Alliance Laundry Systems Drying Cabinet Manuale utente

Installation

www.comlaundry.com

Part No. 70304601R6

February 2008

Keep These Instructions for Future Reference.

(If this machine changes ownership, this manual must accompany machine.)

NOTA: Para bajar una

copia de estas

instrucciones en

español, visite

www.comlaundry.com.

Drying Tumblers

Stacked 30 Pound Capacity

Stacked 45 Pound Capacity

Starting Serial No. 0602004144

Refer to Page 4 for Model Identification

START

HIGH

TEMP

MED

TEMP

LOW

TEMP

HEAT

123

SELECT

TEMP

INSERT

COIN

PUSH

START

123

SELECT

TEMP

INSERT

COIN

PUSH

START

HIGH

TEMP

MED

TEMP

LOW

TEMP

HEAT

T477C

Installation must conform with local codes or in the absence of local codes with:

In the U.S.A.,installation must conform to the latest edition of the American National Standard Z223.1/

NFPA 54 “National Fuel Gas Code” and Standard ANSI/NFPA 70 “National Electric Code.”

In Canada, installation must comply with Standards CSA-B149.1 or Natural Gas and Propane Installation

Code and CSA C22.1, latest edition, Canadian Electric Code, Part I.

In Australia, installation must comply with the Australian Gas Association Installation Code for Gas

Burning Appliances and Equipment.

The following information applies to the state of

Massachusetts, USA.

•This appliance can only be installed by a

Massachusetts licensed plumber or gas fitter.

•This appliance must be installed with a 36

inch (91 cm) long flexible gas connector.

•A "T-Handle" type gas shut-off valve must be

installed in the gas supply line to this

appliance.

•This appliance must not be installed in a

bedroom or bathroom.

IMPORTANT: Information must be obtained from

a local gas supplier on instructions to be followed if

the user smells gas. These instructions must be

posted in a prominent location. Step-by-step

instructions of the above safety information must

be posted in a prominent location near the tumbler

for customer use.

FOR YOUR SAFETY, the information in this

manual must be followed to minimize the

risk of fire or explosion or to prevent

property damage, personal injury or death.

W033

WARNING

• Do not store or use gasoline or other

flammable vapors and liquids in the

vicinity of this or any other appliance.

• WHAT TO DO IF YOU SMELL GAS:

– Do not try to light any appliance.

– Do not touch any electrical switch; do

not use any phone in your building.

– Clear the room, building or area of all

occupants.

– Immediately call your gas supplier from

a neighbor’s phone. Follow the gas

supplier’s instructions.

– If you cannot reach your gas supplier,

call the fire department.

• Installation and service must be

performed by a qualified installer, service

agency or the gas supplier. W052

FOR YOUR SAFETY

Do not store or use gasoline or other

flammable vapors and liquids in the

vicinity of this or any other appliance. W053

POUR VOTRE SÉCURITÉ

Ne pas entreposer ou utiliser d’essence ou

toutes autres vapeurs et liquides

inflammables à proximité de cette unité ou

de tout autre appareil. W053R2QU

MISE EN GARDE

POUR VOTRE SÉCURITÉ, les informations

de ce guide doivent être respectées afin de

réduire les risques d’incendie, d’explosion

ou d’éviter les dommages matériels,

personnels ou blessures mortelles. W033R3QU

• Ne pas entreposer ou utiliser d’essence

ou toutes autres vapeurs et liquides

inflammables à proximité de cette

machine ou de tout autre appareil.

• QUE FAIRE EN CAS D’ODEUR DE GAZ :

– Ne pas mettre d’appareil en marche.

– Ne pas toucher aux interrupteurs

électriques ; ne pas utiliser le

téléphone des lieux.

– Évacuer la pièce, le bâtiment ou la zone

de tous les occupants.

– Appeler immédiatement le fournisseur

de gaz de la maison d’un voisin.

Respecter les instructions

communiquées par le fournisseur.

– Si vous ne pouvez pas joindre le

fournisseur de gaz, appeler le service

d’incendie.

• L’installation et l’entretien doivent être

effectués par un installateur, service

d’entretien qualifiés ou par le fournisseur

de gaz. W052R5QU

means without the expressed written consent of the publisher.

