Toyota Prius 2010 Istruzioni operative

ILLUSTRATION

ON-VEHICLE INSPECTION

1. INSPECT THROTTLE BODY ASSEMBLY

(a) Check for throttle control motor operating sound.

(1) Turn the power switch on (IG).

(2) When depressing the accelerator pedal, check the operating sound of the motor. Make sure that no friction

noises are emitted from the motor. If any friction noise exists, replace the throttle body assembly.

(b) Set the vehicle to the inspection mode .

speed is within the specified range when the A/C is switched off.

Standard:

Condition

Engine Idle Speed

A/C switched off

950 to 1050 rpm

NOTICE:

x Be sure to perform this step with all accessories off.

x Make sure that park (P) is selected.

REMOVAL

1. REMOVE NO. 1 ENGINE UNDER COVER

2. DRAIN ENGINE COOLANT (for Engine)

3. REMOVE NO. 2 CYLINDER HEAD COVER

4. REMOVE AIR CLEANER CAP SUB-ASSEMBLY

(a) Disconnect the mass air flow meter connector.

(b) Release the 2 clamps.

5. REMOVE INLET AIR CLEANER ASSEMBLY

(a) Separate the hose from the hose clamp.

(b) Separate the wire harness clamp from the inlet air cleaner assembly.

6. REMOVE AIR CLEANER CASE

(a) Remove the air cleaner filter element.

(b) Separate the hose from the 3 hose clamps.

7. REMOVE AIR CLEANER HOSE ASSEMBLY

(a) Loosen the hose clamp and separate the ventilation hose.

(b) Unlock the hose clamp and remove the air cleaner hose assembly.

8. REMOVE THROTTLE BODY ASSEMBLY

(a) Disconnect the throttle body connector and the 2 water by

pass hoses.

(b) Remove the 2 bolts, 2 nuts and throttle body assembly.

INSPECTION

1. INSPECT THROTTLE BODY ASSEMBLY

(a) Measure the resistance according to the value(s) in the table below.

Text in Illustration

Component without harness connected

(Throttle Body)

Standard Resistance:

Tester Connection

Condition

Specified Condition

1 (M-) - 2 (M+)

20°C (68°F)

0.3 to 100 Ω

If the result is not as specified, replace the throttle body assembly.

INSTALLATION

1. INSTALL THROTTLE BODY ASSEMBLY

(a) Install a new gasket onto the intake manifold.

(b) Install the throttle body assembly with the 2 bolts and 2 nuts.

Torque:

10 N·m (102 kgf·cm, 7ft·lbf)

2. INSTALL AIR CLEANER HOSE ASSEMBLY

(a) Install the air cleaner hose assembly and lock the hose clamp.

(b) Connect the ventilation hose.

3. INSTALL AIR CLEANER CASE

(a) Install the air cleaner case with the 3 bolts.

Torque: 7.0 N·m (71 kgf·cm, 62in·lbf)

(b) Install the hose to the 3 hose clamps.

4. INSTALL INLET AIR CLEANER ASSEMBLY

(a) Install the inlet air cleaner assembly with the 3 bolts.

Torque:

7.0 N·m (71 kgf·cm, 62in·lbf)

(b) Connect the wire harness clamp to the inlet air cleaner assembly.

5. INSTALL AIR CLEANER CAP SUB-ASSEMBLY

(a) Install the air cleaner cap sub

assembly with the 2 clamps.

(b) Tighten the hose clamp.

6. ADD ENGINE COOLANT (for Engine)

7. INSPECT FOR COOLANT LEAK (for Engine)

8. INSTALL NO. 2 CYLINDER HEAD COVER

9. INSTALL NO. 1 ENGINE UNDER COVER

10. PERFORM INITIALIZATION

NOTICE:

Be sure to perform this procedure after reassembling the throttle body assembly, removing and reinstalling any

throttle body component or replacing the ECM.

(a) Disconnect the cable from the negative (-) battery terminal. Wait at least 60 seconds and reconnect the cable.

(b) Connect the Techstream to the DLC3 and clear the DTCs .

(d) Start the engine without operating the accelerator pedal and check that the MIL is not illuminated and that

the idle speed is within the specified range when the air conditioning is switched off after the engine is warmed

up.

Standard:

Condition

Engine Idle Speed

A/C switched off

950 to 1050 rpm

NOTICE:

x If the accelerator pedal is operated, perform the above steps again.

x Be sure to perform this step with all accessories off.

x Make sure that park (P) is selected.

(e) Perform a road test and confirm that there are no abnormalities.

Altri manuali per Prius 2010

Indice

Altri manuali Toyota Automobile

Toyota

Toyota 2009 4Runner Manuale utente

Toyota

Toyota AT180 Series Istruzioni operative

Toyota

Toyota Celica 2002 Manuale utente

Toyota

Toyota Camry 2004 Manuale utente

Toyota

Toyota 2011 Camry Hybrid Manuale utente

Toyota

Toyota C-HR2018 Manuale utente

Toyota

Toyota 4Runner 2003 Manuale utente

Toyota

Toyota Avalon 2014 Manuale utente

Toyota

Toyota 2012 CAMRY LE Manuale utente

Toyota

Toyota 2011 Camry Hybrid Manuale utente

Toyota

Toyota 2014 FJ Cruiser Manuale utente

Toyota

Toyota Sienna 2003 Manuale utente

Toyota

Toyota SIENNA 2009 Manuale di servizio

Toyota

Toyota 2003 Camry Manuale utente

Toyota

Toyota HIGHLANDER 2010 Manuale utente

Toyota

Toyota SIENNA U Manuale utente

Toyota

Toyota 4Runner 2020 Manuale utente

Toyota

Toyota 2011 HILUX VSS 3 Manuale utente

Toyota

Toyota HIACE 2006 Manuale utente

Toyota

Toyota Kluger Manuale utente

Toyota

Toyota 2013 Prius PHV Manuale utente

Toyota

Toyota 4RUNNER 1998 Manuale utente

Toyota

Toyota 2007 FJ Cruiser Manuale utente

Toyota

Toyota 2012 Rav4 Manuale utente

Manuali Automobile popolari di altre marche

CITROËN

CITROËN DS4 DSign Manuale utente

Lexus

Lexus 2015 CT 200h Manuale utente

Cadillac

Cadillac CTS 2008 Manuale utente

Mercedes-Benz

Mercedes-Benz M-class ML 55 AMG Manuale utente

Porsche

Porsche Boxster S Manuale utente

GMC

GMC 2010 Savana 1500 Cargo Manuale utente

KIAM

KIAM SPORTAGE 2014 Manuale elenco delle parti

GMC

GMC 2013 Terrain Istruzioni per il montaggio

GMC

GMC T-Series 1999 Manuale utente

Mercury

Mercury 1998 Mystique Manuale utente

Mercury

Mercury 2007 Mariner Manuale utente

Mazda

Mazda 2007 Mazdaspeed 3 Guida

Mazda

Mazda 2014 CX-5 Manuale utente

GMC

GMC Chevrolet Express 2022 Manuale utente

GMC

GMC 1997 Jimmy Manuale utente

Chevrolet

Chevrolet 2012 Malibu Manuale utente

Cadillac

Cadillac 2010 Escalade Manuale utente

Skoda

Skoda FABIA RS - ANNEXE 118 Manuale utente