Zodiac PW-5m Manuale utente

PW

5M-7M-9M-11M

Ver. : 11/2011

H03579‐03.A1.SAVer.11/20111

Summary



Installation......................................................................................2



1.1General..............................................................................................................2

1.2Operatingconditions.........................................................................................3

1.3Installation.........................................................................................................3



Operation........................................................................................6



2.1TheControlPanel..............................................................................................6

2.2Checkstobeperformedbeforeoperatingtheappliance.................................7

2.3Startingtheappliance........................................................................................7

2.4Checkstoperformafteroperatingtheappliance.............................................7

2.5Winterizing........................................................................................................8



Maintenance...................................................................................8



3.1Maintenanceinstructions..................................................................................8

3.2Recyclingtheproduct........................................................................................9

3.3Additionalrecommendations............................................................................9



Errorcodes....................................................................................10



FAQ................................................................................................11



Technicalinformation....................................................................12



6.1Technicalspecifications...................................................................................12



Warranties.....................................................................................12



Registrationonline........................................................................14



Conformitycertificate....................................................................14



Pleasereadthismanualcarefullybeforeinstalling,maintainingorrepairingthis

appliance!Thesymbolindicatesimportantinformationthatmustbetakeninto

accountinordertoavoidriskofpersonalinjuryand/ordamagetotheappliance.The

symbolindicatesusefulinformation.

Aspartofourcontinuousimprovementpolicyourproductsmaybesubjecttochange

withoutnotice.

Availableintheappendixesattheendofthemanual:

- electricaldiagram

- dimensions

H03579‐03.A1.SAVer.11/20112

Installation



1.1General



1.1.1Caution



1.1.2Generaltermsofdelivery,storageandtransport

Anyequipment,includingcarriageandpackingfree,isshippedattherecipient’srisk.

Exclusiveuse:heatingswimmingpoolwater(notbeusedforanyother

application),

theproductmustbeinstalledbyaqualifiedtechnicianaccordingtothe

manufacturer’sinstructionsandincompliancewithlocalregulations.The

installerisresponsibleforthecorrectinstallationofthedeviceandalsofor

ensuringcompliancewithlocalregulationsinthisrespect.Themanufacturer

willnotbeheldresponsibleforanypotentialissuesthatmayariseduetofailure

tocomplywithlocalregulationspertainingtoinstallation,

incorrectinstallationmaycauseseriousdamageand/orpersonalinjuries

(possiblydeath),

thatthisdevicemustbehandledbycompetentandcapablepeople(physically

andmentally)whohavereceivedadequateinstructionsforuse(byreadingthe

userguideorasinstructedbytheinstaller).Personswhodonotsatisfythese

requirementsmustnothandletheappliancesoastoavoidexposureto

potentiallydangerousparts.

Intheeventofmalfunctiondonotattempttorepairtheapplianceyourself:call

yourretailer,

beforeworkingontheappliance,ensurethatthepowersupplyisdisconnected

andsecured,

Priortoanyoperation,checkthat:

- Thevoltageontheidentificationplateoftheappliancecorrespondstothe

mainvoltageavailableonsite,

- thesocketandthepowersuppliedareadaptedtothepowerrequirements

oftheheatpump,andthattheyaregrounded,

- theelectricalplugisadaptedtothesocketavailable.

eliminationorshuntingofoneofthesafetyleadsautomaticallytothe

cancellationoftheguarantee,asforthereplacementofpartsbynon‐original

parts,

Keeptheapplianceoutofthereachofchildren,

DonotventR410Aintotheatmosphere:R410Aisafluorinatedgreenhousegas,

coveredbytheKyotoProtocol,withaGlobalWarmingPotential(GWP)=1975‐

(DirectiveoftheEC842/2006).

H03579‐03.A1.SAVer.11/20113

Inthecaseofdamagecausedduringshippingtherecipientmustmentionany

reservationsinwritingonthecarrier'sdeliverynote(confirmationtobesenttothe

carrierwithin48hoursbyregisteredmailandAcknowledgementofReceipt).

Iftheappliancehasbeenturnedonitsside,mentionyourreservationsinwritingto

thecarrier.



1.1.3Contents



X1x2



1.2Operatingconditions

Operatingrange:



between7°Cand32°Cofairtemperature

between10°Cand32°Cofwatertemperature



1.3Installation



1.3.1Selectinganinstallationsite



theheatpumpmustbeinstalledataminimumdistancefromtheendofthepoolso

astoavoidexposuretowatersplashes.Theappropriatedistanceshouldbedefined

withreferencetothenationalelectricalstandardsthatapplyinthecountryof

installation.