270304601© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

Table of

Contents

Introduction......................................................................................... 4

Model Identification ............................................................................. 4

Customer Service.................................................................................. 4

Wiring Diagram .................................................................................... 4

Serial Plate Location............................................................................. 5

Safety Information.............................................................................. 6

Explanation of Safety Messages........................................................... 6

Important Safety Instructions ............................................................... 7

Specifications and Dimensions........................................................... 9

Cabinet Dimensions.............................................................................. 10

Exhaust Outlet Locations...................................................................... 11

Gas Connection Locations.................................................................... 12

Electrical Connection Locations........................................................... 13

Steam Connection Locations ................................................................ 14

Installation........................................................................................... 15

Pre-Installation Inspection .................................................................... 15

Location Requirements......................................................................... 15

Position and Level the Tumbler............................................................ 17

Before Placing Tumbler into Service ................................................... 18

Required for CE Models Only ......................................................... 19

Installing CE Gas Drying Tumblers ..................................................... 19

General Information......................................................................... 19

Basic Configuration ......................................................................... 20

Specific Conversion Procedures ...................................................... 22

Exhaust Requirements ....................................................................... 24

Layout ................................................................................................... 24

Make-Up Air......................................................................................... 24

Venting ................................................................................................. 24

Individual Venting ........................................................................... 25

Manifold Venting............................................................................. 27

Gas Requirements............................................................................... 30

Gas Supply Pipe Sizing and Looping ................................................... 32

High Altitude Burner Orifice Sizing..................................................... 34

Electrical Requirements..................................................................... 35

Grounding Instructions ......................................................................... 35

For CE Models Only............................................................................. 35

Service/Ground Location...................................................................... 36

Connecting Electrical Service............................................................... 37

Configuring Your Tumbler for Other Service Voltages .................. 37

Electrical Connections ..................................................................... 37

Conversion Instructions ........................................................................ 38

Electrical Requirements for Gas and Steam Models ............................ 40

Electrical Requirements for Electric Models........................................ 42

70304601 3

Steam Requirements........................................................................... 43

Piping Recommendations ..................................................................... 43

Installing Steam Trap and Making Condensate

Return Connections ............................................................................ 44

Single Drop Timer .............................................................................. 46

Power-Up Mode.................................................................................... 46

Ready Mode.......................................................................................... 46

Start Mode ............................................................................................ 46

Run Mode ............................................................................................. 46

Setting Dry Time Dipswitches.............................................................. 46

Dipswitch Settings ................................................................................ 47

Adjustments......................................................................................... 49

Loading Door Switch............................................................................ 49

Airflow Switch...................................................................................... 49

Door Strike............................................................................................ 50

Removing Tumbler from Service...................................................... 51

Introduction

Model Identification

Information in this manual is applicable to these models:

Includes models with control suffixes:

Customer Service

If literature or replacement parts are required, contact

the source from which the machine was purchased or

contact Alliance Laundry Systems at (920) 748-3950

for the name and address of the nearest authorized

parts distributor.

For technical assistance, call (920) 748-3121.

Wiring Diagram

The wiring diagram is located in the upper junction or

upper contactor box.

The wiring diagram part number is located in the

lower portion of the electrical data on the serial plate.

Gas Steam Electric

T30

CHD30STG2-CAT30L

CHD30STG2-CAT30N

CHD30STG2-CTT30L

CHD30STG2-CTT30N

CHD30STG2-CUT30L

CHD30STG2-CUT30N

DRST30G2-BAT30L

DRST30G2-BAT30N

DRST30G2-BTT30L

DRST30G2-BTT30N

DRST30G2-BUT30L

DRST30G2-BUT30N

HAT30L

HAT30N

HTT30D

HTT30L

HTT30N

HUT30L

HUT30N

IPD30STG2-ITT30L

IPD30STG2-ITT30N

MTT30N

NTT30N

SAT30L

SAT30N

STT30D

STT30L

STT30N

SUT30L

SUT30N

UAT30L

UAT30N

UTT30L

UTT30N

UUT30L

UUT30N

CHD30STS2-CTT30S

CHD30STS2-CUT30S

DRST30S2-BTT30S

DRST30S2-BUT30S

HTT30S

HUT30S

IPD30STS2-ITT30S

STT30S

SUT30S

UTT30S

UUT30S

CHD30STE2-CTT30E

CHD30STE2-CUT30E

DRST30E2-BTT30E

DRST30E2-BUT30E

HTT30E

HUT30E

IPD30STE2-ITT30E

STT30E

SUT30E

UTT30E

UUT30E

T45

CTT45L

CTT45N

HTT45L

HTT45N

ITT45L

ITT45N

MTT45N

NTT45N

STT45L

STT45N

UTT45L

UTT45N

Not Applicable Not Applicable

3O– DX4 OPL BY– basic electronic, prep for card SD– single drop

3V– DX4 vended NC– NetMaster coin SX– single drop, prep for coin

3X– DX4 prep for coin NR– NetMaster card ZC– NetMaster network coin

BC– basic electronic, coin NX– NetMaster, prep for coin ZR– NetMaster network card

BL– basic electronic, central pay NY– NetMaster, prep for card ZX– NetMaster network, prep for coin

BX– basic electronic, prep for coin QT– dual digital timer ZY– NetMaster network, prep for card

Introduction

70304601

Serial Plate Location

When calling or writing for information about your

product, be sure to mention model and serial numbers.

