Quickie IRIS TRANSIT Manuale utente
ENGLISH
A. REAR TRANSIT BRACKET INSTALLATION
NOTE– The occupant must be removed from the IRIS for this installation.
1. Remove the original Rear Strut
a. Using a 3/16” or1/4” Hex key, remove the screws (A) holding the rearmost
strut tube (B) to the rocker frame(C).
2. Place the new Transit Strut
a. Position the Transit Strut included in your kit and proceed to Step 3
3 Install the Rear Transit Brackets for a standard dual-post back
a. Using the 3/16” hex key, assemble the parts as shown and thread the 5/16”
button head screw (D) through the hardware and into the strut tube (B).
b. Make sure the Wave Washer is in the correct location (G)
b. Repeat this process for the opposite side of the chair.
c. Tighten both buttion head screws holding the transit brackets (E) to the frame.
Torque to 80 in-lb.
4. Install the Rear Transit Brackets for a single-post back (OPTIONAL)
a. Using the 3/16” hex key, assemble the pars as shown and thread the 5/16” button
head screw through the hardware and and rocker (C) into the nylock nut (F).
b. Make sure the Wave Washer is in the correct location (G)
c. Repeat this process for the opposite side of the chair.
d. Tighten the hardware using a 1/2” open wrench and 3/16” hex key.
Torque to 80 in-lb.
1
2
0
15
15
30
30
45
TORQUE !TORQUE !
3
1
1. Parts included in this Transit Kit:
a. 2x Rear Transit Loops
b. 2x Front Transit Bracket
c. 2x 5/16” Button Head (rear)
d. 2x 1/4-20 Button Head (Front)
e. 2x Bushings and Washers (rear)
f. 4x washer & 2x wave washer
g. 2x 5/16” Nylock nut (rear)
h. 2x 1/4-20 Nylock nut (Front)
i. 1x Transit Strut (fixed or adj)
2. Tools needed:
a. 1/4” hex key
b. 3/16” hex key
c. 1/2” open end wrench
d. Torque Wrench with Standard hex bits.
IRIS TRANSIT
INSTALLATION
1
2
Please read these instructions carefully before beginning the installation. Failure to understand and follow installation instructions
may result in injury to installer and/or end user and may void the warranty.
If you have any questions call Sunrise Medical Technical support at 800-333-4000
B
A
C
E
3
0
15
15
30
30
45
TORQUE !
TORQUE !
D
B
C
F
G
G
2
SUNRISE MEDICAL
TRANSIT KIT INSTALLATION IRIS
B. FRONT TRANSIT BRACKET INSTALLATION
1. Assemble and Place the Front Transit Bracket
a. Place the front transit bracket (A) on the frame location (B) and insert
the hex head screws(C) through the washers into the rocker frame.
b. Slide the washers (D) on the hex head screw and hand tighten the nylock
nuts (E).
c. Finish by tightening the hex-head screws (C) to a maximum torque of
about 120 in-lb.
d. Repeat this process for the other side of the wheelchair.
C. TRANSIT STICKERS
1. The placement of Transit hook location stickers is essential for the safety
of the rider and compliance with WC-19 standards.
a. Peel the backing from the Front Transit Hook decals and place them on
each side of the chair in the location shown in Figure 5.
b. Peel the backing from the Rear Transit Hook decals and place them on
both sides of the chair in the location shown in Figure 6.
C. Peel the backing from the WC-19 Transit decals and place them on both
sides of the chair in the location shown in Figure 6.
D. CHECKOUT
1. Double-check Orientation and Torque on all Hardware.
a. Check that front and rear transit brackets have been installed evenly.
b. Using a torque wrench, check front and rear screws for correct torque.
DEALER/TECHNICIAN WARNING
WARNING
Attention dealers and qualified technicians, do not operate or service this wheel-
chair without first reading the owners manual. If you do not understand the instruc-
tions and warnings in the owners manual please contact the Quickie Technical
Service Department before operating and/or servicing the Quickie wheelchair.
Failure to do so may result in damage and/or injury.
IMPORTANT– Please see the QZ IRIS owner’s manual, and the WC-19
Transit supplement included with this kit, for additional
warnings and information.
65
4
0
15
15
30
30
45
TORQUE !
TORQUE !
6
4
C
A
5
©2014 Sunrise Medical (US) LLC
4.15 IS00140 Rev.A
Customer Service: 800.333.4000
www.SunriseMedical.com
Sunrise Medical • 2842 Business Park Ave. • Fresno, CA 93727 • USA
In Canada (800) 263-3390
B
D
E
Indice
Altri manuali Quickie Attrezzature mediche