Theheatpumpmustnotbeinstalled:

- nearaheatsourceornearinflammablegas,

- neararoadwithariskofwaterandmudsplashes,

- facingstrongwind,

- withtheventfacingtowardapermanentortemporaryobstacle(window,wall,

hedge,etc…),itmustbeatleast3metersfromsuch.



1.3.2Installingtheappliance

placeontoastable,solid(concreteslabtype)and

levelsurface,

protectfromrisksoffloodingduetocondensation

producedbytheappliancewhilstitisoperating.

Theappliancemustbeinstalledoutdoorsandtheremustbeadequateopenspace

surroundingit(see§1.3.3).

Donotpickuptheunitusingtheoutercasing,usethebasetoliftandmovethe

unit.

Fixingholes

H03579‐03.A1.SAVer.11/20114



1.3.3Hydraulicconnections



 



ConnectionsshouldbemadeusingØ50PVCpipe,gluingthepipeworkconnectorsto

theswimmingpoolfiltrationsystem,afterthefilterandbeforeanywatertreatment

system.Inordertoensurethewatertightnessbetweenthesejointsandtheheat

pump,wrapTeflontapearoundthethreadingofthewaterintakeandoutput.

Evenifthewaterflowislowerthan8m³/h,itisrecommendedthataby‐pass

installationbeused(valveVBclosed,valvesVEandVSopen)soastofacilitate

interventionsontheappliance.

Respectthedirectionofthehydraulicconnection(see§"Dimensions"inthe

appendix).

Itispossibletofixtheappliancetothegroundusingtheholesinthebaseofthe

applianceorusingfixingrails(notsupplied).Itisalsopossibletofixtheappliance

withbrackets(notsupplied).

Adrillingexplanationdiagramisavailableontherearofthepackagingbox.

*Minimumdistance

filter

watertreatment

by‐pass







Withoutby‐pass

Withby‐pass

(recommended)

H03579‐03.A1.SAVer.11/20115

Installingaby‐passismandatoryifthewaterflowishigherthan8m³/h,usevalveVBto

adjustthewaterflowandleavevalvesVEandVSopen.



PW5M 7M 9M 11M

Testpressurebar 6

Operatingpressurebar 1.5

HeadLossmCE 2.3 2.45 4.95 5

Minimumwaterflow‐ratem³/h 2

Averagewaterflow‐ratem³/h 3 4 5 5

Maximumwaterflow‐rate*m³/h 8

*thisflow‐ratemustnotbeexceeded



1.3.4Electricalconnections



theunitisdesignedforconnectiontoageneralpowersupplywithfullearthand

neutralorneutralearthsystems,

electricalprotection:bycircuit‐breaker(curveD)orfuse(Am),andwitha30mA

differentialtripswitchattheheadofthesupplyline(circuit‐breakerorswitch).



PW5M‐7M‐9M

connectthepowercordsuppliedwiththeappliancetoa16Asocketcomplyingwith

thestandardsandregulationsinforceinthecountrywhereitisinstalled,

extensioncordsandadaptersmustnotbeused,

Ifthepowersupplycableisnotlongenough,contactaqualifiedtechnician.



PW11

theelectricalsupplyoftheappliancemustcomefromaprotectionandswitching

device(notsupplied)complyingwiththestandardsandregulationsinforceinthe

country,

theelectricalsupplycablemustnotbeexposedtoelementsthataresharp,hotor

representacrushhazard,

checkthatallcablesaresecureandallterminalconnectionsarecorrect.



Looseterminalsmaycausethesupplyterminalboardtooverheat, andwillvoid

thewarranty.

Theappliancemustbeearthed.

Acceptabletolerancefortensionvariation:‐10%,+7%(whileoperating)

Riskofelectricalshockinsidethedevice.

Onlyafullyqualifiedandapprovedtechnicianshouldperformcabling

connectionsinsidetheappliance.

Ifthepowercableisdamageditmustbereplacedbyaqualifiedtechnician.

