Tomcat VR Manuale utente
Operating Instructions (EN)
Read these Instructions before
using the machine.
Read these Safety Messages
before using the machine.
COMMERCIAL CLEANING EQUIPMENT
www.tomcatequip.com
1711 South Street
Racine, WI 53404 (USA)
(800) 450-9824 | (+001) 262-681-6470 VERSION 15.246
©2015 RPS Corporation VR-OP-EN
- 2 - TR-OP-EN
INTRODUCTION
This manual is furnished with each new machine. This manual will allow the Operator to get the best performance out of
your RPS manufactured Scrubber-Drier, Sweeper, Burnisher, or Orbital Scrubber. Read this manual thoroughly before
operating or servicing the machine.
This machine will provide excellent performance, but the best results will be obtained at the most minimum costs if:
• The machine is regularly maintained - per the machine Preventative Maintenance instructions provided.
• The machine is operated with reasonable care and caution.
• The machine is maintained with manufacturer supplied parts.
ABOUT THIS MANUAL
TABLE OF CONTENTS: Tells you where to look in the manual.
SAFETY MESSAGES: Section contains important information regarding hazard or unsafe practices of the machine. Lev-
els of hazards are identified that could result in product or personal injury, or severe injury resulting in death.
OPERATION CONTROLS / MACHINE COMPONENTS: Shows you the different machine controls and features.
MACHINE SETUP: Tells you how to setup machine from un-crating to installing squeegee and brushes.
MACHINE OPERATION: Section is to familiarize the operator with the operation and function of the machine.
BATTERY CHARGING: Shows you how to charge the batteries (on-board and off board charging).
MAINTENANCE: This section contains preventative maintenance to keep the machine and it’s components in good work-
ing condition. They are listed in this general order:
• Batteries
• Brooms
• Filters
• Service Schedule
• Machine Trouble Shooting
TROUBLE SHOOTING: A list of common problems that may occur.
MACHINE SPECS: Tells you Machine Specifications for the various parts of the machine.
MACHINE INSTALL FORM: Should be filled out upon machine installation and faxed to 1-866-632-6961 or online at
www.rpscorporation.com.
WARRANTY POLICY: Tells you coverage, exclusions and limitations to warranty.
NOTE: The serial number of your machine is located on the lower half of the Steering Pedestal of the machine.
AS OUR POLICY IS ONE OF CONSTANT IMPROVEMENT - ALL INFORMATION AND
SPECIFICATIONS ARE SUBJECT TO CHANGE WITHOUT NOTICE.
SERIAL NUMBER
TR-OP-EN - 3 -
TABLE OF CONTENTS
Introduction 2
About This Manual 2
Table of Contents 3
Safety Messages 4
Safety Label Locations 6
Operation Controls 7
Operation Controls 8
Operation Controls 9
Machine Components 10
Machine Components 11
Machine Setup 12
Un-Crating Machine: 12
Connecting Batteries: 12
Installing Main Broom: 12
Installing Side Brooms: 13
Adjusting Side Brooms: 13
Machine Operation 13
Pre-Cleaning Checklist: 13
Operating Hints: 13
Sweeping: 14
WET Sweeping: 14
Cleaning Filter: 15
Changing Filter: 15
Empty Hopper: 15
On-Board Charger 16
On-Board Battery Charging (Optional): 16
Description of LED:16
Battery Charging 17
External Battery Charging: 17
Battery Maintenance Guide 18
Safety: 18
Inspection and Cleaning: 18
Storage: 18
Watering: 18
Maintenance 19
Daily Maintenance: 19
Weekly Maintenance: 19
Monthly maintenance: 19
Yearly Maintenance: 19
Storing Machine: 19
Checking Battery Specific Gravity: 19
VR PM Records 20
Trouble-shooting 22
Machine Specs 23
Common Wear Parts 24
Cylindrical Brooms: 24
Side Brooms: 24
Filter Kits: 24
Standard Warranty Policy 25
Machine Install / Warranty Registration 26
- 4 - TR-OP-EN
SAFETY MESSAGES
You will see four kinds of safety reminders in this manual:
DANGER
DANGER indicates a hazardous situation which, if not
avoided, will result in death or serious injury.
WARNING
WARNING indicates a potentially hazardous situation
which, if not avoided, could result in death or serious
injury.
CAUTION
CAUTION indicates a potentially hazardous situation
which, if not avoided, could result in minor or moderate
injury or damage to this machine or nearby objects. CAU-
TION also can be used to alert against unsafe practices.
