Webasto ProCore Edge 9 Manuale utente
ProCoreTM Edge 9/15
North America
Installation, Operation and
Maintenance Manual
Rev 05/18/23
ProCore Edge North America
31241-03-0202 Webasto Charging Systems, Inc.
IOMM
2 of 68
© Webasto Charging Systems, Inc., 2023. All rights reserved
PosiCharge™ systems is a product line of Webasto Charging Systems,
Inc. (WCSI). Webasto Charging Systems and the Webasto Charging
Systems logo are trademarks of WCSI. Corporate names, trademarks,
registered trademarks, service marks, symbols, and logos stated herein
are the property of the respective companies.
Changes or modications to this product not completed by an
authorized service provider could void the product warranty.
Disclaimer: this manual includes the latest information available at
the time of printing. WCSI reserves the right to make changes to
this manual and/or product without further notice. Specications
are subject to change without notice.
No portion of these materials may be duplicated, used, or disclosed
without prior written permission from WCSI.
posicharge.com | posichargeprocore.com
ProCore Edge North AmericaIOMM
Webasto Charging Systems, Inc. 31241-03-02023 of 68
A NOTE ABOUT CUSTOMER SUPPORT
Please write down the unit serial number in the Owner’s Record
below to ensure superior service, and have it available when
contacting Webasto Customer Service. The serial number can be
found on the nameplate rating label on the left side of the unit.
1-866-767-4242
Parts: [email protected]
Owner’s Record
Model: ProCore™ Edge
Serial Number (SN):
Installation date:
Output power:
ProCore Edge North America
31241-03-0202 Webasto Charging Systems, Inc.
IOMM
4 of 68
Contents
1. Installation, Operation and Maintenance Manual ............9
1.1. Scope.............................................................................9
1.2 Acronyms, Abbreviations and Symbols ........................10
2. Required Tools...................................................................12
3. Technical Specications for 48V and 80V
Modules Fitted with 3- or 5-Bay Cabinets ...........................12
4. Installation..........................................................................14
4.1. Multi-Charger Installation Schemes .............................14
4.2 Installation Precautions.................................................16
4.3 Positioning the Charger ...............................................17
4.4 Wall-Mount Installation..................................................18
4.5 Floor Stand Installation .................................................19
5. Remote Battery Connections (Option) ............................34
5.1. Ten-way Screw Terminal Connector.............................34
Table 1 Bare-Ended Signal Connections ............................36
5.2 Optional Features .........................................................37
6. Putting Back the DC-Panel and Top Covers ...................37
6.1. DC-panel Cover ...........................................................37
6.2. Top Cover.....................................................................37
ProCore Edge North AmericaIOMM
Webasto Charging Systems, Inc. 31241-03-02025 of 68
7. Charger Light Bar .............................................................38
8. Operating Instructions .....................................................40
8.1. Battery Display.............................................................42
8.2 Buttons..........................................................................47
9. Maintenance.......................................................................49
9.1 Power Module Replacement ........................................49
9.2. Air Filter Replacement (TBA – not yet available) .........60
9.3. Preventive Maintenance Activities ...............................60
Table 2 Preventative Maintenance Schedule .....................61
10. Faults and Warnings .......................................................63
ProCore Edge North America
31241-03-0202 Webasto Charging Systems, Inc.
IOMM
6 of 68
1. Installation, Operation and Maintenance Manual
1.1. Scope
This manual is intended for use by personnel trained to install and
use chargers for charging batteries in a safe and correct manner.
NOTE
NOTE
NOTE
Read and understand these manufacturer instructions and all safety
practices.
This manual covers the installation, operation, and maintenance of the
charger, and charger accessories.
This manual provides important information on how to install the charger
and should be carefully read.
This manual is based on information available at the time of publication.
The information herein, while eorts have been made to be accurate,
does not cover all details of, or variations in, the hardware or software;
or provide for every possible
contingency in connection with installation.