H03579‐03.A1.SAVer.11/20116

supplycablesection:forcablesofamaximumlengthof20metres(calculationbase:

5A/mm²),mustbecheckedandadapteddependingoninstallationconditions



PFPVoltage

Maximumcurrent

consumptionCablesectionElectricalprotection

Amm²  A

11M230V‐50Hz15.5 3x2.53G2.5 16



Operation

2.1TheControlPanel



SymbolDesignationNotflashingFlashing Of



waterflowWaterflowis

correct

Waterflowtolowor

nowaterflow/



HeatingactiveStartingupinactive



externalpump

(option)Refertothemanualoftheoptionalfeature



ambientair

temperatureSufficientinsufficient/

DefaultSee§4

“on/off”button



Buttonfordisplayingthetemperatureofthepoolwaterorforsetting

parameters

electricalconduitsmustbesecured,

usethestuffingboxtobringthesupplycableintotheappliance.

phase(L)+neutral(N)+Earth(PE)

H03579‐03.A1.SAVer.11/20117



SymbolDesignation NotflashingFlashing Of





settingvaluesbuttons



2.2Checkstobeperformedbeforeoperatingtheappliance

thehydraulicconnectionsmustbetight,

theunitmustbestable(aswellaslevelandupright),

theelectricalsupplycablemustnotbeexposedtosharporhotelementswhichcould

damageitorcrushit.



2.3Startingtheappliance

openthewatersupplyandadjustthevalves,ifany(see§1.3.3),

connecttheheatpumptothepowersupply:then,

toturnontheappliance:pressfor2secondson:

thenbydefaultthescreenwilldisplaytherequestedtemperature,

tosetthedesiredtemperature("requestedtemperature"):whentheheatpumpis

operating,pressonortosetthevalue.

It’spossibletoreadthewatertemperature:whenwaterisflowingthroughtheheat

pump,presson:flashesfor10secondsthendisplaysthe

fixedrequestedtemperature,

It’spossibletolockthekeyboard:

- lockthekeyboard:pressonandsimultaneouslyfor3seconds:

willbedisplayedfor3secondsthen:,

- unlockthekeyboard:pressonandsimultaneouslyfor3seconds:

willflashfor4secondsthen:,



2.4Checkstoperformafteroperatingtheappliance



Afterfollowingthestepsforrunningtheheatpump,temporarilycutthewater

circulationtocheckthattheheatpumpstopsoperating:thewater

flowdiodeshouldflash.



H03579‐03.A1.SAVer.11/20118

2.5Winterizing



switchofftheheatpumpbypressingthe buttonfor2seconds,thendisconnect

thepowercable,

ensurethatnowaterisflowingthroughtheheatpump,

drainthewatercondenser(riskoffreezing)byremovingthetwopoolwaterinletand

outletconnectionsatthebackoftheheatpump,

inthecaseofafullwinterizingofthepool:connecttheinletandoutletconnections

"lightly"withouttightening(oneturn)inordertoavoidforeignbodiesenteringinto

thecondenser,

inthecaseofwinterizingtheheatpumpalone:donotreconnecttheinletandoutlet

connectors,insteadplacetwostops(supplied)onthecondenserwaterinletand

outlet.



Maintenance



3.1Maintenanceinstructions





ensurethatnoforeignbodiesobstructthefangrid,

cleantheinsideoftheappliance,donotusesolvent‐basedcleaningproducts,

cleantheevaporator(forplacingsee§“Dimensions”inappendix)withasoftbrush

andafreshwaterhose(disconnectthepowercable),donottwistorbendthemetal

blades,

checkthecorrectoperationoftheregulator,

checkthatthecondensationisdrainedproperlywhilsttheapplianceisoperating.



Thefollowingoperationsmustbeperformedbyaqualifiedtechnician:

checkthecorrectworkingconditionofallsafetycomponents,

checkthatallmetalelementsareearthed,

checkthetighteningandconnectionsoftheelectriccablesandthecleanlinessofthe

electricalequipmentbox,

Ageneralservicingoftheapplianceisrecommendedbothwhenwinterizingand

whenrestartinginordertoensuretheproperoperationofyourheatpump,to

preserveitsperformanceandtopreventpotentialfailures.

Servicingcostswillbebornebytheuser.

Donotuseahigh‐pressurewaterhose.

Toavoiddamagingtheappliancewithcondensation,donotcoveritwithanair‐

tightcover.

Winterizingisessentialduetotheriskofthecondenserfreezing.Thissituationis

notcoveredbythewarranty.

H03579‐03.A1.SAVer.11/20119



3.2Recyclingtheproduct

Thissymbolmeansthattheequipmentmustnotthrowitintoyour

householdwaste.Itwillbecollectedselectivelysothatitcanbereused,

recycledorrecovered.Anysubstancesitmaycontainwhicharepotentially

dangeroustotheenvironmentwillbeeliminatedorneutralised.

Enquirewithyourretailerfortheconditionsthatapplytotherecyclingofyourproduct.



