Speed Queen SLW570RAW Manuale

Speed Queen RDomestic WasherTechnical Information

August 2000 RT3100015 Rev. 01

120 V, 60 Hz Models

SLW570RAW PSLW570RAW

•Due to possibility of personal injury or property damage, always contact an authorized technician for servicing or

repair of this unit.

•Refer to Service Manual RS3100007 for detailed installation, operating, testing, troubleshooting, and disassembly

instructions.

•Refer to Parts Manual RP3100017 for part number information.

CAUTION

All safety information must be followed as provided in this Technical Sheet and in Service Manual RS3100007.

WARNING

To avoid risk of electrical shock, personal injury, or death, disconnect power to unit and discharge capacitor

before servicing, unless testing requires it.

Models SLW570RAW Models SLW570RAW

Power Source Wash cyles 12

Voltage AC 120 VAC Water temperatures 4

Amperage (Single Unit) 10 A Water level Variable

Frequency 60 Hz Features

Motor horsepower 1/2 Steady SpinBalance System X

Receptacle 6-20R Self-cleaning lint filter X

Plug 6-20P Self-adjusting rear leveling legs X

Dimensions 210 Agitation stroke X

Cabinet Tri−Actionwash system X

Height−overall 43” Fabric softener dispenser X

Height of cabinet 36” Extra rinse X

Width 27” Motor speed 2 speed

Depth 28” Spin speed (revolutions per minute) 640 / 427 rpm

Clearance−washer lid 17 1/2” Agitation speed (strokes per minute)

Weight High 69 spm

Crated 193 lbs. Medium 46 spm

Component Testing Information

WARNING

To avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless

testing requires it.

RT3100015 Rev. 0 August 20002

Illustration Component Test Procedure Results

40046601

L1 L2

Temperature switch Disconnect wires from component to

properly measure the resistance of the

component.

Place switch in the following positions

and measure across the terminals

below:

Hot / Cold L1-2

Warm / Warm L1-1, L1-2, L2-2

L2-1, L2-L1, 1-2

Warm / Cold L1-1, L1-2, 1-2

Cold / Cold L1-1

>1 Ω

40097701 Mixing valve Measure resistance of terminals on

each valve.

Resistance across each valve. Approximately 1000 Ω±10%

40073901 Timer Verify input and output voltage is

present.

Verify wiring is correctly connected to

the timer.

See timing sequence chart for functional

description of the component.

40055101

Pressure switch Do not disconnect the pressure hose

from pressure switch to perform

measurements.

Measure resistance across the

following terminals on the pressure

switch:

Terminal 1 to 2

Terminal 1 to 3

Refer to wiring diagram/schematic for

correct contacts.

Air pressure that actuates switch is

determined by the water level of the

tub.

Continuity (no pressure)

Continuity (pressure)

40035001 Lid switch−SPST Disconnect wire terminals from switch.

Test terminals with switch closed.

Test terminals with switch open. Continuity >1 Ω

Infinite 1 MΩ

Component Testing Information

WARNING

To avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless

testing requires it.

August 2000 3 RT3100015 Rev. 0

Illustration Component Test Procedure Results

038424W Rocker switch

(Extra Rinse) Measure resistance of switch

positions:

Closed (ON position)

Open (OFF position)

Continuity >1 Ω

Infinite 1 MΩ

R0000014 Brake pad kit If washtub does not stop spinning

within seven seconds after opening

loading door.

If brake pads make noises.

Replace all three brake pads.

Apply a thin layer of silicone (26594P) on

pads, see Service Bulletin

“ASQ−213−B”

40095001 Motor Type of motor:

Two speed See following section “Internal Motor

Diagram and Schematic” for correct

wiring contacts.

40040301 Drain pump Verify drain pump is not clogged or

damaged. Remove clog and verify proper operation.

Replace drain pump if damaged.

40065301 Transmission

assembly Type of transmission:

640 rpm Externally identical, must be identified by

part number.

If transmission locks-up, replace.

40053602 Drive belt Type of drive belt:

640 rpm

Refer to “Parts Manual” for proper

pulley size.

Refer to “Parts Manual”, to verify which

drive belt and pulley size is required.

Internal Motor Diagram and Schematic

WARNING

To avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless

testing requires it.

RT3100015 Rev. 0 August 20004

Continuity exists between switch

terminal Rand Red wire.

Manually depress actuator.

