Trane GECA -006 Guida all'installazione

GECA-SVX01B-EN

Models

“A” and later Design Sequence

60 HZ: GECA -006, -009, -012, -015, -018

50 HZ: GECA -006, -009, -012, -015

Installation

Owner

Diagnostics

AxiomTM Console Configuration

Water-Source Comfort System

Model GEC

General

Information

Introduction

The GECA water-source comfort system contains standard features to enhance performance, serviceability

and extend life of the equipment. Several of these features are shown below:

WATER

REGULATING

CONNECTION

WARNINGS / CAUTIONS

EXPLANATION:

Warnings are provided throughout

this manual to indicate to installing

contractors, operators, and service

personnel potentially hazardous

situations which, if not avoided,

COULD result in death or serious

injury.

WARNING

Cautions are provided throughout this

manual to indicate to installing

contractors, operators, and service

personnel potentially hazardous

situations which, if not avoided, MAY

result in minor or moderate injury.

CAUTION

GECA-SVX01B-EN 3

Contents

Installation/Startup/Commissioning

General Information 2

Pre-installation Checklist 4

Dimensions/Weights 5

Installation Instructions 19

Electrical Requirements 27

Pre-Startup Checklist 29

Startup/Commissioning

Sequence of Operation 31

Startup Checklist & Log 34

Maintenance

Warranty Information

Troubleshooting Checklist

Unit Wiring

4GECA-SVX01B-EN

Jobsite Storage

This unit is intended for indoor use

only. To protect the unit from damage

due to the elements, and to prevent

possible IAQ contaminant sources

from growing, the unit should be

stored indoors. If indoor storage is

not possible, the following provisions

for outdoor storage must be met.

1. Place the unit(s) on a dry sur-

face or raise above the ground

to assure adequate air circula-

tion beneath the unit. This is to

assure that no portion of the unit

contacts standing water at any

time.

2. Cover the unit(s) with a water

proof tarp to protect them from

the elements.

3. Make provisions for continu-

ous venting of the covered

units to prevent moisture from

standing on the unit(s) sur-

faces. Wet interior unit insulation

can become an amplification site

for microbial growth (mold) which

has been determined to be a

cause of odors and serious

health related indoor air quality

problems.

4. Store units in the normal UP

orientation. Storing units in this

manner maintains oil in the com-

pressor.

5. Units may be stacked two high.

Pre-installation

Checklist

Jobsite Inspection

Each unit has been inspected, tested

and operated at the factory by pro-

duction and quality associates prior

to being crated for safe transit. How-

ever, rough handling or accidents

can occur resulting in damaged

equipment being delivered. Always

perform the following checks before

accepting a unit:

1. Do not sign the bill of lading

accepting the unit(s) until

inspection has been com-

pleted. Check for damage

promptly after the unit(s) are

unloaded. Once the bill of lading

is signed at the jobsite, the unit(s)

are now the property of the SOLD

TO party and future freight claims

MAY NOT be accepted by the

freight company.

2. Check the unit model numbers

on the bill of lading against

those ordered and received to

assure equipment is AS

ORDERED.

3. Check to assure that the refrig-

erant charge has been retained

during shipment by use of

gauges. Schrader taps are

located and labeled internal to

the cabinet. (See Figure 1).

Figure 1: Schrader location

HIGH

LOW

IMPORTANT!

After assuring that charge has been retained:

Reinstall schrader caps to assure that refrigerant

leakage does not occur.

Reinstall unit panel using all factory provided

screws.

Notice

UNIT CONTAINS HCFC (R-22)

REFRIGERANT

INSTRUCTIONS!

SECTION 608, PARAGRAPH C OF THE 1990 CLEAN AIR ACT STATES:

EFFECTIVE JULY 1, 1992, IT SHALL BE UNLAWFUL FOR ANY PERSON, IN COURSE OF

MAINTAINING, SERVICING, REPAIRING, OR DISPOSING OF AN AIR CONDITIONING SYS-

TEM, TO KNOWINGLY VENT OR RELEASE ANY CFC OR HCFC REFRIGERANT. MINIMAL

RELEASES (AIR PURGES OF REFRIGERANT HOSES) ASSOCIATED WITH GOOD FAITH

ATTEMPTS TO RECAPTURE OR RECYCLE ARE EXEMPT FROM THE BAN ON VENTING.

Important!

