- 3 -
GENERAL WARNINGS
READ and UNDERSTAND this manual completely before using 20 Ton Log Splitter.
Operator must read and understand all safety and warning information, operating instructions,
maintenance and storage instructions before operating this equipment. Failure to properly operate and
maintain the log splitter could result in serious injury to the operator or bystanders.
Operation Warnings
•Do not at any time carry passengers, sit or stand on the log splitter.
•Do not allow children to play on, stand upon or climb on the log splitter.
•Always inspect the log splitter before using to assure it is in good working condition.
•Replace or repair damaged or worn parts immediately.
•Always check and tighten hardware and assembled parts before operation.
•Do not exceed equipment maximum load capacity of 20 tons.
•Avoid large holes and ditches when towing the equipment.
•Always operate the log splitter on clear and level ground.
•Do not operate the log splitter at night, only during daylight hours.
•Always tow at reduce speed in rough terrain, along creeks, ditches and on hillsides.
•To avoid personal injury and/or equipment damage DO NOT EXCEED 45 MPH.
•Driving under 45 MPH on public roads, it is recommended using a “Slow Moving Vehicle” (SMV)
emblem or a “Speed Identification Symbol” (SIS). Signs are available at farm equipment dealers.
•Always refer to the vehicle owner’s manual for proper towing.
•Only tow with recommended vehicles.
•Always secure and lock the log splitter to the vehicle hitch before towing.
Crush and Cut Hazards
•Always keep hands and feet clear from moving parts while operating the equipment.
•Always clear and keep work area clean and free of debris when operating.
•Always wear safety gear, ear and eye protection, gloves and work boots when operating the log
splitter.
High Pressure Hydraulic Fluid Hazards
High fluid pressures and temperatures are developed in hydraulic log splitters. Hydraulic fluid escaping
through a pin-size hold opening can puncture skin and cause severe blood poisoning. Inspect hydraulic
system regularly for possible leaks. NEVER use your hand to check for leaks while the system is
pressurized. Seek medical attention immediately if injured by escaping fluid.
The warnings, cautions, and instructions outlined in this instruction manual cannot cover all
possible conditions or situations that may occur. It must be understood by the operator that
common sense and caution are factors which cannot be built into this product and must be
supplied by the operator.
This product can expose you to chemicals including lead and lead compounds which are known to
the State of California to cause cancer and birth defects or other reproductive harm. For more
information, go to www.P65Warnings.ca.gov
Assembly Is Required
This product requires assembly before use. See “Assembly” section for instructions. Because of the
weight and/or size of the log splitter, it is recommended that another adult be present to assist with the
assembly. INSPECT ALL COMPONENTS closely upon receipt to make sure no components are
missing or damaged.
