Rayence 1417WCE Guida

PART II. Service Manual

1417WCE

User & Installation Manual

Service Manual

1417WCE

R-DHF-USM-048

Version: 1.2

PART II. Service Manual

Date: 2023-02-17

1417WCE

Preface

Please note that this information is for proper use and safety of the equipment. The following

symbols may indicate a hazardous situation in which, if not heeded, may result in serious injury

or even death to the user or others, or damage to the equipment.

Used to emphasize essential information.

Be sure to read this information to avoid incorrect operation.

WARNING

Indicates warning and safety instructions. If not adhered to, it could result in death or

serious injury to the user or others.

CAUTION

Indicates a hazardous situation which, if not heeded, may result in minor or moderate

injury to the user or others, or damage to the equipment.

For users in the United States:

United State federal law restricts this equipment to be used by or on the order of a

physician.

Since the X-ray exposure condition can be changed depending on the age, gender and

bone density of the patient, in case of Pediatric, X-ray exposure condition can be changed

by expert’s judge. For further information, please refer to FDA Pediatric X-ray Imaging

webpage.

http://www.fda.gov/radiation-

emittingproducts/radiationemittingproductsandprocedures/medicalimaging/ucm298899.htm

For users in other countries:

This equipment is to be used by or on the order of a licensed person under the related laws

for each country.

Intended use:

Digital Flat Panel X-Ray Detector is indicated for digital imaging solution designed for general

radiographic system for human anatomy. It is intended to replace film or screen based

radiographic systems in all general purpose diagnostic procedures. Not to be used for

mammography.

VATECH Global France SARL

49 Quai de Dion Bouton, AVISO A 4ème étage, 92800 Puteaux, FranceTel :

+33 1 64 11 43 30 Fax : +33 1 64 11 43 39

Rayence Co., Ltd.

14, Samsung 1-ro 1-gil, Hwaseong-si, Gyeonggi-do, Korea

www.rayence.com

Contents

1417WCE 5

Contents

PART I. User & Installation Manual 7

1. Safety Information ........................................................................................8

1.1 Safety Standard ...................................................................................8

1.2 Symbols ............................................................................................ 15

1.3 Warning ............................................................................................ 17

1.4 Caution ............................................................................................. 20

1.5 Safety Information ............................................................................. 28

1.6 Label and Location of Attachment........................................................ 30

1.7 Summary of usability specifications...................................................... 30

2. Product Introduction and Specification .......................................................... 31

2.1 Product Features ................................................................................ 31

2.2 Product Components .......................................................................... 32

2.3 Part Names and Functions................................................................... 33

2.4 Part Specifications .............................................................................. 38

2.5 Environmental Requirements............................................................... 41

2.6 Dimensions (Unit: mm)....................................................................... 42

3. Installation and Calibration .......................................................................... 45

3.1 Installation ........................................................................................ 45

3.2 Calibration ......................................................................................... 61

4. Usage ........................................................................................................ 67

4.1 Set Up............................................................................................... 67

4.2 Image Acquisition............................................................................... 69

4.3 View Images...................................................................................... 71

4.4 Additional Function............................................................................. 73

5. Maintenance............................................................................................... 88

5.1 Cleaning............................................................................................ 88

5.2 Inspection ......................................................................................... 88

5.3 Replaceable Parts and Instruction of Replacement................................. 89

5.4 Disposal or Recycling .......................................................................... 90

6. Warranty .................................................................................................... 91

6.1 Warranty ........................................................................................... 91

PART II. Service Manual 92

1. Overview.................................................................................................... 93

2. FPD Manager Instruction (IP, SSID Set Up / Firmware, FPGA Update) .............. 94

2.1 Detector IP Address Set Up................................................................. 94

Contents

6 1417WCE

2.2 SSID, PSK (Pre-Shared Key) Set Up ..................................................... 96

2.3 Firmware, FPGA Update...................................................................... 98

2.4 Set Windows Firewall to use FPD_Manager (For Win 7)....................... 100

3. Multi Detector Set Up.................................................................................102

4. Troubleshooting.........................................................................................107

4.1 LAN Connection Issue ...................................................................... 107

4.2 Lost IP Address (Use one of the methods below)................................ 110

4.3 When using a reciprocating bucky ..................................................... 110

4.4 Auto Trigger Mode ........................................................................... 112

Supplement 1. Wireless AP Set Up Instruction..........................................................114

