Carrier Integra 35X Manuale utente

Truck Refrigeration

Operator’s Manual

for

35X with Standby

40X & 50X

Truck Refrigeration Units

with Cab Command Two Controller

62-11045 Rev C

Operator’s Manual

for

35X with Standby

40X & 50X

Truck Refrigeration Units

with Cab Command Two Controller

©Carrier Corporation, 2018 - Printed in U. S. A. April 2018

Table of Contents Page

Introduction.................................................................1

Safety.....................................................................2

Unit Identification .......................................................3

Unit Operation............................................................5

Keypad and Display...................................................6

Additional Key Functions...........................................7

Starting - Engine Operation......................................8

Starting - Standby Operation....................................9

Changing Display Brightness.................................10

Temperature Setpoint..............................................11

Manual Defrost...................................................... 12

Defrost Parameters............................................... 13

Defrost Interval.........................................................14

Minimum/Maximum Setpoint, Out-of-Range

and Continuous Airflow...........................................15

Stopping Unit............................................................16

Product Loading.......................................................17

Recommended Transport Temperatures................18

Problems and Alarms............................................ 19

Alarm and Error Display..........................................20

Alarm List ................................................................21

Alarm Reset .............................................................22

Standby Operation Guidelines................................23

Fuses - 40/50X........................................................24

Fuses – 35X (Road Only)......................................25

Fuses – 35X (230/3/60)..........................................26

Fuses – 35X (230/1/60)..........................................27

Fuses – 35X (115/1/60) ..........................................28

Unit Maintenance.................................................. 31

Emergency Road Service ..................................... 30

Introduction

This guide has been prepared for the operator of Carrier Transicold

35X with Standby, and 40X and 50X Truck Refrigeration units with

Cab Command, Two Controller. It contains basic instructions for

the daily operation of the refrigeration unit as well as safety

information, and other information that will help you to deliver the

load in the best possible condition. Pleasetake thetime toread the

information contained in this booklet and refer to it whenever you

have a question about the operation of your Carrier Transicold

unit.

Your refrigeration unit has been engineered to provide long, trouble-

free performance when it is properly operated and maintained. A

comprehensive maintenance program will help to insure that the unit

continues to operate reliably. Such a maintenance program will also

help to control operating costs, increase the unit’s working life and

improve performance.

This guide is intended as an introduction to your unit and to provide

general assistance when needed. More comprehensive information

can be found in the Operation and Service Manual for your unit. This

manual can be obtained from your Carrier Transicold dealer.

When having your unit serviced, be sure to specify genuine Carrier

Transicold replacement parts for the highest quality and best reli-

ability.

At Carrier Transicold, we are continually working to improve the

products that we build for our customers. As a result, specifications

may change without notice.





Safety

Your Carrier Transicold refrigeration unit has been designed with

the safety of the operator in mind. During normal operation, all

moving parts are fully enclosed to help prevent injury. During all

pre-trip inspections, daily inspections, and problem

troubleshooting, you may be exposed to moving parts; please stay

clear of all moving parts when the unit is in operation.

WARNING

Beware of unannounced starting of the fans caused by

the thermostat and the start/stop cycling of the unit.

Refrigerants

The refrigerant contained in the refrigeration system of your unit

can cause frostbite, severe burns, or blindness when in direct

contact with the skin or eyes. For this reason, and because of

legislation regarding the handling of refrigerants during system

service, we recommend that whenever your unit requires service

of the refrigeration system you contact your nearest Carrier

Transicold authorized repair facility for service.

WARNING

Inspect battery cables for signs of wear, abrasion or

damage at every pretrip inspection and replace if

necessary. Also check battery cable routing to ensure that

clamps are secure and that cables are not pinched or

chafing against any components.

Emergency Switch (40/50X units only)

The unit can be completely

shut down manually by the

emergency switch inside the

frame of the condenser unit.

The emergency switch must

be in the on position to allow

the unit to restart with the

“ON” key of the cab

command.

Emergency Switch





Unit Identification

The unit is identified by a nameplate attached to the frame of the

unit. This nameplate identifies the complete model number of the

unit, the serial number, the type of refrigerant and charge, and the

date the unit was placed in service.

If a problem occurs, please refer to the information on this plate,

and make a note of the model and serial number before calling for

assistance. This information will be needed when you contact a

technician or Carrier Transicold Service Engineer so that they may

properly assist you. 40/50X Nameplate

35X Nameplate





A : Evaporator

B : Condenser

C: Cab control

D : Compressor mounting kit

E : Vehicle battery

F : Standby plug

G : Main road fuse





Altri manuali per Integra 35X

Questo manuale è adatto per i seguenti modelli

Indice

Altri manuali Carrier Frigorifero

Carrier

Carrier FV4B Manuale utente

Carrier

Carrier XtendFRESH Guida

Carrier

Carrier Integra 20X Manuale utente

Carrier

Carrier 69NT40-489-100 Series Manuale operativo

Carrier

Carrier Transicold Vector Multi-Temp Manuale utente

Carrier

Carrier 19DA Manuale di installazione

Carrier

Carrier XARIOS X150-04 Manuale utente

Carrier

Carrier 69NT40-561-019 Manuale operativo

Carrier

Carrier 69NT40-511-300 Manuale operativo

Carrier

Carrier BT30RF- EXPR Manuale utente

Carrier

Carrier Transicold Supra 550 Manuale utente

Carrier

Carrier WeatherMaker 50A020-060 Manuale utente

Carrier

Carrier 69NT40-541-505 Manuale operativo

Carrier

Carrier 69NT40-551-001 Manuale operativo

Carrier

Carrier GD60 Manuale utente

Carrier

Carrier ThinLINE 69NT40-541 Istruzioni per l'installazione

Carrier

Carrier Container Refrigeration Unit Manuale utente

Carrier

Carrier 40WAU Series Manuale utente

Carrier

Carrier NEOS 100S Istruzioni per l'installazione e il funzionamento

Carrier

Carrier Transicold 69NT40-561-001 Manuale operativo

Carrier

Carrier NaturaLINE 69NT40-601 Manuale utente

Carrier

Carrier 40RM Manuale operativo

Carrier

Carrier Streamline Scroll 69NT20-531-300 Manuale operativo

Carrier

Carrier 69NT40-511-1 Manuale operativo

Manuali Frigorifero popolari di altre marche

Bonnet Neve

Bonnet Neve SKYVIEW PLUS Manuale utente

Zanussi Electrolux

Zanussi Electrolux ZERB 8441 Manuale utente

Sharp

Sharp SJ-BA31IEXW2-EU Manuale utente

CORBERO

CORBERO CC2300MCW Manuale utente

KitchenAid

KitchenAid 2205264 Manuale utente

Stengel

Stengel KU 1101 A++ Manuale utente

NEFF

NEFF KI181 Series Manuale utente

Hoshizaki

Hoshizaki Reach-In Manuale utente

Amana

Amana ASD2524VES00 Manuale utente

BOMANN

BOMANN KGC 213 Manuale utente

Danby

Danby DAR044A1SLDD Istruzioni per il montaggio

Samsung

Samsung RF323TE Manuale utente

Beko

Beko CSA31022 Manuale utente

IKEA

IKEA FROSTIG C 185 E Manuale utente

Electrolux

Electrolux ER 6821 D Manuale utente

True

True TS-28 Manuale utente

Frigidaire

Frigidaire FSC23R5DW9 Manuale utente

Beko

Beko LSP4579W Manuale utente