Varimixer W30 Manuale utente

PLEASE REFER TO THE DIAGRAM ON PAGE 2

1REMOVE NUT (J) AND SHIM WASHERS (H)

2 PRY OFF FORK ASSEMBLY (X).

3 REMOVE SPECIAL V-BELT (A).

4 REMOVE TWO 17MM BOLTS (V)

5 REMOVE 4 BOLTS FROM MOTORPLATE (T).

6 ON OLDER MODEL MIXERS WITH SINGLE PHASE MOTORS,IT MAY BE NECESSARY

TO DISCONNECT THE START & RUN CAPACITORS FROM THE SIDE OF THE

MOTOR BEFORE LIFTING THE MOTOR OUT OF THE MIXER.

7 LIFT MOTOR OUT OF MIXER BODY. SET MOTOR ASSEMBLY ON A BOARD LAYED

ACROSS THE TOP OF THE MIXER.

8 DISCONNECT WIRE HARNESS FROM MOTOR.

NOTE: DO NOT FOLLOW STEPS 9-12 IF YOU ARE REPLACING THE WHOLE

ASSEMBLY. (MOTOR ,GEARBOX,MOTOR PLATE AND PULLEY.

9 GRASP TOP PULLEY (W) AND BANG AGAINST CLAMPING RING & WASHER (S)

THIS ACTION WILL REMOVE PULLEY FROM MOTOR SHAFT.

10 REMOVE 4 SLOTTED HEAD SCREWS FROM MOTOR PLATE TO MOTOR.

REMOVE MOTOR PLATE.

11 INSTALL MOTOR PLATE ONTO MOTOR,TIGHTEN 4 SLOTTED HEAD SCREWS.

INSURE CAPACITORS WILL FACE THE REAR OF THE MIXER WHEN MOTOR IS

INSTALLED.

12 INSTALL MOTOR PULLEY ONTO MOTOR SHAFT,TAKING CARE TO ALIGN KEY WITH KEYWAY. BANG TOP PULLEY AGAINST BOTTOM

PULLEY UNTIL INSTALLED.

13 PLACE MOTOR ON TOP OF MIXER AND CONNECT MOTOR TO HARNESS. (FOLLOW DIAGRAM

ON MOTOR)

14 LOWER MOTOR INTO MIXER BODY.INSTALL 4 BOLTS (T) TO THE MOTOR PLATE. DO NOT TIGHTEN!

15 INSTALL 2 17MM BOLTS (V)

16 MEASURING THE DISTANCE BETWEEN PULLEYS (B),ON 30QT. & 40 QT. THE

DISTANCE SHOULD BE 11 1/2 INCHES.SLIDE MOTOR TO REACH THIS DISTANCE.

ON 60QT.-150QT.,THE DISTANCE SHOULD BE 12 1/4"S.

17 TIGHTEN 13 MM BOLTS (T) AND 17 MM BOLTS (V).

NEXT PAGE

Motor Removal Instructions

Models W30-W150

Motor Removal Instructions

Models W30-W150

18 INSTALL SPECIAL V-BELT (A).

19 INSTALL FORK ASSEMBLY (X).

20 INSTALL WASHERS (G) (H) AND NUT (J).DO NOT TIGHTEN NUT.

21 START THE MIXER AND TIGHTEN THE NUT (J).

DO NOT OVERTIGHTEN!

22 ON THE FRONT PULLEY SET,THE STUD (K) ON THE VARISPEED COLLAR (L) MUST BE PLACED

INSIDE THE LOWER FORK (M),AND ON THE REAR PULLEY SET OUTSIDE THE FORK (N).

23 ADJUST THE SPEED BY TURNING THE THE STOP SCREWS (O) IN OR OUT.

24 THE STOP SCREWS (O) ON THE SPEED LEVER SHOULD BE ADJUSTED SO THAT THE

MEASUREMENT (P) IS 1-2MM ON THE FRONT AND REAR PULLEY,AT HIGH AND LOW SPEED,

RESPECTIVELY.TIGHTEN THE JAM NUTS (R) WHEN THE SPEED IS CORRECTLY ADJUSTED.

Motor Removal Instructions

Models W30-W150

Altri manuali per W30

1

Questo manuale è adatto per i seguenti modelli

1

Indice

Altri manuali Varimixer Miscelatore

Varimixer

Varimixer KODIAK20 Manuale utente

Varimixer

Varimixer V20K Guida

Varimixer

Varimixer W150N MK-I Manuale utente

Varimixer

Varimixer W80A Manuale utente

Varimixer

Varimixer V80 Manuale utente

Varimixer

Varimixer V20K Guida

Varimixer

Varimixer V150PLM Manuale utente

Varimixer

Varimixer V5A TEDDY Guida

Varimixer

Varimixer ERGO100 Manuale utente

Varimixer

Varimixer W80 Guida

Varimixer

Varimixer W20A Guida

Varimixer

Varimixer W40(A) Guida

Varimixer

Varimixer KODIAK10 Manuale utente

Varimixer

Varimixer W80 Manuale utente

Varimixer

Varimixer AR80 Series Manuale utente

Varimixer

Varimixer TEDDY W5A Manuale utente

Varimixer

Varimixer W20SF Manuale utente

Varimixer

Varimixer AR30 VL-1S Manuale utente

Varimixer

Varimixer V30K Guida

Varimixer

Varimixer V30K Guida

Varimixer

Varimixer ERGO60 Manuale utente

Varimixer

Varimixer W20D Guida

Varimixer

Varimixer W30 Guida

Varimixer

Varimixer V80 Guida

Manuali Miscelatore popolari di altre marche

Bosch

Bosch GRW 9 Manuale utente

MULTIQUIP

MULTIQUIP Whiteman WM45E Guida

KitchenAid

KitchenAid KSM7581BZ0 Guida rapida

Jay-Lor

Jay-Lor 5050 Manuale utente

Sunbeam

Sunbeam FPSBSM210X Manuale utente

MULTIQUIP

MULTIQUIP Whiteman MC94S Guida

Thinky

Thinky ARE-250 Manuale utente

Midas

Midas XL4 Manuale utente

bianco

bianco PURO 4 Manuale utente

Paso

Paso DAG9200 Manuale utente

Sima

Sima SFX-9A Manuale utente

better chef

better chef IM-815WC Istruzioni per l'installazione

ALLEN & HEATH

ALLEN & HEATH GR1 Manuale utente

Lacor

Lacor 69083 Scheda tecnica

M-Audio

M-Audio Midiman SAM Manuale utente

Buffalo

Buffalo CP921 Manuale utente

Pentair

Pentair HYPRO Cleanload 3376-0870 Istruzioni operative

Cuisinart

Cuisinart SM50WHE Manuale utente