PART I. User & Installation Manual

1417WCE 7

PART I. User & Installation Manual

1. Safety Information……………………………………. 7

2. Product Introduction and Specification............258

3. Installation and Calibration ............................4545

4. Usage ..............................................................6767

5. Maintenance ...................................................8888

6. Warranty .........................................................9191

PART I. User & Installation Manual

8 1417WCE

1. Safety Information

1.1 Safety Standard

1.1.1 Medical Device Fification

Item Description

Classification by protection type against Electric

Shock Class I or Internally Powered Equipment

Classification according to the degree of

protection against ingress of water IP67

Mode of operation Continuous Operation

Environment of Use This equipment is not suitable for use in the

presence of flammable anesthetic or oxygen.

IP67 does not mean completely waterproof, so use with caution. If the connector is

contaminated with liquids or foreign substances, clean and dry it sufficiently before use.

If you operate the equipment outside of recommended operating conditions, the

equipment may be damaged. This damage is not covered by warranty.

1.1.2 Regulations

1. Safety and Electromagnetic Compatibility Information

Item Description

IEC/EN/UL 60601-1 Medical electrical equipment

Part 1: General requirements for safety

IEC/EN 60601-1-2 Medical electrical equipment

Part 2: Electromagnetic compatibility-requirements and tests

This equipment has been tested and found to comply with the limits for medical devices in IEC

60601-1-2. These limits are designed to provide reasonable protection against harmful

interference in a typical medical installation.

This equipment generates, uses and can radiate radio frequency energy. If not installed and

used in accordance with the instructions, it may cause harmful interference to other devices in

the vicinity. However, there is no guarantee that interference will not occur in a particular

installation. If this equipment does cause harmful interference to other devices, which can be

determined by turning the equipment off and on, the user is encouraged to try to correct the

interference by one or more of the following measures.

Reorient or relocate the equipment.

Increase the separation between the equipment.

Connect the equipment into an outlet on a circuit different from that to which the other

devices are connected.

Contact Rayence Customer Service team or authorized agent for help.

PART I. User & Installation Manual

1417WCE 9

2. Radio Frequency compliance

FCC (For USA)

•FCC ID: QIIRYRWM001A

•5.15- 5.25 GHz band is restricted to indoor operations only.

•Host device of the approved module shall be marked with the following item:

•Compliance with FCC requirement 15.407(c)

Data transmission is always initiated by software, which is the passed down through the

MAC, through the digital and analog baseband, and finally to the RF chip. Several special

packets are initiated by the MAC. These are the only ways the digital baseband portion will

turn on the RF transmitter, which it then turns off at the end of the packet. Therefore, the

transmitter will be on only while one of the aforementioned packets is being transmitted. In

other words, this device automatically discontinues transmission in case of either absence

of information to transmit or operational failure.

This device complies with part 15 of the FCC Rules. Operation is subject to the following

two conditions: (1) This device may not cause harmful interference, and (2) this device

must accept any interference received, including interference that may cause undesired

operation.

FCC CAUTION

Changes or modifications not expressly approved by the party responsible for compliance

could void the user’s authority to operate the equipment. This transmitter must not be co-

located or operated in conjunction with any other antenna or transmitter.

When installing it in a mobile equipment

This equipment complies with FCC radiation exposure limits set forth for an uncontrolled

environment and meets the FCC radio frequency (RF) Exposure Guidelines in

CFR §2.1093.

When you use the detector with wire mode, the wireless function is automatically off.

•5150-5250 MHz band is restricted to indoor operations only.

