Advantech IPC-602 Manuale utente

IPC-602

Industrial PC Chassis

All manuals and user guides at all-guides.com

all-guides.com

This document is copyrighted, July 1999, by Advantech Co., Ltd. All rights are reserved. Advantech

Co., Ltd. reserves the right to make improvements to the products described in this manual at any time

without notice.

No part of this manual may be reproduced, copied, translated, or transmitted in any form or by any

means without the prior written permission of Advantech Co., Ltd. Information provided in this

manual is intended to be accurate and reliable. However, Advantech Co., Ltd. assumes no responsibili-

ty for its use, nor for any infringements of the right of third parties which may result from such use.

Acknowledgments

IPC-602 and PCA-6106VP3 are trademarks of Advantech Co., Ltd.

Note: The information in this document is provided for reference only. Advantech does

not assume any liability arising out of the direct or indirect use of the information

or products described herein.This manual is subject to change without notice.

Part No. 2002060200

1st Edition Printed in Taiwan July 1999

All manuals and user guides at all-guides.com

Contents

Chapter 1 General Information..................................................... 1

1.1 Introduction .............................................................................................................. 1

1.2 Specifications .......................................................................................................... 1

1.3 Dimensions .............................................................................................................. 3

Chapter 2 System Setup ............................................................... 4

2.1 Removing the Cover ................................................................................................ 4

2.2 Adding Disk Drives .................................................................................................. 5

2.4 Replacing the Fan ................................................................................................... 6

2.3 Installing Plug-in Cards ............................................................................................ 6

2.5 Replacing the Filter .................................................................................................. 7

Appendix A Passive Backplane ................................................................................... 8

Appendix B Exploded Diagram .................................................................................... 9

Appendix C Parts Ordering Guide.............................................................................. 10

Appendix D Safety Instructions.................................................................................. 11

D.1 English ........................................................................................................................... 11

D 2 German - Wichtige Sicherheishinweise ......................................................................... 12

All manuals and user guides at all-guides.com

IPC-602 User's Manual

Chapter 1 General Information

1.1 Introduction

The IPC-602 is a compact rugged 19" 2U-height rackmount chassis designed for space-limited applica-

tion. With its rugged, sturdy and well-cooled steel chassis specially designed to withstand heavy

shocks and thick dust, the IPC-602 can be used in the harshest of environments. It is ideal for

low-density CT or network system configurations that require high availability within a limited space,

such as computer telephony and networking systems.

1.2 Specifications

Construction: Heavy-duty steel

Disk drive capacity: One 5.25" and two 3.5" drive bays

Indicators: LEDs for power On/Off, HDD and 3.3 V

Controls: Power On and Reset switches on front panel

Cooling fan: Two 42 CFM fans on front panel, with air filters

Weight: 9.8 kg (21.8 lbs)

Dimensions (W x D x H): 481.2 x 449.5 x 88 mm (19" x 17.7" x 4")

Interior paint color: Black 2U, 2X; Fabric Texture

Passive backplane (PCA-6106VP3)

Slots: 2 ISA / 3 PCI / 1 PICMG

PC board: 6-layer PCB with ground and power planes for reduced noise and low power-supply

impedance

Indicators: LEDs for +5 V, +12 V, -5 V, -12 V, +3.3 V

Power supply (PS-250X-DPS)

Output rating: 250 watts max.

Input rating: 90 ~ 135 Vac or 180 ~ 265 Vac @ 47 ~ 63 Hz, switchable

Output voltage: +5 V @ 25 A, +12 V @ 8 A, -5 V @ 0.5 A, -12 V @ 0.8 A, +3.3 V @ 14 A,

+5 VSB @ 1 A

Minimum load: +5 V @ 1.5 A, +12 V @ 0.2 A

MTBF: 100,000 hours @ 90% load

Safety: UL/TUV/Nordic approved

EMI: Meets FCC/VDC Class B

All manuals and user guides at all-guides.com

IPC-602 User's Manual

Power supply (PS-260)

Output rating: 260 watts max.

Input rating: 85 ~ 130 Vac or 180 ~ 260 Vac @ 47 ~ 63 Hz, switchable

Output voltage: +5 V @ 25 A, +12 V @ 9 A, -5 V @ 0.5 A, -12 V @ 2 A,

Minimum load: +5 V @ 1 A, +12 V @ 0.1 A

MTBF: 200,000 hours @ 70% load

Safety: UL/CSA/TUV approved

EMI: Meets FCC/VDE Class B

Power supply (PS-30XDC48-BPS)

Output rating: 300 watts max.