Features described herein may not be present in all systems.
NOTE
Each ProCore Edge has been assembled and programmed for each
customer. Webasto recommends that you contact Webasto Technical
Support before making any modications and/or additions (such as
additional modules) to your ProCore Edge.
ProCore Edge North AmericaIOMM
Webasto Charging Systems, Inc. 31241-03-02027 of 68
1.2 Acronyms, Abbreviations and Symbols
Acronym,
Abbreviation or
Symbol
Meaning
°C Degrees Celsius
°F Degrees Fahrenheit
AAmp(s) / Ampere(s)
AC Alternating Current
AWG American Wire Gauge
BMID Battery Monitor and Identier
BMS Battery Management System
CAN Controller Area Network
CB Circuit Breaker
CSA Canadian Standards Association
D Depth
DC Direct Current
Di Delta Current
Dt Delta Temperature
EU European Union
ft Foot or Feet
GCAN (G-CAN) Ground Controller Area Network
h Height
Hz Hertz (frequency)
Icc Conditional Short Circuit Current
Icp Prospective Short Circuit Current
mr Minimum Required
IEC International Electromechanical Commission
in. Inch(es)
in-lbs Inch Pounds
IP Ingress Protection (Rating)
ProCore Edge North America
31241-03-0202 Webasto Charging Systems, Inc.
IOMM
8 of 68
Acronym,
Abbreviation or
Symbol
Meaning
kg Kilogram(s)
kW Kilowatt(s)
L Length
lb. Pound(s) by Weight
Max. Maximum
Min. Minimum
mm Millimeter(s)
mm2Square Millimeter(s)
NEMA National Electrical Manufacturers Association
Nm Newton-metre/meter
OK All Correct
OCV Open Circuit Voltage
ph. Phase(s)
PSCCR Prospective Short Circuit Current Rating
SB® Storage Battery Connector
SBX® Storage Battery Connector with Auxiliary Contacts
sic “Thus it had been written”
SOC State of Charge
SOOW Cable type (Service), which features Oil-resistant insulation,
an Oil-resistant jacket, and is Water resistant
UL Underwriters Laboratories
VVolt(s)
VAC Volt(s) Alternating Current
VDC Volt(s) Direct Current
WWidth
WCSI Webasto Charging Systems, Inc.
ProCore Edge North AmericaIOMM
Webasto Charging Systems, Inc. 31241-03-02029 of 68
2. Required Tools
• Hex key, 4 mm, for the ller screws on the charger top panel
• TORX TX30 for the charger top panel
• Flathead screwdriver for the terminal screws
• TORX TX25 for the DC output power cable panel
3. Technical Specications for 48V and 80V Modules Fitted
with 3- or 5-Bay Cabinets
Technical Specications
Model ProCore Edge 9 ProCore Edge 9 ProCore Edge 15 ProCore Edge 15
Number of tted modules 23234545
Max. output power rating16 kW 9 kW 6.4 kW 9.6 kW 12 kW 15 kW 12.8 kW 16 kW
Module type 48V 80V 48V 80V
Nominal input voltage 480 VAC + 10% 3 ph. 50/60Hz
Cabinet size 3-bay 5-bay
Max. input amps (3-phase
480VAC) 9 A 14 A 9 A 14 A 19 A 24 A 19 A 24 A
Max. CB size215 A 20 A 15 A 20 A 25 A 30 A 25 A 30 A
Min. tted AC input
wire size (AWG) per NEC 14 12 14 12 10 10 10 10
Max. output amperage:
24-volt battery @ 2.4 V/cell 128 A 192 A ― ― 256 A 320 A ― ―
Max. output amperage:
36-volt battery @ 2.4 V/cell 128 A 192 A ― ― 256 A 320 A ― ―
1The number of modules and module type determine the maximum output power rating.