Continuity broken between

switch terminal Rand Red wire.

Continuity exists between switch

terminal Pand Red wire.

Manually depress actuator.

Continuity broken between

switch terminal Pand Red wire.

Inoperative start switch.

Replace switch.

Inoperative high speed

switch. Replace switch.

Continuity broken between

switch terminal Pand Violet wire.

Manually depress actuator.

Continuity exists between switch

terminal Pand Violet wire.

Inoperative low speed

switch. Replace switch.

Motor switch checks OK.

YES

Start

Terminals

High Speed

Terminals

Low Speed

Terminals

One or Two Speed Motors

4-5 ohms between Brown wire

and Red wire.

1-2 ohms between Blue wire and

Yellow wire.

1-2 ohms between Yellow wire

and Violet wire.

Continuity exists between Yellow

wire and White wire.

All motor windings checks OK.

Inoperative start winding.

Replace motor.

Inoperative high speed winding.

Replace motor.

Inoperative low speed winding.

Replace motor.

Inoperative common lead.

Replace motor.

Start

Winding

High Speed

Winding

Low Speed

Winding

Protector

YES

Internal Motor Diagram and Schematic

WARNING

To avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless

testing requires it.

August 2000 5 RT3100015 Rev. 0

Wire harness

connection

block

WhiteBrown

Blue Yellow

Violet

Red

RUN

START

Red

Blue

Yellow

Brown

White

4P M

6P M

Aux.

Overload

protector

Yellow

Violet

Motor Assembly

(two speed motor)

Wiring Diagram and Schematic

WARNING

To avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless

testing requires it.

RT3100015 Rev. 0 August 20006

24 L2

PNK/BLU

4N.O.

PNK/BLU

WHT/BLK

GRY/BLK

BLU/WHT

WHT/RED

BRN

VLT

10 BLUK

A14

16 PNK

EXTRA RINSE

SWITCH

BLK/PNK

GRY

HOUSING

CONNECTION

DIAGRAM

RED/BLK

BLU/BLK

24 PIN

TIMER

H20

21 RED L1 1

4 POSITION

TEMP. SWITCH

ORG

CONTROL HOOD

GROUND TO

PNK/BLU

VLT

COM.

SWITCH

LID

SWITCH

PRESSURE

BLU 7

BLU

WHT

BRN 5

VLT

BRN

WHT

PNK 7PNK

WHT/RED

GRN/YEL

3MOTOR

HOUSING

GROUND TO

GRN/YEL

CABINET

WHT/RED

GRN/YEL

WHT/RED

GRN/YEL

GROUND

TO TOP GRY

ORG

PLUG

RECEPTACLE

GRY

ORG

MIXING VALVE

NATURAL

RED

HOT COLD

GRN

CONNECTOR

GROUND TO

18 GA.

BLK WHT

TOP

RIDGE OR TINNED TERMINAL = NEUTRAL

CORD

POWER

TM WHT/BLK

PNK

Wiring Diagram and Schematic

WARNING

To avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless

testing requires it.

August 2000 7 RT3100015 Rev. 0

BP EXTRA RINSE SWITCH

SPIN

HIGH

AGITATE

START 4

HOT

COLD

SPRAY RINSES = COLD

WARM

4 POSITION WATER

TEMP. SWITCH

COLD

HOT L1-2

L1-1

L1-1-2

WARM

WARM L1-L2-1-2

MOTOR

TIMER

SCHEMATIC

TIMER BUSS

INDICATES INTERNAL

3LOW MOTOR

N.O.

SWITCH

LID

120 VOLTS A.C. 60 HZ

PRESSURE SWITCH

MIXING VALVE

L1 L2

WATER TEMP.

4 POSITION

SWITCH

Timer Cycle Chart

WARNING

To avoid risk of electrical shock, personal injury, or death, disconnect power to washer before servicing, unless

testing requires it.