This equipment has been tested and found to comply with the limits for a Class B digital

device, pursuant to part 15 of the FCC Rules. These limits are designed to provide

reasonable protection against harmful interference in a residential installation. This

equipment generates, uses and can radiate radio frequency energy and, if not installed and

used in accordance with the instructions, may cause harmful interference to radio

communications. However, there is no guarantee that interference will not occur in a

particular installation. If this equipment does cause harmful interference to radio or

television reception, which can be determined by turning the equipment off and on, the user

is encouraged to try to correct the interference by one or more of the following measures:

- Reorient or relocate the receiving antenna.

- Increase the separation between the equipment and receiver.

- Connect the equipment into an outlet on a circuit different from that to which the receiver

is connected.

- Consult the dealer or an experienced radio/TV technician for help.

PART I. User & Installation Manual

10 1417WCE

IC Notice (For CANADA)

IC: 10742A-RWM001A

This Class A digital apparatus complies with Canadian ICES-003

This device complies with Industry Canada licence-exempt RSS standard(s). Operation is

subject to the following two conditions: (1) this device may not cause interference, and (2)

this device must accept any interference, including interference that may cause undesired

operation of the device.

Le present appareil est conforme aux CNR d'Industrie Canada applicables aux appareils

radio exempts de licence. L'exploitation est autorisee aux deux conditions suivantes: (1)

l'appareil ne doit pas produire de brouillage, et (2) l'utilisateur de l'appareil doit accepter

tout brouillage radioelectrique subi, meme si le brouillage est susceptible d'en

compromettre le fonctionnement.

RED Notice (European Union)

The product compliance to the Directive 2014/53/EU as Radio Equipment.

5150-5250 MHz band is restricted to indoor operations only.

3. Electro-Magnetic Compatibility Information

Do not use mobile phones in the vicinity of this device. Use of mobile phones near this

device can cause errors in operation due to electromagnetic wave interference, so such

devices should be turned off in the vicinity of this device.

The use of accessories and cables other than those sold by RAYENCE Co., Ltd. as internal

components, may result in increased emissions or decreased electromagnetic immunity of

this device.

Do not use this device adjacent to or stacked with other devices. If adjacent or stacked use

is necessary, confirm normal operation in the configuration in which this device will be used.

Cable

Item Length Unit

Link cable (Shielded) 7 m

LAN cable (Shielded) 10 m

Power cord (3-Wire No Shielding) 1.8 m

USB cable (A to B type) 1.8 m

Trigger cable (Rayence I/F Cable) 10 m

P-interface cable (Rayence I/F Cable) 8 m

Indice

Altri manuali rayence Sensore di sicurezza

rayence

rayence 1417WGC Guida

Manuali Sensore di sicurezza popolari di altre marche

THORLABS

THORLABS PDA10JT Manuale utente

Waeco

Waeco UV-DETECT Manuale utente

Intermatic

Intermatic IOS-DSIMF Manuale utente

urmet domus

urmet domus 1083 Manuale utente

Siemens

Siemens AZL66 Series Manuale utente

BTI

BTI Profiline Multi Finder Manuale utente

Challenger

Challenger SL01 Manuale utente

DMP Electronics

DMP Electronics 1122INT Manuale utente

Rielta

Rielta Ladoga MK-RK Manuale utente

Mirion Technologies

Mirion Technologies ACCURAD PRD Manuale utente

Bosch

Bosch DS835 Manuale utente

DBI SALA

DBI SALA EZ Stop Manuale dell'operatore

Lamptime

Lamptime ST05C Manuale utente

Ubiquiti

Ubiquiti MFI-MSC Manuale utente

Subsite

Subsite 910R Istruzioni per l'installazione

Satel

Satel OPAL Pro Manuale utente

Aleph

Aleph XC-1XTEU Manuale utente

Pima

Pima LARIS QUAD Manuale utente

rayence 1417WCE Guida

Manuali Sensore di sicurezza popolari di altre marche