2The circuit breaker ratings (maximum CB size) should be based on the charger maximum input ratings (input amps) for
the number of tted modules as stated in this section.
ProCore Edge North America
31241-03-0202 Webasto Charging Systems, Inc.
IOMM
10 of 68
Model ProCore Edge 9 ProCore Edge 9 ProCore Edge 15 ProCore Edge 15
Number of tted modules 23234545
Max. output power rating16 kW 9 kW 6.4 kW 9.6 kW 12 kW 15 kW 12.8 kW 16 kW
Module type 48V 80V 48V 80V
Nominal input voltage 480 VAC + 10% 3 ph. 50/60Hz
Cabinet size 3-bay 5-bay
Max. output amperage:
48V battery @ 2.4 V/cell 104 A 156 A 80 A 120 A 208 A 260 A 160 A 200 A
Max. output amperage:
72V battery @ 2.4 V/cell ― ― 76 A 114 A ― ― 151 A 189 A
Max. output amperage:
80V battery @ 2.4 V/cell ― ― 69 A 104 A ― ― 139 A 173 A
Max. output amperage:
96V lithium-ion battery @
full charge
― ― 56 A 83 A ― ― 111 A 139 A
Min. DC output wire size
(AWG) 1/0 1/0 1/0 1/0 3/0 3/0 or 4/031/0 1/0
Protective class I
PSCCR max. (Icc) 3.6 kA
PSCCR min. (Icp, mr) 320 A
OCV II
Pollution degree 2
Efciency and power factor Efciency = 94% maximum
Power factor = 0.95 maximum
Output protection Short circuit protection
Reverse polarity protection
Dimensions (H×W×D) 18.6 in. × 21 in. × 14.7 in.
(473 mm × 534 mm × 374 mm)
24.8 in. × 21 in. × 14.7 in.
(631 mm × 534 mm × 374 mm)
Weight 51.8. (23.5 kg) without module
9.2 lb. (+4.2 kg) per module
64.8 lb. (29.4 kg) without module
9.2 lb. (+4.2 kg) per module
Installation Wall, stand, or oor mounting options
Environment Operating temperature: −20°C to +45°C (−4°F to 113°F)
Storage temperature: −25°C to +65°C (−13°F to 149°F)
Relative humidity 90%, non-condensing
Enclosure IP20, NEMA 1–only indoor use
Operating altitude Up to 3000 m (9843 ft)
Certications
CSA certied to UL1564, C22.2 107.2-01, and CEC
NOM-208-SCFI-2016
Technical Dictum for exemption of NOM-001-SCFI-2018.
3Stated output currents require connectors and electrical cables of adequate capacity.
Altri manuali per ProCore Edge 9
1
Questo manuale è adatto per i seguenti modelli
1
Indice
Lingue:
Altri manuali Webasto Caricabatterie per batterie
Webasto
Webasto Pure Manuale utente
Webasto
Webasto ProCore Edge Manuale di installazione e d'uso
Webasto
Webasto PosiCharge DVS 330 Manuale utente
Webasto
Webasto Live Manuale utente
Webasto
Webasto PosiCharge ProCore Guida all'installazione
Webasto
Webasto DVS100 Manuale utente
Webasto
Webasto Go Manuale utente
Webasto
Webasto Pure Manuale utente
Webasto
Webasto Live Manuale utente
Webasto
Webasto TurboConnect Manuale utente
Webasto
Webasto PosiCharge DVS 300 Manuale
Webasto
Webasto ProCore Edge 9 Manuale utente
Webasto
Webasto DVS100 Manuale utente
Webasto
Webasto Pure Manuale utente
Webasto
Webasto PosiCharge SVS100N Manuale utente
Webasto
Webasto Next Manuale utente
Webasto
Webasto Next Manuale utente
Webasto
Webasto Live Guida rapida
Webasto
Webasto TurboDX Manuale utente
Webasto
Webasto Unite Manuale utente