NOTICE
NOTICE indicates information considered important, but
not hazard-related. This safety message may be related
to property damage or warranty warnings.
Your safety, and that of others, is very important. Operating this machine safely is an important responsibility.
DO NOT OPERATE THIS MACHINE:
• Unless you are trained and authorized to do so by your RPS Authorized Local Distributor
• Unless you have read and understood this Operator’s Manual
• On surfaces with greater than a 5% grade
• Unless equipped with a functional parking brake
WHEN OPERATING THIS MACHINE:
• Remove loose objects from the floor that could be projected from the rotating Brooms
• Keep your hands and feet away from the rotating Brooms
• Do not operate this machine where flammable liquids are present
• Use caution when maneuvering
BEFORE LEAVING THE MACHINE:
• Park the machine on a level surface
• Turn the machine off & remove key
• Open battery lid
BEFORE SERVICING THE MACHINE:
• Disconnect the Batteries
DANGER
Explosive hydrogen gas forms when Batteries are
charging. An open flame or spark can cause this gas
to explode. Serious personal injury or property damage
could occur. Only charge the Batteries in this machine in
a well ventilated area.
TR-OP-EN - 5 -
WARNING
The Batteries in this machine produce hazardous
voltage which can cause electrical shock, burns and/
or electrocution. Always disconnect Batteries before
servicing this machine.
WARNING
When climbing or descending ramps, always drive
machine forward. To avoid overturning the machine, Do
not back down ramps. Do not drive across inclines. Do
not turn while ascending or descending ramps. Over-
turning the machine can cause serious injury or death.
WARNING
Do not park this machine on ramps or slopes. Always
park this machine on a level, hard surface. Do not oper-
ate this machine outdoors or on uneven surfaces.
WARNING
The Batteries in this machine contain sulfuric acid,
which causes burns to skin. If battery acid contacts
clothing or skin, rinse the effected area with cold water
immediately. If battery acid gets on your face or in your
eyes, flush the area immediately with cold water and
seek medical attention.
WARNING
To avoid electrical shock, do not operate this machine
over electrical floor outlets.
WARNING
Dress safely. Do not wear rings or metal wrist watches
when servicing this machine, as they can cause an
electrical short circuit which can cause serious burns.
WARNING
Do not remove, paint over or destroy warning decals. If
warning decals become damaged, call 1-262-681-3583
for free replacements.
WARNING
Dress safely. Do not wear a neck tie, scarf, or any
loose or dangling clothing while operating this machine.
Loose or dangling clothing or neck-wear can tangle in
rotating parts, causing serious injury or death.
WARNING
Always turn off this machine before leaving it unat-
tended. Do not allow untrained persons to operate this
machine.
WARNING
NO RIDERS. Do not carry passengers on this ma-
chine. Do not use this machine as a stepladder or work
platform.
WARNING
Understand the dynamic braking system before you
operate the machine on ramps. 5 Degree max.
WARNING
Before you service a Battery, always wear face protec-
tion, protective gloves and protective clothing. Battery
acid or battery explosion can cause serious injuries.
CAUTION
Do not operate this machine if any parts have been
damaged or removed.
CAUTION
Always use the automatic battery charger provided by
the manufacturer of this machine to charge the Batter-
ies of this machine. It is designed to charge the Batter-
ies at the appropriate rate. If you must use a different
charger, disconnect the Batteries before charging to
avoid damage to the electronic speed controller.
CAUTION
To avoid damage to the electronic control components
of this machine, Do not store this machine outdoors. Do
not pressure wash this machine.
- 6 - TR-OP-EN
SAFETY LABEL LOCATIONS
Read and obey all Safety Labels on your VR Floor Sweeper. If you have questions about these labels, ask your supervi-
sor.
These images indicate where on the VR Safety Labels are located. If ever the labels become illegible, worn off, or torn,
promptly report it to your supervisor and replace it.
USE ONLY DISTILLED WATER IN THE BATTERIES. USE
ONLY THE OEM CHARGER PROVIDED WITH THE MA-
CHINE. ALWAYS DISCONNECT THE BATTERY BEFORE
SERVICING THE MACHINE.
REFER TO MANUAL OR CALL +011-262-681-3583
DANGER
EXPLOSION RISK!
EXPLOSIVE HYDROGEN GAS FORMS WHEN
BATTERIES ARE CHARGING. AN OPEN FLAME
OR SPARK CAN CAUSE THIS GAS TO EXPLODE.
ONLY CHARGE THE BATTERIES IN THIS MA-
CHINE IN A WELL VENTILATED AREA.