Equipment is shipped FOB (Free on

Board) at the manufacturer. There-

fore, freight claims for damages

against the carrier must be initiated

by the receiver.

GECA-SVX01B-EN 5

Dimensions/

Weights

Unit

Size without Pallet with Pallet

60 HZ 50 HZ

Unit

Weight

(lbs)

Chassis

Weight

(lbs)

Unit

Weight

(lbs)

Chassis

Weight

(lbs)

006 - 188 140 218 170

009 006 192 144 222 174

012 009 204 156 234 186

015 012 203 155 233 185

018 015 210 162 240 192

Unit Clearance

Access to the unit for servicing purposes should be provided at installation. All configurations require clear-

ance from other mechanical and electrical equipment on three service sides (shown below). This enables

panel removal from the unit for service/maintenance ability.

6GECA-SVX01B-EN

Dimensions/Weights

Cabinet (RH) no Pump Kit

GECA-SVX01B-EN 7

Dimensions/Weights

Subbase (RH) no Pump Kit

8GECA-SVX01B-EN

Dimensions/Weights

Cabinet (LH) no Pump Kit

GECA-SVX01B-EN 9

Dimensions/Weights

Subbase (LH) no Pump Kit

10 GECA-SVX01B-EN

Dimensions/Weights

Cabinet (RH) Extended Length

Questo manuale è adatto per i seguenti modelli

Indice

Altri manuali Trane Pompa di calore

Trane

Trane CAUC-C20 Manuale del proprietario

Trane

Trane GEHE 072-180 Istruzioni per l'installazione e il funzionamento

Trane

Trane Horizon OADG Series Istruzioni per l'installazione e il funzionamento

Trane

Trane 4TCY5024A1000A Istruzioni per il montaggio

Trane

Trane 4TWR3 Istruzioni per il montaggio

Trane

Trane TWA Series Manuale utente

Trane

Trane BAYVALV001 Manuale utente

Trane

Trane Horizon OAKD Istruzioni per l'installazione e il funzionamento

Trane

Trane 4TWR3 Istruzioni per il montaggio

Trane

Trane 4TWR5018G Istruzioni per il montaggio

Trane

Trane Ultra-Low NOx Series Istruzioni per il montaggio

Trane

Trane TTK 509 E Manuale utente

Trane

Trane WEATHERTRON 4TWX6 Istruzioni per il montaggio

Trane

Trane A4HP5018D1000A Istruzioni per il montaggio

Trane

Trane Voyager PKGP-PRC001-EN Manuale utente

Trane

Trane 4TWX5018B Istruzioni per il montaggio

Trane

Trane ComfortLink 4TWZ0060A1000A Manuale utente

Trane

Trane 4WCZ6036B3000A Manuale utente

Trane

Trane TTPO30D Istruzioni per il montaggio

Trane

Trane Axiom VSHE024 Manuale

Trane

Trane 2TTX4018B Istruzioni per il montaggio

Trane

Trane GEHB018 Manuale utente

Trane

Trane Horizon OABD Series Istruzioni per l'installazione e il funzionamento

Trane

Trane 4TWB4018G Istruzioni per il montaggio

Manuali Pompa di calore popolari di altre marche

MICROWELL

MICROWELL HP 1000 GREEN Manuale utente

Sanyo

Sanyo SAP120FCH Manuale utente

Daikin

Daikin EHYHBH05AA Manuale utente

Panasonic

Panasonic WH-SDF03E3E5 Guida

Bryant

Bryant 544B Manuale utente

Airxcel

Airxcel 45000 Series Manuale

Mitsubishi Electric

Mitsubishi Electric PUZ-SWM60VAA Manuale utente

Dimplex

Dimplex LI 16I-TUR Guida utente

Carrier

Carrier WSHP Open v3 Guida rapida alla configurazione

TGM

TGM CTV14CN018A Manuale utente

Carrier

Carrier 38MGQ Series Manuale utente

Kokido

Kokido K2O K880BX/EU Guida alla risoluzione dei problemi

Viessmann

Viessmann VITOCAL 300-G PRO Type BW 2150 Guida rapida

Carrier

Carrier 48EZN Manuale utente

Viessmann

Viessmann KWT Vitocal 350-G Pro Series Istruzioni operative

Ariston

Ariston NIMBUS Manuale utente

Weishaupt

Weishaupt WWP L 7 Guida utente

GE Zoneline AZ85H09EAC Manuale utente