Storage Canopy C4080S Manuale utente

SHELTER

ASSEMBLY MANUAL

Model # W12xL24xH 4.5m

C4080S Container Shelter

SPECIFICATION

Width:12m Length:24m Height:4.5m

IMPORTANT-----READ MANUAL FIRST

Improper site preparation, Assembly and Maintenance may invalidate warranty and cause

unnecessary and costly mistake. If you have any questions contact your local dealer.

For User Friendly assembly we have identified each individual component with the part code as

indicated in the parts list. Please refer to the part code numbers and drawing to ensure problem

free assembly.

It’s necessary to tighten the roof fabric enough to avoid “hammocks” on the roof and also

re-tighten once or twice again after a few months of use. This is important when assembly in cold

weather (autumn and winter) because the fabric is stiff then and when we got the sun and warm

weather afterwards it will make the fabric “slack” again and need to be re-tighten before next

winter.

It’s the owners responsibility to take of snow immediately if not slide off by itself.

READ ALL INSTRUCTIONS BEFORE ASSEMBLY

1. Keep work area clean. Cluttered areas invite injuries. Do not set up near snow drifts, in

slippery places, in high winds, or wet location.

2. Keep children away. All children should be kept away from the work area.

3. Don’t over reach. Keep proper footing and balance at all times.

4. Do not assemble in under the influence of alcohol or drugs. Read warning labels on

prescriptions to determine if your judgment or reflexes are impaired while taking drugs. If

there is any doubt, do not assemble.

5. Be aware of possible windy conditions; fasten the bases in concrete if these conditions are

likely to occur. Remove the cover during hurricane.

6. Be careful with power and heat sources. Do not keep heat sources near the tarpaulin. Do not

expose to open flame.

7. Be aware of personal safety during assembly and use. Be careful not to pinch fingers with

clips and tubes when assembling: when using makes sure there is adequate ventilation for

exhaust and other dangerous fumes.

Parts List

Part Code

Description

Qty

Top Bent Tube

Side Bent Tube

Lower Bent Tube

Purlin

Top Tension Device

Clips

Left Base Plate

Right Base Plate

Ratchet

Nylon band for ratchet

Tensioning Tube

2 Groups

Bolts M8x70

176

11A

Bolts M12x30

132

Bolts M10x80

Roof Cover

Knitting Rope for Cover

Plastic Plug

Angle iron

Angle iron for base plate

EQUIPEMNT AND TOOLS FOR INSTALIATION

1. Measuring tape

2. String for alignment

3. Step ladder

4. Welder

5. Sledge hammer

6. Wrench

7. Scissors

INSTALLATION PROCESS

A—BASE INSTALLATION

Please refer to the diagram (Figure 1) to place the base plates.

Figure 1

1. The measurement is from center to center of the tubes. Referring to the above diagram and

confirm the place of the base plates. ENSURE THAT THE FOUNDATIONS IS SQUARE.

2. All the base plates should be welded on the Containers.

Figure 2 Sketch Frame

B—FRAME INSTALLATION

Figure 3

Figure 4

C—ROOF COVER INSTALLATION

NOTE: DO NOT install the cover onto the frame of your building in high wind conditions. A

slight breeze is the most advantageous for cover installation. To take advantage of the breeze,

pull the cover up over the arches with breeze blowing in the cover like a sail filled with air.

Figure 5

Figure 6

Please check the below installation detailed pictures:

(A) (B)

NOTE: DO NOT LEAVE THE ROOF COVER UNATTACHED UNDER ANY

CIRCUMSTANCES until the final assembly and tightening has been completed.

The process is quite easy. But some tightening adjustments will be necessary to produce a

flat, tensioned roof cover. Please adjust the roof cover every month.

Please Note:

Please use the tape wrapped around the gap between the steel

skeleton after installing.

Indice

Altri manuali Storage Canopy Riparo

Storage Canopy

Storage Canopy C4040DTR Manuale utente

Storage Canopy

Storage Canopy FB406021DP Manuale utente

Storage Canopy

Storage Canopy C2640R Manuale utente

Storage Canopy

Storage Canopy C4020 Manuale utente

Storage Canopy

Storage Canopy FB408021DP Manuale utente

Storage Canopy

Storage Canopy 26x40x10 Container Shelter Single truss Manuale utente

Storage Canopy

Storage Canopy 40x40x15 Manuale utente

Storage Canopy

Storage Canopy C6040S Manuale utente

Storage Canopy

Storage Canopy C2620 Manuale utente

Storage Canopy

Storage Canopy DT Container shelter Manuale utente

Storage Canopy

Storage Canopy C3340 Manuale utente

Storage Canopy

Storage Canopy C4040R Manuale utente

Storage Canopy

Storage Canopy C3340R Manuale utente

Storage Canopy

Storage Canopy C3340DTPR Manuale utente

Storage Canopy

Storage Canopy C3340 Manuale utente

Storage Canopy

Storage Canopy C4040S Manuale utente

Storage Canopy

Storage Canopy C4060DTR Manuale utente

Storage Canopy

Storage Canopy FB335017P Manuale utente

Storage Canopy

Storage Canopy W33 x L40 x H12 ft Manuale utente

Storage Canopy

Storage Canopy 40x60x15 ST Container shelter Manuale utente

Storage Canopy

Storage Canopy Two Car Garage Shelter Manuale utente

Storage Canopy

Storage Canopy C604015S Manuale utente

Storage Canopy

Storage Canopy SHELTER Manuale utente

Storage Canopy

Storage Canopy C2620R Manuale utente

Manuali Riparo popolari di altre marche

Tempo Fitness

Tempo Fitness S11 Manuale utente

Tuindeco

Tuindeco 42.7906 Manuale utente

No Butts Bin

No Butts Bin SR1605 Manuale utente

TMG

TMG TMG-DT5040CG Manuale utente

TMG

TMG TMG-DT3063-PRO Manuale utente

EAGLE CLAW

EAGLE CLAW Shappell DX4000 Manuale utente

Kampa

Kampa Poled Shelter 300 Manuale utente

Harnois

Harnois TA-R Manuale utente

Shelters4Less

Shelters4Less SR1551 Manuale utente

TMG

TMG TMG-DT50FW8 Manuale utente

Vikre Handel AS

Vikre Handel AS JIT-1216 Manuale utente

VARNA buildings

VARNA buildings C2020H Manuale utente

Frabill

Frabill ICE HUNTER 195 Manuale utente

Shelters4Less

Shelters4Less SR1588 Manuale utente

Sealey

Sealey Power Products GSS150819SD Manuale utente

Crivit

Crivit 104155 Manuale utente

No Butts Bin

No Butts Bin SR1558-F Manuale utente

TMG

TMG TMG-ST3040C Manuale utente