BATTERY CHARGING LABEL
PART #: 349-7280
USEONLYDISTILLEDWA
TERINTHEBATTERIES. USE
ONLYTHEOEM CHARGER PROVIDEDWITH THEMA-
CHINE.ALWAYSDISCONNECT THE BA
TTERYBEFORE
SERVICINGTHEMACHINE.
REFERTOMANUALORCALL+011-262-681-3583
DANGER
EXPLOSIONRISK!
EXPLOSIVEHYDROGENGAS FORMS WHEN
BATTERIESARECHARGING. AN OPENFLAME
ORSPARKCANCAUSE THIS GAS TO EXPLODE.
ONLYCHARGETHEBA
TTERIESINTHISMA-
CHINEINAWELL VENTILATEDAREA.
TR-OP-EN - 7 -
OPERATION CONTROLS
1. CIRCUIT BREAKER: 15 AMP resettable circuit breaker
2. CIRCUIT BREAKER: 15 AMP resettable circuit breaker
3. CIRCUIT BREAKER: 10 AMP Side Broom resettable circuit breaker
4. CIRCUIT BREAKER: 40 AMP Main Broom resettable circuit breaker
5. KEY SWITCH: Turns power of the machine ON and OFF
6. EMERGENCY STOP (OPTIONAL): 1 button push machine shut down in case of emergency
6
1
234
5
- 8- TR-OP-EN
OPERATION CONTROLS
1. SIDE BROOM SPEED CONTROL KNOB: Controls the speed of the Side Brooms - Turn
counterclockwise to reduce speed
2. FILTER SHAKER SWITCH: Filter shaker button shakes filter to remove dust or debris particles to
deposit into the hopper for removal
3. BRUSH AMP GAUGE: Indicates the amount of amperage that the Main Broom pulling
4. BATTERY GAUGE / HOUR METER: Indicates the amount of batery charge remaining along with
total hours used
5. MAIN BROOM SWITCH: Tuns the Main Broom ON or OFF
6. SIDE BROOM SWITCH: Turns the Side Brooms ON or OFF
7. REVERSE SWITCH: Switch back for reverse machine drive
1
2
3
4
5
6
7
TR-OP-EN - 9 -
OPERATION CONTROLS
1. SIDE BROOM LIFT LEVER: Lifts and lowers Side Brooms that allow for debris clean up
directly up to walls
2. ADJUSTABLE SEAT WITH ARM RESTS: The machine is equipped with an ergonomic
seat with adjustable arm rests and positioning
3. MAIN BROOM LIFT LEVER: Lifts and lowers the Main Broom
4. STEERING WHEEL: Steers the main Drive Wheel
5. HORN: Sounds the horn for warning oncoming traffic
6. HEADLIGHT SWITCH: Turns power of the Headlights ON and OFF
7. ADJUSTABLE STEERING: Four settings for operator comfort and ease of entry
8. HOUR METER: Hour meter to indicate complete time machine has been ON
9. RECHARGE CYCLE METER: Shows the amount of charges on a machine
10. CHARGER PORT: Grey 50 used to receive charger input for optional external charger
11. FOOT PEDAL: Controls the acceleration and deceleration of the machine
1
3
24
5
6
7
8
9
10
11
OPPOSITE SIDE OF
STEERING PEDESTAL
- 10 - TR-OP-EN
MACHINE COMPONENTS
1. STROBE LIGHT (OPTIONAL): Optional Strobe Light silently alerts others nearby of the
machines presence
2. HEADLIGHTS: Helps you see in low light areas and to warn oncoming traffic
3. SIDE BROOM GUARDS (OPTIONAL): Optional Side Broom Guards protect your Side
Broom Brushes in case operator error
4. SIDE BROOMS: Allows for debris clean up directly up to walls
5. FRONT DRIVE TIRE: Drives and steers the machine
6. TIE DOWN POINTS: Location for tie down straps during transport
7. FILTER ACCESS LATCH: Latch holds the Filter Box together while also releasing and
allowing access to the inside of the Filter Box
8. SIDE ACCESS DOOR: Protects the Main Broom and Hopper
9. SIDE DOOR LATCH: Opens and latches closed the Side Access Door to the Main
Broom and Hopper
10. REAR WHEELS: Rear wheels provide three point stability for this machine
11. SIDE BROOM ADJUSTMENT SCREW: Turn screw counterclockwise for fine tuning of
height adjustment of the Side Brooms to accommodate for brush wear
6
6
10
11
1
2
3
4
45
8
7
9
3
Indice
Altri manuali Tomcat Soffiatore
