STEP 3: Attach the tongue assembly (5) to the tank assembly (4) using two 1/2” NC x 4-1/2” hex cap bolts (1), two 1/2” lock

washers (2) and two and two 1/2” hex nuts. Tighten. (3).Tighten.

ITEM NO PART NO. DESCRIPTION QTY.

1O/L 1/2”NC x 4-1/2” Bolt 2

2O/L 1/2” Lock Washer 2

3O/L 1/2” NC Hex Nut 2

4401193B22 Tank Assembly 1

540126300 Tongue Assembly 1

STEP 4: Stand the beam (1) up on end. Two people may be needed for this step to ensure safety. Make sure that the beam

is stable and on a level surface.Remove the pivot pin (2) and clip pin (3) from the tank assembly.Roll the tongue/

tank assembly into position between the two tabs on the beam (1). Slide the pivot pin (2) through the aligned holes

and lock in place with the clip pin (3)

ITEM NO. PART NO. DESCRIPTION QTY.

1401411PB Beam 1

2071022WC Pivot Pin 1

3O/L 1/2”-3/4” R Clip Pin 1

Page 8

O/L- Obtain locally. Common fasteners available through hardware

and farm stores.

O/L- Obtain locally. Common fasteners available through hardware

and farm stores.

Questo manuale è adatto per i seguenti modelli

Indice

Manuali Spaccalegna popolari di altre marche

Bell

Bell Pickpine VS S9 Manuale di istruzioni

ATIKA

ATIKA ASP 5 N-UG Istruzioni operative

Posch

Posch Schälprofi 500 Manuale utente

Champion

Champion 91520 Manuale

Fieldmann

Fieldmann FZLS 1008V-E Manuale utente

Craftsman

Craftsman 247.28775 Manuale utente

Scheppach

Scheppach OX 3-1000 Istruzioni per il montaggio

Swisher

Swisher 21200 Manuale utente

Elem Garden Technic

Elem Garden Technic FBHT65-22TCH Manuale utente

Champion Power Equipment

Champion Power Equipment 90720 Manuale

Boss Industrial

Boss Industrial ES5T20 Manuale utente

Villager

Villager LSP 12 T Manuale utente

MTD

MTD 242-642A Manuale utente

Rok

Rok 150-51-50255 Manuale utente

Hakki Pilke

Hakki Pilke Raven Manuale utente

Swisher

Swisher LSRB11534 Manuale utente

Hyundai

Hyundai HYLS7TE Manuale utente

Scheppach

Scheppach HL1500M Guida utente