3.3Additionalrecommendations

InrelationwiththePressurisedEquipmentDirective(PED‐97/23/CE)



3.3.1Installationandmaintenance

theunitmaynotbeinstalledclosetocombustiblematerials,ortheairductinletof

anadjacentbuilding.

forcertainappliances,itisessentialtofitprotectiongridsiftheunitisinstalledinan

areawhichisunprotectedandeasilyaccessible.

duringinstallation,repairandmaintenancework,itisstrictlyprohibitedtostepon

pipesandhosesasthesecouldbreakandtheescapingrefrigerantcouldcause

seriousscalding.

whenservicingtheappliance,thecompositionandstateofheatcarryingfluidmust

bechecked,aswellastheabsenceofanyrefrigerant.

duringtheannualunitsealingtestinaccordancewithvalidlegislation,thehighand

lowpressureswitchesmustbecheckedtoensuretheyaresecurelyfastenedtothe

refrigerationcircuitandthattheyshut‐offtheelectricalcircuitwhentripped.

duringmaintenancework,ensuretherearenotracesofcorrosionoroilaround

refrigerationcomponents.

beforebeginningworkontherefrigerationcircuit,isolatetheapplianceandwait

severalminutesbeforeremovingthetemperatureorpressuresensors.Certain

elementssuchasthecompressorandassociatedpipingmayattaintemperaturesin

excessof100°Candhighpressureswiththeconsequentriskofseverescalding.



3.3.2Repair

allbrazingworkmustbecarriedoutbyaqualifiedbrazer/welder,

replacementpipesmustalwaysbemadeofcopperincompliancewithstandardNF

EN12735‐1.

leakdetection,pressuretest:

- neveruseoxygenordryair,riskoffireorexplosion,

- usedrynitrogenorthemixtureofnitrogenandrefrigerantindicatedonthename

plate,

- thetestpressureforboththehighandlowpressurecircuitsmustnotexceed42

bar.



Altri manuali per PW-5m

Indice

Altri manuali Zodiac Pompa di calore

Zodiac

Zodiac Z200 Guida

Zodiac

Zodiac Jandy Pro Series JE1500T Manuale utente

Zodiac

Zodiac PX 50 Manuale utente

Zodiac

Zodiac PF 6M-8M-11M-13M-15M Manuale utente

Zodiac

Zodiac Z250 MD3 Manuale utente

Zodiac

Zodiac POWER FORCE 25 Manuale utente

Zodiac

Zodiac PW-5m Manuale utente

Zodiac

Zodiac Z550iQ Manuale utente

Zodiac

Zodiac Z300 Series Manuale utente

Zodiac

Zodiac Jandy EE-Ti Manuale utente

Zodiac

Zodiac Pac Alpha 5M Manuale utente

Zodiac

Zodiac Edenpac 4D Manuale utente

Zodiac

Zodiac Z400 iQ Manuale utente

Zodiac

Zodiac iAquaLink Z400iQ Manuale utente

Zodiac

Zodiac AquaLink Z350iQ Manuale utente

Zodiac

Zodiac ZS500 Manuale utente

Zodiac

Zodiac PF Premium 6M Manuale utente

Zodiac

Zodiac POWER FORCE Series Manuale utente

Zodiac

Zodiac ZS500 MD5 Manuale utente

Zodiac

Zodiac Z900 TD20 Manuale utente

Zodiac

Zodiac PF 6M-8M-11M-13M-15M Manuale utente

Zodiac

Zodiac PW-5m Manuale utente

Zodiac

Zodiac PX 50 Manuale utente

Zodiac

Zodiac Z250iQ Manuale utente

Manuali Pompa di calore popolari di altre marche

MICROWELL

MICROWELL HP 1000 GREEN Manuale utente

Sanyo

Sanyo SAP120FCH Manuale utente

Daikin

Daikin EHYHBH05AA Manuale utente

Panasonic

Panasonic WH-SDF03E3E5 Guida

Bryant

Bryant 544B Manuale utente

Airxcel

Airxcel 45000 Series Manuale

Mitsubishi Electric

Mitsubishi Electric PUZ-SWM60VAA Manuale utente

Dimplex

Dimplex LI 16I-TUR Guida utente

Carrier

Carrier WSHP Open v3 Guida rapida alla configurazione

TGM

TGM CTV14CN018A Manuale utente

Carrier

Carrier 38MGQ Series Manuale utente

Kokido

Kokido K2O K880BX/EU Guida alla risoluzione dei problemi

Viessmann

Viessmann VITOCAL 300-G PRO Type BW 2150 Guida rapida

Carrier

Carrier 48EZN Manuale utente

Viessmann

Viessmann KWT Vitocal 350-G Pro Series Istruzioni operative

Ariston

Ariston NIMBUS Manuale utente

Weishaupt

Weishaupt WWP L 7 Guida utente

GE Zoneline AZ85H09EAC Manuale utente