Cornelius Liquid Base Beverage Dispenser Manuale utente

P/N 630460068

July 8, 1998

IMI Cornelius Inc; 1998

IMI CORNELIUS INC.

One Cornelius Place

Anoka, MN. 55303–6234

Telephone (612) 421–6120

Facsimile (612) 422–3232

INSTALLATION MANUAL

Liquid Base Beverage Dispenser

DRIP

TRAY

CUP

REST

FRONT

ACCESS PANEL

SUPPLY INLET

Design data

Width 10 3/4”

Height 21”

Depth 9 1/8”

Electrical Requirements:(if applicable)

15 Amp Circuit, 115v 60hz

.52 Amp Unit Current Draw

24v 60hz, Dispensing valves

Installation Check List :

Counter Top with access to route

concentrate supply lines.

15 Amp,115v60hz Outlet, Within 5’

(if applicable)

Cold Water Supply, With Shutoff

Overall Dimensions:

Weight: 12 lbs

24 VOLT

TRANSFORMER

(24 Volts) cord to

dispensing valves

RECEIVING

Each Unit is completely tested under operating conditions and thoroughly inspected before shipment. At time of

shipment, the carrier accepts the Unit and any claim for damage in transit must be made with the carrier. Upon

receiving Unit from the delivering carrier, carefully inspect the carton for visible indication of damage. Any dam-

age or irregularities should be noted at time of delivery (or not later than 15 days from date of delivery) and im-

mediately reported to the delivering carrier. Request a written inspection report from the Claims Inspector to

substantiate claim. File claim with the delivering carrier, not with IMI Cornelius Inc.

INSTALLATION

Place Unit in selected location to install unit.

Use mounting template (See page No. 3), to drill mounting holes for installing unit to counter top.

Liberally apply a sealant, such as Dow Corning RTV 731 or equivalent, to the unit flange bottom surface,per

(NSF) requirements, the unit must be sealed to the counter top.

Make connections as follows:

Plain Water Source Connections:

TO THE INSTALLER

It is the responsibility of the installer to ensure that the water supply to the dispensing equipment is

provided with protection against backflow by an air gap as defined in ANSI/ASME A112. 1.2-1979; or an

approved vacuum breaker or other such method as proved effective by test.

P/N 630460068

Water pipe connections and fixtures directly connected to a potable water supply shall be sized,

installed, and maintained according to Federal, State, and Local laws.

1. Flush plain water source thoroughly before connecting to Unit.

2. Connect plain water source to water inlet tube labeled ‘‘WATER’’.

Concentrate Line Connection:

1. Connect concentrate source lines to inlet lines from dispenser, labeled ‘‘1 or 2 etc’’. DO NOT CONNECT

SOURCE LINES TO CONCENTRATE AT THIS TIME.

Transformer Connections:(for electric valve units)

1. Connect Unit cord two-pin connector to the mating connector on the transformer output (24V) cord.

Steps of final installation:

1. Plug transformer into electrical outlet with proper electrical requirements.

2. Open shutoff valve in plain water source line.

3. Inspect connections for leaks.

4. Place a waste container under each nozzle and operate valve(s) to remove air from the plain water line.

5. Connect concentrate supply to concentrate system.

6. Open cylinder shutoff valve to apply the calculated pressure (approx. 40 PSI) to the concentrate system.

7. Operate each dispensing valve to remove air from the lines.

8. Check all lines for leaks.

9. Adjust Dispensing Valves for Water-To-Concentrate “Ratio”of dispensed drinks as instructed on ”BRIXING

VALVES”instructions.

NOTE: Concentrate system must be sanitized before Unit is put into operation. Refer to

Owner/Operator Manual for procedure.

10. Apply flavor decals to valve covers.

P/N 630460068

ONE SINGLE-FLAVOR

DISPENSING VALVE

ADJUSTABLE CONCENTRATE

FLOW REGULATOR

CONCENTRATE NO. ”2” IN

CONCENTRATE NO. ”1” IN

”WATER” IN

TWO SINGLE-FLAVOR

DISPENSING VALVES

”WATER” IN

CONCENTRATE NO. ”1” IN

CONCENTRATE NO. ”3” IN

CONCENTRATE NO. ”4” IN

TWO TWO-FLAVOR

DISPENSING VALVES

ADJUSTABLE WATER

FLOW REGULATOR

CONCENTRATE NO. ”2” IN

FLOW DIAGRAMS

”WATER” IN

CONCENTRATE NO. ”1” IN ”WATER” IN

”WATER” IN

Altri manuali per Liquid Base Beverage Dispenser

Indice

Altri manuali Cornelius Distributore di bevande

Cornelius

Cornelius Focus CG5052-0308 Manuale utente

Cornelius

Cornelius IDC 255 Manuale utente

Cornelius

Cornelius ENDURO-175 Manuale utente

Cornelius

Cornelius QUEST ELITE 4000 Manuale utente

Cornelius

Cornelius Enduro 150 8 Valve Manuale utente

Cornelius

Cornelius ENDURO-150 6 VALVE Manuale utente

Cornelius

Cornelius 2 Flavor Post-Mix Cold Coffee Dispenser Quest... Manuale utente

Cornelius

Cornelius C10 Manuale utente

Cornelius

Cornelius DF250 Manuale utente

Cornelius

Cornelius OLYMPUS Series Manuale utente

Cornelius

Cornelius VANGUARD 245 Manuale utente

Cornelius

Cornelius DF 250 BCP Manuale utente

Cornelius

Cornelius Drop-In Post-Mix Dispenser 2323 Universal Manuale utente

Cornelius

Cornelius The Profile PR150 BC Manuale utente

Cornelius

Cornelius A.B.S. Unit Manuale utente

Cornelius

Cornelius VANGUARD 245 Manuale utente

Cornelius

Cornelius ED Series Guida all'installazione

Cornelius

Cornelius JETSPRAY Guida alla configurazione

Cornelius

Cornelius TRIAD-150 Manuale utente

Cornelius

Cornelius TEA URN Manuale utente

Cornelius

Cornelius IDC 2 Series Manuale utente

Cornelius

Cornelius IDC PRO 255 Manuale utente

Cornelius

Cornelius IDC 2 Series Manuale utente

Cornelius

Cornelius ED 300 BC Manuale utente

Manuali Distributore di bevande popolari di altre marche

PEGAS

PEGAS Evolution Manuale utente

Ugolini

Ugolini MT micro Manuale utente

Bunn

Bunn SLCA-7 Istruzioni per l'installazione

Gekkeikan

Gekkeikan Sake Machine Manuale utente

Olympia

Olympia DH709 Manuale utente

Marco

Marco ECOSMART PB10 Manuale utente

Marvel

Marvel ML24BN Series Manuale

Cecilware

Cecilware 2K-GB-LD Manuale

Sure Vend

Sure Vend 673 Manuale utente

Nostalgia Electrics

Nostalgia Electrics KEG7000SS Manuale utente

Bunn

Bunn LCR-3 HV Guida alla risoluzione dei problemi

Servend

Servend SV-200 Manuale utente

EdgeStar

EdgeStar VBR440 Manuale utente

CDS AUTOMATEN

CDS AUTOMATEN ML-16C2-C Manuale utente

Siemens

Siemens GA 3000 Manuale di istruzioni e di sicurezza

Selbach

Selbach Fruit Juice dispenser Manuale utente

Taylor

Taylor C302NP Manuale utente

Vinotemp

Vinotemp VT-WINEDISP2 Manuale utente