RT3100015 Rev. 0 August 20008

BLU/

WHT

WHT/

BLU/

RED

BLK

TMHI

AEX

1012 11

24 23

RED 22

PINK

BLK/

21 RED/

BLK

GRY

18 17

BRN

PNK

VLT

15 14

BLU

89 WHT/

BLK

231

SWITCH

FUNCTION

EXTRA

RINSE

PARTNO. 40101801

TIMERCHART

WIRE POSITION

24 PIN HOUSING

DTERM

IDENT

BLU

PNK/

REGULAR WASH

SOAK PRE-

WASH DELICATE

PERMANENT

PRESS EXTRA

RINSE EXTRA

RINSE HAND

WASH

AGITATE

PRESSURE SW, BYP

EX. RINSE ENABLE

FILL

AGITATE

WASH

COLD WATER

LO MOTOR

RINSE

TM-LO

V-W

P-V

V-R

F-L

F-K

G-L

G-K

SPIN

A-EX

A-BP

A-PS

TM-HI

HI-MOTOR

DEGREES

190

170

180

160

140

150

130

110

120

100

300

310

290

270

260

250

240

220

230

280

210

200

350

360

330

340

320

LO MOTOR

HOT WATER P-H

TM-LO

SOAK

WASH:

FILL &

AGITATE

F A

I G

L I

L T

& T

D G

R I

Y T

WASH:

FILL &

AGITATE

PNK WHT/

BLK

LOTM

PNK/

BLU

BLK

GRY/

13121189761054312 30

3027 282625 292422 232120191815 16 1714 4745 4644434241403938373634 35333231 52 53 5451504948

CONTACTS CLOSED

CONTACTS OPEN

THIS MACHINE MANUFACTURED

UNDER ONE OR MORE OF THE

FOLLOWING PATENTS:

UNITED STATES NO: 3,253,874;

3,838,755; 3,8453642

CANADIAN NO: 1,008,265;

994,685

OTHER PATENTS PENDING

Failure to install, maintain, and/or

operate this machine according to

manufacture's instructions may

result in conditions which can

produce bodily injury and/or

property damage.

Indice

Altri manuali Speed Queen Rondella

Speed Queen

Speed Queen SCN060G2 Istruzioni per l'installazione

Speed Queen

Speed Queen 803236R2 Manuale utente

Speed Queen

Speed Queen EX325 Manuale utente

Speed Queen

Speed Queen EX325 Guida rapida

Speed Queen

Speed Queen 802757R4 Manuale utente

Speed Queen

Speed Queen TR3 Manuale dell'operatore

Speed Queen

Speed Queen Super 20 CL8761 Manuale utente

Speed Queen

Speed Queen 802759 Manuale utente

Speed Queen

Speed Queen AWN412 Manuale utente

Speed Queen

Speed Queen AWNE92SP Manuale utente

Speed Queen

Speed Queen HA3000 Manuale utente

Speed Queen

Speed Queen CL9161 Manuale utente

Speed Queen

Speed Queen 20 lb Manuale utente

Speed Queen

Speed Queen AWNE92 Manuale utente

Speed Queen

Speed Queen DA3001 Manuale utente

Speed Queen

Speed Queen AWNA62SN305AW01 Manuale utente

Speed Queen

Speed Queen SA4710 Guida rapida

Speed Queen

Speed Queen LWS05 Manuale utente

Speed Queen

Speed Queen LWS11 Manuale utente

Speed Queen

Speed Queen SWTY20WN Manuale utente

Speed Queen

Speed Queen LTSA0AWN Manuale utente

Speed Queen

Speed Queen SWNMN2PP112TW01 Manuale utente

Speed Queen

Speed Queen SCN080GF Istruzioni per l'installazione

Speed Queen

Speed Queen AWS17NW Manuale utente

Manuali Rondella popolari di altre marche

Tricity Bendix

Tricity Bendix AW 1000 W Guida del prodotto

Panasonic

Panasonic NA-F60L5WRB Manuale utente

GE WSLP1500 Manuale

Electrolux

Electrolux EWF1284EDW Manuale utente

Bosch

Bosch WAN2829BSN Manuale utente

LG TV2516DV3B Manuale utente

LG TH2517DSAV Manuale utente

VESTEL

VESTEL CMH-XL 7510 TE Manuale utente

AEG

AEG 74335 Manuale operativo

Johnson

Johnson JWF721A Manuale utente

Beko

Beko WTE7604XLW0 Manuale utente

Danby

Danby DTT100A1WDB Istruzioni per il montaggio

Amica

Amica WA 14 Ex Manuale utente

Daewoo

Daewoo DWD-F1222 Manuale utente

Bosch

Bosch WAS28461AU Manuale utente

Miele

Miele PW 6080 Vario Manuale utente

Finlux

Finlux FLX108CF220 Manuale utente

Whirlpool

Whirlpool 3LBR5132AN0 Manuale utente