Theben Timeguard BoostMaster DS3HD Manuale

IP65 Time

Delay Switch

Model: DS3HD - White

Installation & Operating Instructions

WARNING: Isolate from supply before

removing this cover

DS3HD

IP65 Time Delay Switch

Press to Start

L - MAINS LIVE IN (right hand position of

connector)

SL - MAINS LIVE OUT (TO EXTERNAL LOAD)

(second from right hand position of connector)

EARTH – Connect any Earth wires to this pin

N– NEUTRAL (IN) (fourth from right hand position

of connector)

N– NEUTRAL (OUT) (ﬁfth from right hand position

of connector)

• NOTE: Ensure that all screws on the mains

connector are tightened adequately.

• Adequatelytightenthenutsonthecableentry

 pointsontheoutsideofthebox.

• Selecttherequiredtimedelaybyusingthetime

 delayselectorasshownbelow.

• Screwthefrontpanelbackon.Ensuretighttting

for IP compliance

• Switchonmainssupply.Theunitisnowreadyfor

operation.

4. Internal Delay Selection Switches

FourinternalDILswitchesareavailabletoselect8

timedelaysettingsasshownbelow.

Please Note: On the DIL switch, switch 1 is not in use

Time (minutes) Switch 4 Switch 3 Switch 2

2 L L L

5 L L R

10 L R L

30 L R R

60 R L L

90 R L R

120 R R L

 180 R R R

Left = ON Right = OFF

ON ON ON ON ON ON ON ON

2 mins 5 mins 10 mins 30 mins 60 mins 90 mins 120 mins 180 mins

Drainholespositionsareshownbelow.Thedrain

holesmustbedrilledoutusinga5mmdrill.Opening

the drain hole will reduce the IP rating of the

product.

Four xing holes

Four

drain

holes

Knock outs for cable conduit entry

3 Year Guarantee

Intheunlikelyeventofthisproductbecomingfaultydue

to defective material or manufacture within 3 years of the

date of purchase, please return it to your supplier in the first

yearwithproofofpurchaseanditwillbereplacedfreeof

charge. For years 2 and 3 or any difficulty in the first year

telephone the helpline on 020 8450 0515.

1. Technical Specications

ConformstoDirectives: 73/23/EEC&89/336/EEC

Operating Voltage: 230V 50Hz

Switching Capacity: Incandescent: 16A

Fluorescent: 16A

Resistive: 16A

Motor: 1hp

Operating temperature: -10°C to +40°C

Timingrange: 2minuteto180minutes

   in8steps

Timing accuracy: +/- 2%

Enclosure: Flame-resistant

   polycarbonatematerial.

IP rating: IP 65

Dimensions:  94mmx94mmx57mm

Terminals:  Suitablefor1.5mm2to

4mm2

1. General

The DS3HD is a time delay switch designed to

switchonanexternallyconnectedloadtomains

supplywhenthepushbuttonispressed.Itwill

then automatically switch off the load after a time

delayhaselapsed.Thetimedelaycanbeselected

bythreeinternalDILswitchestogive8different

timedelays.Thetimedelaycanbecancelledatany

timebypressingthepushbuttonagaininwhich

casetheblueLEDwillashandtheloadwillbe

disconnected after one minute.

DS3HD IP65 Time Delay Switch

Figure 1 - Front Panel of DS3HD

Illuminated push button

WARNING: Isolate from supply before

removing this cover

DS3HD

IP65 Time Delay Switch

Press to Start

2. Functional Description

ThereisasingleblueLEDilluminatedpushbutton

switch on the front panel. When pressed, the

DS3HD will function as follows:

• TheblueLEDwillturnoff.

• Anexternallyconnectedloadwillbeswitchedon

for the selected time delay.

• Oneminutebeforetheendofthetimedelay,the

 blueLEDwillash.

• Attheendofthetimedelay,theexternally

 connectedloadwillbeswitchedofffrommains

supply.

• TheblueLEDwillswitchpermanentlyonuntilthe

 pushbuttonispressedagain.

• Ifthepushbuttonispressedwhenthetimedelay

 isstillrunning,thedelaywillbeterminatedafter

1 minute.

• Ifthepushbuttonispressedinthelastminuteof

 thetimedelay(whenthebluelightisashing)

 thecountdownwillberesetandthetimerwill

restart the time delay.

3. Mounting and Installation

Warning: Switch off mains electricity

before proceeding with installation.

IMPORTANT NOTICE:

• Thisproductshouldbeinstalledinaccordance

with the current IEE and Wiring Regulations.