Model and serial numbers are found on serial plate on

the rear of machine and inside door.

TMB1974N

1Serial Plate

Conversion Table

Multiply By To Obtain Multiply By To Obtain

Btu 0.252 kCal Pounds/sq. inch 0.06895 Bars

Btu 1055 Joules Pounds/sq. inch 0.070 kg/sq. cm

Inch 25.4 Millimeters Pounds (lbs.) 0.454 Kilograms

Inches W.C. 0.036 Pounds/sq. inch Boiler Horsepower 33,479 Btu/hr.

Inches W.C. 0.249 kPa Boiler Horsepower 34.5 lbs. steam/hr.

lb/inch2(psi) 6.895 kPa CFM 0.471 liters/second

ft328.32 Liters kW 3414 Btu/hr.

Safety Information

Explanation of Safety Messages

Precautionary statements (“DANGER,” “WARNING,”

and “CAUTION”), followed by specific instructions,

are found in this manual and on machine decals. These

precautions are intended for the personal safety of the

operator, user, servicer, and those maintaining the

machine.

Additional precautionary statements (“IMPORTANT”

and “NOTE”) are followed by specific instructions.

IMPORTANT: The word “IMPORTANT” is used

to inform the reader of specific procedures where

minor machine damage will occur if the procedure

is not followed.

NOTE: The word “NOTE” is used to communicate

installation, operation, maintenance or servicing

information that is important but not hazard

related.

NOTE: The WARNING and IMPORTANT

instructions appearing in this manual are not

meant to cover all possible conditions and

situations that may occur. It must be understood

that common sense, caution and carefulness are

factors which CANNOT be built into this tumbler.

These factors MUST BE supplied by the person(s)

installing, maintaining or operating the tumbler.

Always contact your dealer, distributor, service agent

or the manufacturer on any problems or conditions you

do not understand.

Indicates an imminently hazardous

situation that, if not avoided, will cause

severe personal injury or death.

DANGER

Indicates a hazardous situation that, if not

avoided, could cause severe personal

injury or death.

WARNING

Indicates a hazardous situation that, if not

avoided, may cause minor or moderate

personal injury or property damage.

CAUTION

Failure to install, maintain, and/or operate

this machine according to manufacturer’s

instructions may result in conditions which

can produce serious injury, death and/or

property damage. W051R1

WARNING

Safety Information

70304601

Important Safety Instructions

Save These Instructions

1. Read all instructions before using the tumbler.

2. Refer to the GROUNDING INSTRUCTIONS

for the proper grounding of the tumbler.

3. Do not dry articles that have been previously

cleaned in, washed in, soaked in, or spotted with

gasoline, dry cleaning solvents, other flammable

or explosive substances as they give off vapors

that could ignite or explode.

4. Do not allow children on or in the tumbler. This

appliance is not intended for use by young

children or infirm persons without supervision.

Young children should be supervised to ensure

that they do not play with the appliance.

5. Before the tumbler is removed from service or

discarded, remove the door to the drying

compartment and the door to the lint

compartment.

6. Do not reach into the tumbler if the cylinder is

revolving.

7. Do not install or store the tumbler where it will

be exposed to water and/or weather.

8. Do not tamper with the controls.

9. Do not repair or replace any part of the tumbler,

or attempt any servicing unless specifically

recommended in the user-maintenance

instructions or in published user-repair

instructions that you understand and have the

skills to carry out.

10. Do not use fabric softeners or products to

eliminate static unless recommended by the

manufacturer of the fabric softener or product.

11. To reduce the risk of fire, DO NOT DRY plastics

or articles containing foam rubber or similarly

textured rubberlike materials.

12. Always clean the lint filter daily.

13. Keep area around the exhaust opening and

adjacent surrounding area free from the

accumulation of lint, dust and dirt.

14. The interior of the tumbler and the exhaust duct

should be cleaned periodically by qualified

service personnel.

15. If not installed, operated and maintained in

accordance with the manufacturer’s instructions

or if there is damage to or mishandling of this

product’s components, use of this product could

expose you to substances in the fuel or from fuel

combustion which can cause death or serious

illness and which are known to the State of

California to cause cancer, birth defects or other

reproductive harm.

16. Tumbler will not operate with the loading door

open. DO NOT bypass the door safety switch to

permit the tumbler to operate with the door open.

The tumbler will stop tumbling when the door is

opened. Do not use the tumbler if it does not stop

tumbling when the door is opened or starts

tumbling without pressing or turning the START

mechanism. Remove the tumbler from use and

call for service.

17. Tumbler will not operate with lint panel open.

DO NOT bypass lint panel safety switch to

permit the tumbler to operate with the lint panel

open.

