WaterLogic WL900 Manuale utente
WL900 Manual Page 13 – Revision: 1-21-2021
SERVICE REQUIREMENTS
WARNING! Read and understand the contents of this manual before attempting to
service WL900 Water Treatment System. Failure to follow the instructions in this
manual could result in death, serious personal injury, or severe property damage.
Only trained and qualified technicians should attempt to install, maintain, or service
Waterlogic Equipment.
1. Visually inspect all electrical and water connections for signs of wear or damage.
2. Ensure there is adequate (minimum of 2”) clearance around the WL900 Water and Ice
Machine and clean the condenser grill and compressor fan to provide efficient cooling
system operation.
3. Sanitize the cold tank, ambient tank, and ice-making area per instructions in the pre-
installation procedures.
WARNING! SANITIZER MAY CONTAIN HAZARDOUS CHEMICALS. Use of proper
personal protective equipment such as rubber gloves and eye protection are required.
4. Clean and sanitize external surfaces of the WL900 Water and Ice Machine. Use soap and
water or chemicals that are compatible with ABS plastic and will not damage or degrade the
product surfaces.
5. Remove and clean the Faucet on every service visit.
6. Change out filters every 6 months, or as needed.
WL900 Manual Page 14 – Revision: 1-21-2021
REPLACEMENT COMPONENTS (CONSUMABLES)
Component
WLCP Part No.
Frequency of Replacement
Sediment Filter 22-1835 Every 6 Months
Carbon Pre-Filter 22-1840 Every 6 Months
RO Membrane Filter 22-1845 Every 6 Months
Carbon Post Filter 22-1850 Every 6 Months
Hot Tank Assembly 22-1660 Every 5 Years depending on use
CAUTION! Use only Waterlogic Replacement parts that can be obtained from Waterlogic
or an Authorized Waterlogic Dealer, failure to do so will void the Warranty.
See Installation and Service Manual for additional information.
Hot Tank Service
Hot Tanks (with controls) must be replaced every 5 years.
Surface Cleaning
Clean on a regular basis with damp lint free cloth. Never use harsh chemicals (alcohol or acid
based) or abrasive agents on any part of the product to avoid damage. A mild cleaner such as
Simple Green or equivalent is recommended.
Tank Sanitization
Clean and sanitize the inside of the ambient tank, ice bin, and cold tank on an annual basis to
inhibit issues with biofilm and mold. This process is covered in the Installation section.
DISPOSAL
End of Life
At the end of this product’s life, ensure that it is disposed of in an environmentally friendly
manner which is fully compliant with all Federal/State/Local Requirements and Guidelines.
Do not dispose of this appliance with normal household or business waste.
WL900 Manual Page 15 – Revision: 1-21-2021
WL900 MAIN DRAWING AND PARTS LIST
Yellow = Consumables
Green = Recommended
spare parts
145
213
22
142
83
15
79
16
173
172
84
133
12
129
132
15
174
187
182
143
138
105
181
176
15
180
178
177
179
141
228
21
167
212
20
224
175
215
219
168
134
8
103
130
130
137
228
228
228
2
9
135
135
11
6
4
3
7
135
135
228
5
17
158
N/A
127
169
170
171
WL900 Manual Page 16 – Revision: 1-21-2021
110
111
107
229
N/A
N/A
N/A
56
36
34
34
N/A
N/A
33
225
63
118
25
101
74
76
132
75
23
35
26
N/A
43
38
27
N/A
69
48
186
80
185
94
184
39
40
75
59
60
42
154
40
39
44
154
76
N/A
86
N/A
44
82
41
43
28
53
83
50
72
74
76
89
93
90
88
91
52
157
50
73
N/A
50
51
37
47
95
116
66
113
117
115
114
57
58
70
157
209
96
92
210
WL900 ICE UNIT DRAWING AND PARTS LIST
WL900 Manual Page 17 – Revision: 1-21-2021
No
WLCP Part
No.
