Twister T4 Manuale utente
USER MANUAL
PN: 21-0028_REV02
TWISTERTRIMMER.COM
TWISTERTRIMMER.COM
Front Cover: T4 standard speed control ediঞon on a Trim Saver stand.
TWISTERTRIMMER.COM pg | 1
TABLE OF CONTENTS
Important Safety Informaঞon
Machine Overview
Stand Conversion
Iniঞal Setup
Control Panel Overview
Operaঞon
Disassembly
Reassembly
Inspecঞons
Cleaning
Maintenance
Storage
Troubleshooঞng
Warranty Informaঞon
Specicaঞons
Spare Parts and Accessories
Conveyor and Rails Guide
Contact Us
2
5
9
11
19
20
24
33
40
44
46
60
61
68
70
72
75
76
TWISTERTRIMMER.COMpg | 2
IMPORTANT SAFETY INFORMATION
This manual is for the Twister T4 Trimmer. In this manual,
the T4 Trimmer will simply be referred to as the T4.
The T4 is a high-speed cuমng machine requiring special
safety precauঞons to be pracঞced during operaঞon,
cleaning, and maintenance to reduce the risk of personal
injury. Read this manual, including all important safety
informaঞon, danger, warning, and cauঞon signs before
using the T4.
Keirton is conঞnually improving all its products. As
a result, engineering changes are someঞmes made.
If operaঞon or appearances di@er from this manual, please contact Keirton technical support for
assistance (see Contact Us on page 76).
Do not allow anyone to use the T4 without this manual. A rst ঞme user of the T4 should obtain
proper training or instrucঞon from this manual.
General Safety Information
• Do not operate, clean, or conduct maintenance on the T4 while ঞred or under the
inuence of drugs, alcohol, or medicaঞons.
• Safety glasses, dust masks, and ear protecঞon must be worn when operaঞng the T4.
• Do not wear loose clothing or jewellery when operaঞng, cleaning, or conducঞng
maintenance on the T4.
• Conne long hair when operaঞng, cleaning, or conducঞng maintenance on the T4.
• Do not move, disassemble, reassemble, clean, or conduct maintenance on the T4 while
power is connected to the machine.
• Ensure all protecঞve covers are installed and hands are clear of the machine before
plugging in the T4.
CARELESS USE OF THE T4
OR OPERATING IT WITHOUT
READING THE INSTRUCTIONS
AND ACCOMPANYING DANGER,
WARNING, AND CAUTION
NOTICES MAY RESULT IN
SERIOUS OR FATAL INJURY.
DANGER
!
TWISTERTRIMMER.COM pg | 3
IMPORTANT SAFETY INFORMATION
• Ensure the T4 is connected to a vacuum before connecঞng either to power.
• Do not reach inside the tumbler while the T4 is plugged in.
• Keep body parts away from the moving parts of the T4.
• Keep the T4 well venঞlated to prevent overheaঞng.
• Do not allow water to collect on the ground around the T4. This could cause a slipping
hazard.
• The T4 is heavy. Always use proper li[ing technique. If necessary, use two people to li[.
• Subsঞtuঞng factory parts with third-party parts may void warranty or result in bodily
harm or damage to the T4.
• Do not remove safety labels from the machine. Replace any safety labels if they
become damaged or obscured.
• Keep visitors and children a safe distance from the T4.
Connection and Electrical Safety Information
• The T4 standard ediঞon with speed control requires a circuit breaker with the following
specicaঞons:
• 15A, 120V, 60Hz (North America)
• 10A, 230V, 50Hz (Europe)
• The T4 must be used in connecঞon with a properly grounded receptacle. Refer to the
specicaঞons (starঞng on page 70) to determine the correct electrical requirements.
• Observe all applicable building and electrical codes.
• Do not overload outlets or extension cords as this can result in re or electric shock.
• Do not use extension cords for the trimmer with a diameter narrower than 14AWG.
• Do not use extension cords for the trimmer longer than 50’ (15M).
• To power down the T4, switch o@the motors via the control panel before unplugging the
machine.
• The control box is not water ঞght. Always remove the control box before cleaning to
avoid water damage and electric shock.
TWISTERTRIMMER.COMpg | 4
Operation Safety Information
• Ensure the T4 is fully assembled and all guards, covers, and shrouds are in place before
operaঞon.
• Conduct all pre-operaঞon inspecঞons listed under Step 1: Inspect the T4 on page 20
before operaঞng the T4.
• Never let the T4 run unaended.
•
Only place plant maer in the T4. Do not put foreign objects in the T4. Doing so
may cause bodily harm or damage to the machine.
Maintenance Safety Information
• Conduct regular maintenance on the T4.
• Do not aempt to service electrical components on the T4 yourself. Opening or
removing covers may expose you to dangerous voltage and possible re or
electric shock.
• Do not aempt maintenance not covered in this manual unless directed by Keirton
technical support.
• Some repair or damage will require a qualied service technician who is trained in
machinery maintenance, service, and repair.
• Improper adjustments may result in damage to the machine.
• Replacement parts are specic to the T4 and must only be purchased from an authorized
dealer. Failure to comply may void warranty, cause bodily harm, and/or damage to the
machine.
IMPORTANT SAFETY INFORMATION
TWISTERTRIMMER.COM pg | 5
MACHINE OVERVIEW
Fig. 1
Fig. 2
SIDE PLATE
CONTROL BOX
LIFTING HANDLE TUMBLER
TUMBLER GUARD
BLADE BELT COVER
BLADE BELT
COVER BOLT
VACUUM SHROUD
ADJUSTMENT
CLICKER
BRUSH
VACUUM
SHROUD OUTLET
ADJUSTMENT BAR
LOCK KNOB
ADJUSTMENT
BAR
TWISTERTRIMMER.COMpg | 6
MACHINE OVERVIEW
Fig. 3
ROLLER
BRUSH END CAP
BLADE END PLATE
BLADE END CAP
VACUUM SHROUD
LOCK PIN
Fig. 4
CONTROL
BOX LOCK PIN
GAS SPRING
CONTROL BOX
LOCK KNOB
BLADE MOTOR
PULLEY
DRIVE WHEEL
BLADE BELT
HOPPER MAGNET
BLADE PULLEY
HOPPER PIN
CONTROL BOX
GUIDE PIN
TWISTERTRIMMER.COM pg | 7
MACHINE OVERVIEW
Fig. 5
Fig. 6
CONTROL PANEL
HELIX BLADE
CONTROL BOX
HOUR METER
POWER CABLE
DRIVE WHEEL
MOTOR
CONTROL BOX
SIDE PANEL
BED KNIFE
CONTROL BOX
SUPPORT BAR
T4 with the Trim Saver
TRIM SAVER
CYCLONE INLET
5” HOSE
HOSE CUFF
VACUUM
ATTACHMENT
COUPLING TRIM SAVER
STAND
TWISTERTRIMMER.COMpg | 8
MACHINE OVERVIEW
Fig. 7
T4 with the Leaf Collector
LEAF COLLECTOR
LEVELLING FEET
FILTER BAGS
LEAF
COLLECTOR
SWITCH
VACUUM
ATTACHMENT
COUPLING
LEAF COLLECTOR
STAND
Altri manuali per T4
3
Questo manuale è adatto per i seguenti modelli
4
Indice
Altri manuali Twister Tagliabordi