• Ifindoubtconsultaqualiedelectrician.

• Donotusethemainssupplyconnectorforwiring

 continuity.Mainsinputmustbesuppliedfromits

own 16 Amp MCB.

Figure 2 - Internal of DS3HD

Four PCB mounting screws

Knock outs for cable glands

Four xing

holes

Push

button

switch

connector

Time

delay

selector

Four xing

holes

Mains

supply

input and

output

connector

• Removefrontpanelbyunscrewingthefour

 xingscrews.

• Ifnecessary,carefullyremovetheprintedcircuit

 board(PCB)byundoingthefourPCBmounting

screws.

• Removeknockoutsat(preferably)thebottomof

 thebox.

• UseappropriateIP65ratedentryconduitstot

M20knockouts.EnsuretightttingforIPcompliance.

• Fixsurfacemountboxrigidlytoasecuresurface

 byusingappropriatescrewsthroughthefour.

 xingholes.

• RetthePCBbackontothesurfacemountbox

 byprogressivelytighteningeachofthefourPCB

mounting screws in turn. Do not over tighten

the screws

• Ensuringthatthemainswiresareadequate

 fortherequiredloadcutthecabletailstothe

appropriate lengths.

• Insertmainswiringthroughcableconduits.

• Connectthemainswirestothemains

connector as follows:

Figure 3 - Mains supply connector

Neutral Neutral in Earth Live out Live in

Designed in the U.K. 67-058-381

Timeguard Limited.

Victory Park, 400 Edgware Road,

London NW2 6ND

Sales Ofce: 020 8452 1112

or email csc@timeguard.com

or email helpline@timeguard.com

Designed in the U.K. 67-058-381

Timeguard Limited.

Victory Park, 400 Edgware Road,

London NW2 6ND

Sales Of ce: 020 8452 1112

or email csc@timeguard.com

For a product brochure please contact:

Zerofour – September 2010

or email helpline@timeguard.com

HELPLINE

020 8450 0515

Indice

Altri manuali Theben Timer

Theben

Theben SELEKTA 171 top2 RC 24 V Manuale utente

Theben

Theben TR top2 Series Manuale utente

Theben

Theben SELEKTA 171 Top3 RC Manuale utente

Theben

Theben TR 611 top3 Manuale utente

Theben

Theben SYN 161 h Manuale utente

Theben

Theben SELEKTA 171 Top3 RC Manuale utente

Theben

Theben SUL 181 h Manuale utente

Theben

Theben TR 644 S Manuale utente

Theben

Theben SIMPLEXA 601 Manuale utente

Theben

Theben SIMPLEXA 601 top Manuale utente

Theben

Theben TR 652 S Manuale utente

Theben

Theben TR 611 top2 RC 24 V Manuale utente

Theben

Theben TIME GUARD TGBT4 Manuale

Theben

Theben TR 635 top2 Manuale utente

Theben

Theben SYN 161 d Manuale utente

Theben

Theben TR 610 top3 Manuale utente

Theben

Theben SYN 161 d Istruzioni per l'installazione

Theben

Theben SELEKTA 175 top2 Manuale utente

Theben

Theben Timeguard NTT05 Manuale

Theben

Theben TR 611 top3 Manuale utente

Theben

Theben Timeguard SupplyMaster FST24 Manuale

Theben

Theben SYN 169 s Manuale utente

Theben

Theben termina tr 611 top2 Manuale utente

Theben

Theben SELEKTA 170 top3 Manuale utente

Manuali Timer popolari di altre marche

Intermatic

Intermatic P1131 Manuale utente

Learning Resources

Learning Resources Time Tracker mini Manuale utente

CEBEK

CEBEK I-215 Manuale utente

Somogyi

Somogyi home TS MD 5 Manuale utente

Profile

Profile 010200280 Manuale utente

Gizmo

Gizmo T4 Manuale utente

Tekmar

Tekmar Timer 031 Manuale utente

Daikin

Daikin DST301B61 Manuale utente

sisel

sisel ENDA ETM2432 Manuale utente

B&Q

B&Q TE103 Manuale operativo e di manutenzione

Hozelock

Hozelock AC Plus 2700 Manuale utente

GIC

GIC Eliro V7DDSS3Eliro V7DFTS3 Manuale utente

Tork

Tork TU40 Manuale utente

Emos

Emos EMT400F Manuale utente

FarmTek

FarmTek Polaris Manuale utente

Maximum

Maximum CRONUS Manuale utente

Uberhaus

Uberhaus TD133B Manuale utente

Clas Ohlson

Clas Ohlson 31-3766 Manuale utente