Description Part No Purchase as:
1 22-1000 Base Panel Assembly 91-2250-0 Assembly
2 22-1005 FM Valve 1/4”PTC 11-1624-1 Individually
3 22-1010 Gutter FM Valve 11-1346-0 Assembly
4 22-1015 Caster 21-0313-0 Assembly
5 22-1020 Tube End 3/8” 31-0867-0 Assembly
6 22-1025 Base Panel 21-0403-4 Assembly
7 22-1030 Leg: Nob-less 11-0351-0 Assembly
8 22-1035 Booster Pump 41-1494-1 Individually
9 22-1040 Solenoid V/V: Raw Water 41-0789-3 Individually
10 22-1045 Wire AC #3 with Fuse and
Fuse Holder 41-2030-0 Individually
11 22-1050 Fixed Clip: Capacitor 25-0056-1 Individually
WL900 Manual Page 18 – Revision: 1-21-2021
12 22-1055 Compressor :
Samsung MSA670C-D1G 41-1828-1 Individually
13 22-1060 Refrigerant Step Valve 41-1607-1 Individually
14 22-1065 Left Side Panel Assy 91-3415-0 Assembly
15 22-1070 Drain Connector Assy 11-2467-0 Assembly
16 22-1075 Bulk Head 1/4”PTC 11-0297-0 Assembly
17 22-1080 Left Side Panel 21-0717-1 Assembly
18 22-1085 Ball Valve 1/4”PTC 11-0527-0 Assembly
19 22-1090 Drain Tube Assy PVC 91-2696-0 Assembly
20 22-1095 Spring Clip 17mm
Diameter 21-0521-0 Assembly
21 22-1100 Tube PVC 77-1188-0 Assembly
22 22-1105 Ice Unit Assembly 91-2783-0 Assembly
23 22-1110 Unit Panel 21-0709-0 Assembly Not Shown
WL900 Manual Page 19 – Revision: 1-21-2021
24 22-1115 Hook Ice Basket 11-2216-0 Assembly
25 22-1120 Ice Unit 11-2468-1 Assembly
26 22-1125 Seal Unit 31-0932-0 Assembly
27 22-1130 Bushing Spiral 11-2991-0 Assembly
28 22-1135 Sensor: Ice Full Transmit 41-0524-1 Assembly
29 22-1140 O-Ring P10A 31-0327-0 Assembly
30 22-1145 Ice Full Transmitter 11-0631-1 Assembly
31 22-1150 Sensor: Ice Full Receive 41-1810-0 Assembly
32 22-1155 O-Ring P10A 31-0327-0 Assembly
33 22-1160 Ice Full Receiver 11-0630-0 Assembly
34 22-1165 Rubber Bracket EVA 31-0934-0 Individually
WL900 Manual Page 20 – Revision: 1-21-2021
35 22-1170 Ice Basket 11-2470-1 Individually
36 22-1175 Ice Separator 11-2471-1 Individually
37 22-1180 Distributor Gasket 31-0885-0 Individually
38 22-1185 Head Pump Circulator
Seal 31-0324-1 Individually
39 22-1190 Cold Sensor Seal 31-0035-1 Individually
40 22-1195 Cold Water Level Sensor 41-1795-0 Individually
41 22-1200 Cold Water Temp Sensor 41-1801-0 Individually
42 22-1205 Pipe Assy SUS 3/8” 91-2763-0 Assembly
43 22-1210 Straight PTC Fitting 3/8 11-0434-0 Assembly
44 22-1215 Tee Fitting 3/8” 11-0435-0 Assembly
45 22-1220 O-ring P9 31-0329-0 Assembly
WL900 Manual Page 21 – Revision: 1-21-2021
46 22-1225 Pipe SUS 3/8” 21-0713-2 Assembly
47 22-1230 Pipe Bucket In 11-2493-1 Assembly
48 22-1235 Circulation Pump Head 11-2224-0 Assembly
49 22-1240 Water Distributor
Assembly 91-2764-0 Assembly
50 22-1245 O-Ring P8 31-0328-0 Assembly
51 22-1250 Distributor 91-2546-0 Assembly
52 22-1255 Connector Elbow 11-2215-1 Assembly
53 22-1260 Ice Discharge Motor 41-1911-0 Individually
54 22-1265 Auger Coupler Connector 11-2930-0 Individually
55 22-1270 Auger Bushing Connector
SUS 11-2931-0 Individually
56 22-1275 Spiral Auger 21-0839-2 Individually
WL900 Manual Page 22 – Revision: 1-21-2021
57 22-1280 EPS Upper Unit 61-1475-0 Individually
58 22-1285 EPS Lower Unit 61-1476-1 Individually
59 22-1290 Auger Coupler 11-2206-0 Individually
60 22-1295 O-Ring AN012 31-0880-0 Individually
61 22-1300 Rubber Bracket EVA 31-0934-0 Individually
62 22-1305 Rear Bracket Assy EVA 91-2765-0 Assembly
63 22-1310 Rear Bracket EVA 11-2487-0 Assembly
64 22-1315 Rubber Bracket EVA 31-0934-0 Assembly
65 22-1320 Ice Tray Rotational
Coupler 11-2220-2 Individually
66 22-1325 EPS Motor Panel 61-1782-0 Individually
67 22-1330 Motor Link Gasket 31-0881-0 Individually
Altri manuali per WL900
7
Altri manuali WaterLogic Sistema idrico
WaterLogic
WaterLogic WL800 - MAX II Manuale utente
WaterLogic
WaterLogic WL2FLT Manuale utente
WaterLogic
WaterLogic BLUPURA FIZZ 80 Manuale utente
WaterLogic
WaterLogic WL100 Manuale utente
WaterLogic
WaterLogic 12-WL200CT Manuale utente
WaterLogic
WaterLogic WL3FW Manuale utente
WaterLogic
WaterLogic BLUPURA FIZZ 80 Manuale utente
Manuali Sistema idrico popolari di altre marche
Spirotech
Spirotech SPIROVENT SUPERIOR S250 Manuale utente
Culligan
Culligan Aqua-Cleer Aqua-Cleer Advanced Drinking Water... Manuale utente
A.O. Smith
A.O. Smith Dura-Max AJH - 1000A - P Manuale utente
Microline
Microline T.F.C.-4 Manuale
Eureka Forbes
Eureka Forbes Aquaguard Select Manuale utente
Cetetherm
Cetetherm AquaEfficiency Manuale utente