Input rating: -40 ~ 56 Vdc @ 47 ~ 63 Hz

Output voltage: +5 V @ 30 A, +12 V @ 12 A, -5 V @ 0.5 A, -12 V @ 1 A, +3.3 V @ 20 A,

+5 VSB @ 1.5 A

Minimum load: +5 V @ 3 A, +12 V @ 1 A

MTBF: 119,122 hours @ 75% load

Safety: UL/TUV

EMI: Meets FCC/VDC Class A

Environmental specifications

Operating temperature: 0 ~ 45° C (32 ~ 113° F)

Relative humidity: 10 ~ 95% @ 40° C, non-condensing

Safety: UL / CE approved

CE compliant

All manuals and user guides at all-guides.com

IPC-602 User's Manual

1.3 Dimensions

COMPACT

110V

RES ET

POW ER

3.3V

HDD

3.3V

POW ER

Unit: mm (inches)

All manuals and user guides at all-guides.com

all-guides.com

IPC-602 User's Manual

Chapter 2 System Setup

The following procedures are provided to assist you in installing drives and plug-in cards into the

IPC-602.

2.1 Removing the Cover

Unscrew the six screws on the front and rear panels , and then slide the cover toward the rear chassis.

See Figure 2-1 below:

Figure 2-1: Removing the cover

Step 1

Step 3

Step 2

All manuals and user guides at all-guides.com

IPC-602 User's Manual

2.2 Adding Disk Drives

After removing the cover, you can easily install disk drives. Refer to Figure 2-2 below and do the

following:

1. Remove the four outer screws which mount the drive bay to the chassis.

2. Slide the drive bay about 1 cm. toward the rear, to a location where it is not obstructed by the upper

rim. Lift it free of the chassis.

3. Remove the cover of the front drive bay, and insert the drives into their proper locations in the drive

bay.

Figure 2-2: Adding disk drives

All manuals and user guides at all-guides.com

IPC-602 User's Manual

2.3 Installing Plug-in Cards

After removing the cover, you can easily install plug-in cards. See Figure 2-3 below:

Figure 2-3: Installing plug-in cards

2.4 Replacing the Fan

Unscrew the two screws on the fan, and slide the cover toward the rear chassis. See Figure 2-4 below:

Figure 2-4: Replacing the fan

Step 1 Step 2

All manuals and user guides at all-guides.com

IPC-602 User's Manual

2.5 Replacing the Filter

The filter is located next to the lockable door. If the IPC-602 is under continuous use, the filter should

be changed about once a month. To replace the filter, refer to Figure 2-5 below and do the following:

1. Open the lockable door.

2. Remove the filter by gently pulling the tab and sliding the filter to the right.

3. Slide a new filter in until it snaps into place.

4. Close and lock the lockable door.

Figure 2-5: Replacing the filter

All manuals and user guides at all-guides.com

Altri manuali per IPC-602

Altri manuali Advantech Telaio

Advantech

Advantech IPC-7132 Manuale utente

Advantech

Advantech IPC-602 Manuale utente

Advantech

Advantech IPC-6806 Manuale utente

Advantech

Advantech ACP-5260 Manuale utente

Advantech

Advantech ITA-2000 Manuale utente

Advantech

Advantech IPC-613 Manuale utente

Advantech

Advantech IPC-3026 Manuale utente

Advantech

Advantech HPC-7120 Manuale utente

Advantech

Advantech PCE-5B06-00A1E Manuale di installazione e funzionamento

Advantech

Advantech IPC-616 Manuale utente

Advantech

Advantech HPC-8316 Series Manuale utente

Advantech

Advantech EPD-B101 Manuale utente

Advantech

Advantech ACK-A001E Manuale utente

Advantech

Advantech ACP-4340 Manuale utente

Advantech

Advantech IPC-631 Manuale utente

Advantech

Advantech ACP-4010 Manuale utente

Advantech

Advantech AIMB-B2000 Manuale utente

Advantech

Advantech HPC-7483 Manuale utente

Advantech

Advantech IPC-6025 Manuale utente

Advantech

Advantech PCA-6108P6 Manuale di installazione e funzionamento

Advantech

Advantech HPC-7484 Manuale utente

Advantech

Advantech HPC-8104 Manuale utente

Advantech

Advantech RMD-1150 Manuale utente

Advantech

Advantech ACP-7000 Manuale utente

Manuali Telaio popolari di altre marche

IMC Networks

IMC Networks iMcV/18 Manuale utente

Chenbro

Chenbro RB13804N4WFT Manuale utente

Lenovo

Lenovo ThinkSystem SR665 V3 Manuale utente

Wuntronic

Wuntronic PCI4DRQ Manuale utente

EtherWAN

EtherWAN EMC400 Manuale utente

Overland Storage

Overland Storage SnapSAN S1000 Guida

Philips

Philips LC4.1E A Manuale utente

Supermicro

Supermicro SCF418 Series Manuale utente

Chenbro

Chenbro RM437 Series Manuale utente

Pickering

Pickering 40-914 Manuale utente

HP A7503-S Istruzioni per il montaggio

Supermicro

Supermicro SC823MTQ-R700LPB Manuale utente

SilverStone

SilverStone RMS08 Series Manuale utente

NI cRIO-FRC II Manuale utente

Pickering

Pickering 65-200 Manuale utente

Allied Telesis

Allied Telesis AT-MMCR18 Manuale utente

Hisense

Hisense MSD6586 Manuale utente

Cisco

Cisco Nexus 7010 Manuale di istruzioni