SAFETY PRINCIPLES
This manual provides specifications and describes recommended use and maintenance practices. Each set of
Off-road traction drive platform cart conforms to the generalized specifications disclosed in this manual and fulfills our
demanding standards for quality, safety and durability.
Each person who might participate in the use or maintenance of the product must read this manual and fully
understand the directions BEFORE using or performing maintenance on the cart. If you do not understand an
instruction, ask your supervisor or employer for assistance. Failure to adhere to the directions in this manual
might result in serious personal injury or even death.
Vestil is not liable for any injury or property damage that occurs as a consequence of failing to apply either: 1) the
instructions that appear in this manual; or 2) the information provided on labels affixed to the product. Furthermore,
failure to exercise good judgment and common sense might result in property damage, serious personal injury or
death. Such injury or damage is solely the fault of the person(s) who fail to exercise good judgment; it is not another
responsibility delegated to manufacturers.
This manual uses SIGNAL WORDS to classify personal injury risks and situations that might lead to property
damage, as well as to draw attention to safety messages. The reader must understand that each signal word
indicates the seriousness of the described hazard.
Identifies a hazardous situation which, if not avoided, WILL result in DEATH or SERIOUS
INJURY. Use of this signal word is limited to the most extreme situations.
Identifies a hazardous situation which, if not avoided, COULD result in DEATH or SERIOUS
INJURY.
Indicates a hazardous situation which, if not avoided, COULD result in MINOR or
MODERATE injury.
Identifies practices likely to result in product/property damage, such as operation that might
damage the cart.
SAFETY GUIDELINES
Failure to read and understand the instructions included in this manual BEFORE using or maintaining the
platform cart constitutes misuse of the product.Study the entire manual before using or maintaining the product
for the first time, and subsequently as necessary to refresh your understanding. DO NOT attempt to resolve any
problem(s) with the device unless you are both authorized to do so and certain that it will be safe to use afterwards.
If this product is used improperly or carelessly, the operator and/or bystander(s) might sustain serious
personal injuries. To reduce the likelihood of injury:
When not in use, store the cart in an indoor, dry location. DO NOT expose the electrical system to moisture (rain,
snow, etc.).
DO NOT remove or obscure any label. Verify the placement and legibility all labels. DO NOT use the cart UNLESS
all labels are attached and readable.
DO NOT attempt to transport unbalanced loads with the cart. Only use the cart to transport stable loads. Secure the
load to the deck with straps, if necessary to prevent the load from shifting during transport.
DO NOT exceed the load rating. ALWAYS make sure that the load weighs no more than the rated load of the coil
hook. Rated load varies with the supporting surface (ground/floor): 1) Maximum rated load when used on smooth,
level improved surfaces = 600 pounds (273kg); 2) when used on level, unimproved surfaces (e.g. gravel, dirt) = 500
pounds (227¼kg); and 3) inclined/sloped surfaces UP TO a maximum of 13 degrees = 400 pounds (182kg).
DO NOT ride on the cart or allows other person(s) to do so.
Inspect the cart prior to each use. DO NOT use the cart if it is noticeably AND dangerously damaged. Examples of
noticeable damage include, but are not limited to punctured tire(s), non-functioning brake lever, cut or exposed
electrical wires.
While traveling up or down an incline, DO NOT change the speed setting. Always traverse the whole incline in the
same speed setting, because changing the speed setting might cause the cart might roll down the incline in an
uncontrolled manner.
ALWAYS start the cart with the speed selection knob in the “Stop” position (see p. 4). ALWAYS return the speed
selection knob to “Stop” when the cart is not in use.
Improperly recharging the batteries might either cause the batteries to explode or result in battery damage. To
properly recharge the batteries: 1) Shut off the power (turn the switch key to “off”); 2) connect the AC extension cord
of the charger to the outlet of a nearby power supply (the charger will automatically turn on and it will run at a rate that
matches the requirements of the batteries.) When the batteries are fully charged, the charger will only supply enough
current to maintain charge; 3) disconnect the AC plug from the power supply once charging is complete.
DO NOT leave a loaded cart unattended. Always unload the cart BEFORE leaving the cart unattended.
Page 2 of 10
