UTICA BOILERS TriFire Guida all'installazione

Knockdown Boiler Assembly Instructions -

TriFire Model

Remove all components from crate. It may be to the1. installer’s advantage to place the cast iron boiler block

close to where the nal installation location will be.

Install rubber grommets in rear top plate. Attach with

2. brass bolts and washers. See Figure 1.

Figure 1

Rear of boiler

P/N 240007211, Rev. A [04/08]

KNOCKDOWN ASSEMBLY

Instructions for

TriFire Oil Fired Boiler

SUPPLEMENTAL INSTRUCTIONS

This assembly must be completed by a qualied installer or service agency, in accordance with the

manufacturer’s instructions, and in accordance with all codes and requirements of the authority having

jurisdiction. Failure to follow these instructions could result in re or explosion resulting in property dam-

age, personal injury, or loss of life.

WARNING

Wrap insulation around boiler with the smooth side out.3.

If necessary, overlap underneath boiler. Wrap 2 band-

ing strips around insulation. As shown in Figure 2,

Cinch banding together with plastic buckles provided.

Cut off excess banding material.

Figure 2

Insulation straps with buckles

Attach pipe nipples to supply and return outlets. Be4. sure to use pipe dope before screwing into boiler. See

Figure 3.

Figure 3

Attach insulation to rear of boiler. Attach insulation5. straps with plastic buckles as shown in Figure 4. Cut

off excess strap material as shown.

Figure 4

Place the control panel on the top of the boiler with the6. burner wire harness on the right. See Figure 4A.

Figure 4A

Insert brass bolts into threaded holes on front of boiler7. as shown in Figure 5. Do not tighten down. These

bolts will hold the side Jacket panels on the boiler.

Figure 5

KNOCKDOWN BOILER ASSEMBLY

Place the side jackets on the bolts from the previ-8. ous step. Be sure to route the burner wire harness as

shown in Figure 6.

Figure 6

11”

Attach the burner harness zip tie to right side jacket. If9.

no hole is present, drill 1/8” dia. See Figure 6.

Attach the lower rear panel, then attach the upper

10.

rear panel with the screws provided. See Figure 7

(Nipples removed for clarity.)

Figure 7

Rear of boiler

Attach the front control panel with the screws provided.11.

Check the clearance between the two side panels and en-

sure there is the same clearance top and bottom. Tighten

down the bolts mentioned in step 6. See Figure 8.

Figure 8

Attach the front panel by setting onto the rivets in the12.

side jackets. See gure 9.

Figure 9

KNOCKDOWN BOILER ASSEMBLY

Attach the top panel with the screws provided.13.

Proceed to the section “Packaged Boiler Assembly” in14.

the Installation, Operation and Maintenance manual.

KNOCKDOWN BOILER ASSEMBLY

For technical assistance with this product call toll free 1-800-325-5479

ECR International

PO Box 4729

Utica, NY 13504-4729

www.ecrinternational.com

Indice

Altri manuali UTICA BOILERS Caldaia

UTICA BOILERS

UTICA BOILERS BC3095 Manuale di istruzioni

UTICA BOILERS

UTICA BOILERS MGB Series Guida

UTICA BOILERS

UTICA BOILERS 95M-200 Manuale utente

UTICA BOILERS

UTICA BOILERS MGC-8D Manuale di istruzioni

UTICA BOILERS

UTICA BOILERS TriFire Manuale utente

UTICA BOILERS

UTICA BOILERS MGC 3 Series Manuale di istruzioni

UTICA BOILERS

UTICA BOILERS UBSSC-299 Manuale di istruzioni

UTICA BOILERS

UTICA BOILERS STARFIRE 3 WATER Manuale di istruzioni

UTICA BOILERS

UTICA BOILERS SFM CONSTELLATION Series Manuale di istruzioni

UTICA BOILERS

UTICA BOILERS TRIFIRE II Series Manuale di istruzioni

UTICA BOILERS

UTICA BOILERS USC SERIES Guida

UTICA BOILERS

UTICA BOILERS SFE0365 Manuale utente

UTICA BOILERS

UTICA BOILERS UH15B Series Manuale di istruzioni

UTICA BOILERS

UTICA BOILERS MAH-125 Manuale utente

UTICA BOILERS

UTICA BOILERS MAHF-100 Manuale utente

UTICA BOILERS

UTICA BOILERS PEG-C Manuale utente

UTICA BOILERS

UTICA BOILERS PEG075EID Manuale di istruzioni

UTICA BOILERS

UTICA BOILERS MGB 50 Manuale di istruzioni

UTICA BOILERS

UTICA BOILERS DV Guida

UTICA BOILERS

UTICA BOILERS USC SERIES Manuale di istruzioni

UTICA BOILERS

UTICA BOILERS UCS-380 Manuale utente

UTICA BOILERS

UTICA BOILERS UBSSC-050 Manuale del proprietario

UTICA BOILERS

UTICA BOILERS PEG112C Manuale utente

UTICA BOILERS

UTICA BOILERS DVB-50 Manuale del proprietario

Manuali Caldaia popolari di altre marche

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Manuale utente

Radijator

Radijator BIO max 23.1 Manuale utente

Brunner

Brunner BSV 20 Manuale utente

Buderus

Buderus Logamax GB062-24 KDE H V2 Manuale utente

Potterton

Potterton 50e Scheda tecnica

Joannes

Joannes LADY Series Manuale

ECR International

ECR International UB90-125 Manuale di istruzioni

Froling

Froling FHG Turbo 3000 Manuale utente

Froling

Froling P4 Pellet 8 - 105 Manuale utente

U.S. Boiler Company

U.S. Boiler Company K2 Manuale utente

Henrad

Henrad C95 FF Manuale utente

NeOvo

NeOvo EcoNox EF 36 Manuale utente

Potterton

Potterton PROMAX SL 12 Manuale utente

Eco Hometec

Eco Hometec EC 25 COMPACT Manuale utente

Viessmann

Viessmann VITODENS 200 Guida

Baxi

Baxi Prime 1.24 Manuale utente

REXNOVA

REXNOVA ISA 20 BITHERMAL Manuale utente

Radiant

Radiant R2K 55 Manuale