Rollplay W488 Manuale utente

Mercedes Benz GL (W488)

Customer Service Guide

2

Customer Service Guide

Contents

I) Check Battery …………………………............................................. 3

II) Check Wiring Condition ……………………………..………………………. 5

III) Check Foot Pedal ………………………………………………………….….... 12

IV) Gearbox Replacement …………………………………………..…………… 14

V) Door Replacement .…………………………………..…….……..….………. 17

VI)Motor Control Board Replacement .….………..…….……..….………. 19

VII) Headlight Replacement .….……………………...…….……..….………. 21

VIII) Schematic diagram ……………..…………….…..….………..……………. 22

IX) Exploded View …………..………………..…....….……….……..…….…… 23

CAUTION :

Disconnect the battery before proceeding.

3

Customer Service Guide

I) Check Battery

Operation: Using a Flat head screwdriver, unlock and remove the seat. Locate the battery

harness, unplug the connector, and use a volt-meter to check battery condition

at battery side.

Step (1)

Turn and unlock this plastic knob according to the icon

Step (2)

Unplug the battery connector (red) by holding down

the small clip and pulling apart.

4

Customer Service Guide

I) Check Battery

Step

(3)

Voltage Reading: 6.0 V ~ 6.5 V –Good condition

5.6 V ~ 5.9 V –Proceed to Recharge

5.5 V –Battery to be recharged if after the stipulated

recharging time, voltage has not increased,

the Battery needs replacement

Below 5.5 V –Battery needs replacement

5

Customer Service Guide

II) Check Wiring Connection

Operation: Disconnect and reconnect all plugs and connections leading to the drive board

shown below.

A. Motor/Gearbox : Follow above (Point I) to remove the seat, locate the Gearbox

harness underneath.

Customer Service Guide

VI)Motor Control Board Replacement

Operation: Follow above (Point I) to remove the seat first and replace the Motor Control

Board (MCB) by below steps.

Customer Service Guide

Re-Coding Remote Control

Follow the below steps if;

1: Replacing the receiver/drive board module in the vehicle or

2: Remote control function is not operating as it should.

Note: The remote coding button should be held down for 5 seconds & then hold down

the receiver/module reset coding button for 5 seconds.

7

Customer Service Guide

II) Check Wiring Connection

C. Dashboard : Remove the Steering Wheel and Dashboard to check the connection.

Step (1)

Unscrew then pull up & out to remove steering wheel

Step (2)

Next, unscrew these two screws to remove the dashboard

8

Customer Service Guide

II) Check Wiring Connection

Step (3)

Pull up & out to remove the dashboard and windshield

together as one unit.

Step (4)

Check the 4-Pin plug

9

Customer Service Guide

II) Check Wiring Connection

D. Shifter : Follow steps above to remove the Dashboard, then check the connection

of Shifter and Main Power Switch as well.

Step (1)

Unplug this connector

Step (2)

Unscrew these four screws to remove the Windshield

Indice

Altri manuali Rollplay Auto giocattolo motorizzata

Rollplay

Rollplay 12V Chevrolet Silverado Manuale utente

Rollplay

Rollplay MINI COOPER S Foot To Floor Manuale utente

Rollplay

Rollplay FLEX KART XL PEDAL Istruzioni per il montaggio

Rollplay

Rollplay BMW i8 Concept Spyder Manuale utente

Rollplay

Rollplay W483RAC Istruzioni per il montaggio

Rollplay

Rollplay 6V Chevy W460 Manuale utente

Rollplay

Rollplay 6V BMW X5 Manuale utente

Rollplay

Rollplay 6V Mini Quad ACQUAD-P Istruzioni per il montaggio

Rollplay

Rollplay W461P-02 Istruzioni per il montaggio

Rollplay

Rollplay W463 Istruzioni per il montaggio

Rollplay

Rollplay Audi R8 Spyder Istruzioni per il montaggio

Rollplay

Rollplay W495NB Istruzioni per il montaggio

Rollplay

Rollplay Mini Cooper S Manuale utente

Rollplay

Rollplay W466AC-R Istruzioni per il montaggio

Rollplay

Rollplay W488AC Istruzioni per il montaggio

Rollplay

Rollplay Dino AR Explorer Manuale utente

Rollplay

Rollplay BMW i8 Concept Spyder Manuale utente

Rollplay

Rollplay 6V Chevy Tahoe Police SUV Istruzioni per il montaggio

Rollplay

Rollplay Nighthawk NexGen W502 Istruzioni per il montaggio

Rollplay

Rollplay Turnado W401E Manuale utente

Rollplay

Rollplay Mini Cooper S Istruzioni per il montaggio

Rollplay

Rollplay W48912AC-F Istruzioni per il montaggio

Rollplay

Rollplay 12V GMC Sierra Denali Istruzioni per il montaggio

Rollplay

Rollplay 6V Porsche 918 Istruzioni per il montaggio

Manuali Auto giocattolo motorizzata popolari di altre marche

Eduard

Eduard Humber Scout Car Mk.I exterior Manuale utente

Traxxas

Traxxas 4995X Manuale utente

Jamara

Jamara VW T1 Bus Manuale utente

REVELL

REVELL 68 CHEVY CHEVELLE SS 396 Manuale utente

Schumacher

Schumacher Pro Cat Manuale utente

Tamiya

Tamiya TT-01 TYPE E Manuale utente

Eduard

Eduard Krupp Protze 6x4 1/48 Manuale utente

New Bright

New Bright 61072UEP Manuale utente

Team Durango

Team Durango DEX410v5 Manuale utente

Jamara

Jamara Mercedes Actros Muldenkipper 2,4 GHz Manuale utente

PLAYMOBIL

PLAYMOBIL 9536 Manuale utente

Atomic

Atomic BZ3 Manuale utente

Aiyaplay

Aiyaplay 370-290V00 Manuale utente

Power Wheels

Power Wheels GRJ53 Manuale utente

ZEROTRIBE

ZEROTRIBE Zetricks ZT1144 Manuale utente

INJUSA

INJUSA 412 Manuale utente

Maverick

Maverick MSC-30BR-WP Manuale utente

Land of B.

Land of B. Rollin' Riders Manuale utente