18. Do not put articles soiled with vegetable or cooking

oil in the tumbler, as these oils may not be

removed during washing. Due to the remaining

oil, the fabric may catch on fire by itself.

19. To reduce the risk of fire, DO NOT put clothes

which have traces of any flammable substances

such as machine oil, flammable chemicals,

thinner, etc. or anything containing wax or

chemicals such as in mops and cleaning cloths, or

anything dry-cleaned at home with dry-cleaning

solvent in the tumbler.

20. Use the tumbler only for its intended purpose,

drying fabrics.

21. ALWAYS disconnect and lockout the electrical

power to the tumbler before servicing. Disconnect

power by shutting off appropriate breaker or fuse.

22. Install this tumbler according to the

INSTALLATION INSTRUCTIONS. All

connections for electrical power, grounding, and

gas supply must comply with local codes and be

made by licensed personnel when required.

Hazardous Voltage. Can cause shock, burn

or cause death. Allow machine power to

remain off for two minutes prior to working

in and around AC inverter drive. W359

WARNING

Safety Information

70304601

23. Remove laundry immediately after tumbler stops.

24. Always read and follow manufacturer’s

instructions on packages of laundry and cleaning

aids. Heed all warnings or precautions. To reduce

the risk of poisoning or chemical burns, keep

them out of reach of children at all times

(preferably in a locked cabinet).

25. Do not tumble fiberglass curtains and draperies

unless the label says it can be done. If they are

dried, wipe out the cylinder with a damp cloth to

remove particles of fiberglass.

26. Always follow the fabric care instructions

supplied by the garment manufacturer.

27. Never operate the tumbler with any guards and/or

panels removed.

28. DO NOT operate the tumbler if it is smoking,

grinding, has missing or broken parts.

29. DO NOT bypass any safety devices.

30. Solvent vapors from dry-cleaning machines

create acids when drawn through the heater of the

drying unit. These acids are corrosive to the

tumbler as well as to the laundry load being

dried. Be sure make-up air is free of solvent

vapors.

31. Failure to install, maintain, and/or operate this

machine according to the manufacturer’s

instructions may result in conditions which can

produce bodily injury and/or property damage.

WARNING

To reduce the risk of serious injury, install

lockable door(s) to prevent public access

to rear of tumblers. W055

Questo manuale è adatto per i seguenti modelli

Indice

Altri manuali Alliance Laundry Systems Asciugatrice

Alliance Laundry Systems

Alliance Laundry Systems D310IE3B Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems 25 Series Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems DRY725C_SVG Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems ADE3TFWS431AW01 Istruzioni operative

Alliance Laundry Systems

Alliance Laundry Systems HSE117*C802 Istruzioni per il montaggio

Alliance Laundry Systems

Alliance Laundry Systems TMB1276C Manuale del proprietario

Alliance Laundry Systems

Alliance Laundry Systems ADG41F1 Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems LEB07A*-1709 Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems Speed Queen DR3003WG Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems TR3003WN Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems LES17A*M4588 Guida

Alliance Laundry Systems

Alliance Laundry Systems CA050L Istruzioni operative

Alliance Laundry Systems

Alliance Laundry Systems D0582 Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems ZE1010-1502 Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems T477C Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems UA025L Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems D715I Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems BDEBCAGS173TN01 Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems 512906 Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems SFG109*F Guida

Alliance Laundry Systems

Alliance Laundry Systems AT170FG Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems LTZ87A*H0902 Series Manuale utente

Alliance Laundry Systems

Alliance Laundry Systems DRY724C_SVG Guida

Alliance Laundry Systems

Alliance Laundry Systems SE5130 Istruzioni per il montaggio

Manuali Asciugatrice popolari di altre marche

Bosch

Bosch WTA79200GB Manuale utente

Amana

Amana W10233410A Manuale utente

Miele

Miele TWH 780 WP Manuale utente

Asko

Asko T760 Manuale utente

Bosch

Bosch Logixx 10 WTB76556GB Scheda tecnica

STIEBEL ELTRON

STIEBEL ELTRON Ultronic S Manuale di istruzioni

Electrolux

Electrolux EW2H328R2 Manuale utente

Beko

Beko DS8433RX1M Manuale utente

Dawlance

Dawlance Spinner DS 6000 C Manuale utente

Electrolux

Electrolux TP5080TW Manuale utente

AEG

AEG TR838P4OB Manuale utente

Indesit

Indesit IDV 75 Manuale utente

Infiniton

Infiniton SD-DG85C Manuale utente

BOMANN

BOMANN WT 5019 Manuale utente

Asko

Asko T793C Manuale utente

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer Manuale utente

Frigidaire

Frigidaire CAQE7077KW0 Manuale del proprietario

Bosch

Bosch WTX8HKM9SN Manuale utente