Purkeys DIRECT FLEX Guida all'installazione

DIRECT FLEX/MAX

DIAGNOSTIC GUIDE

300-51 R1.00

P: 479.419.4800 | F: 479.419.4801 | www.purkeys.net

CONTENTS

Direct Flex (no severe service cables)..............................................................2

Direct Max (includes severe service cables) ...................................................3

Cover Assembly..................................................................................................4

Interior Light Module (optional) .....................................................................5

Connections Inside Nosebox ..................................................................5

Connections Outside Nosebox ...............................................................6

Basic Troubleshooting .......................................................................................7

No Lights on Face of the Nosebox..........................................................7

Batteries Not Being Charged ...................................................................9

Interior Lights Not Working (if installed) ...........................................15

Limited Commercial Warranty Policy...........................................................17

DIRECT FLEX

(NO SEVERE SERVICE CABLES)

P: 479.419.4800 | F: 479.419.4801 | www.purkeys.net

FLEX/MAX DIAGNOSTIC GUIDE

DIRECT MAX

(INCLUDES SEVERE SERVICE CABLES)

COVER ASSEMBLY

P: 479.419.4800 | F: 479.419.4801 | www.purkeys.net

FLEX/MAX DIAGNOSTIC GUIDE

INTERIOR LIGHT MODULE (OPTIONAL)

CONNECTIONS INSIDE NOSEBOX

CONNECTIONS OUTSIDE NOSEBOX

P: 479.419.4800 | F: 479.419.4801 | www.purkeys.net

FLEX/MAX DIAGNOSTIC GUIDE

NO LIGHTS ON FACE OF THE NOSEBOX

Step 1: Conrm all connections are tight and inspect wiring for defects.

Step 2: Connect the tractor to the unit.

Step 3: Start the tractor.

Step 4: Check the 2 amp fuse on the

DC/DC converter in the battery

box:

• If blown, replace.

• If good, proceed.

Step 5: Using a voltmeter, measure

the voltage at the 2-pin terminal

strip on the DC/DC converter

charging plate:

• Place the positive lead on the

ligate battery+ stud.

• Place the negative lead on the

ground stud.

• If there is a battery voltage

reading, skip to step 7.

• If no voltage is shown, proceed

to step 6.

BASIC TROUBLESHOOTING

NOTE: Battery voltage below 7 volts will NOT power the system.

Step 6: Check the 30 amp circuit

breaker using a voltmeter:

• Place the positive lead on

the circuit breaker stud that

connects to the red junction

stud closest to the DC/DC

converter on the plate.

• Place the negative lead on the

negative post of the battery.

• If there is a battery voltage

reading, proceed to the next

step.

• If no voltage is shown, reset the

circuit breaker.

• If there is still no voltage, check

wiring for defects.

• If no defects are found, replace

the circuit breaker.

Step 7: On the front of the trailer,

remove the hardware holding the

cover assembly to the nosebox

base.

• Place the voltmeter positive

lead where the orange wire is

connected.

• Place the negative lead where

the white wire is connected.

• Check the battery voltage

reading.

• If there is a battery voltage

reading, replace the faceplate

assembly.

• If there is no voltage reading,

inspect the wiring for defects

and repair any issues.

Questo manuale è adatto per i seguenti modelli

Indice

Altri manuali Purkeys Caricabatterie per batterie

Purkeys

Purkeys SOLAR BOLT Manuale utente

Purkeys

Purkeys SOLAR BOLT Manuale utente

Purkeys

Purkeys SELECT Guida all'installazione

Purkeys

Purkeys DIRECT PLUS Guida all'installazione

Purkeys

Purkeys Liftgate Double Check Manuale utente

Purkeys

Purkeys SELECT Manuale utente

Purkeys

Purkeys BOSS-01 Manuale utente

Purkeys

Purkeys Select P1020-K Manuale utente

Purkeys

Purkeys DIRECT Guida all'installazione

Purkeys

Purkeys DIRECT PLUS Manuale utente

Purkeys

Purkeys DIRECT-03 Manuale utente

Manuali Caricabatterie per batterie popolari di altre marche

AA Portable Power Corp

AA Portable Power Corp Universal Smart Charger Manuale utente

Enelion

Enelion Vertica Manuale utente

RCA

RCA CHU6 Manuale utente

ANSMANN

ANSMANN ALCT 6/24-10 Manuale utente

Hitachi

Hitachi UC 18YRSL Guida alla risoluzione dei problemi

Olympus

Olympus B-20 LPC Manuale utente

Exibel

Exibel ZH1708143 Manuale utente

Lenmar

Lenmar Mach 1 Manuale utente

CTEK

CTEK MXS 5.0 Manuale utente

ABB

ABB HT842379 Manuale utente

Nitecore

Nitecore Superb Charger SC4 Manuale utente

Renogy

Renogy RBC2125DS-21W Manuale utente

Braun

Braun BWC02M Manuale utente

CTEK

CTEK MXS 3.6 Manuale utente

Black & Decker

Black & Decker BDV090 Manuale utente

Trinity

Trinity DPD Manuale utente

Hulkman

Hulkman Sigma 1 Manuale utente

IKEA

IKEA koppla Manuale utente