Datamax W-Class Manuale utente

Maintenance Manual

CG Triumvirate is a trademark of Agfa Corporation.

CG Times, based upon Times New Roman under license from The Monotype Corporation.

Firmware (Software) Agreement:

The enclosed Firmware (Software) resident in the Printer is owned by Licensor or its suppliers and is licensed for use only

on a single printer in the user’s Trade or Business. The User agrees not to, and not to authorize or permit any other

person or party to, duplicate or copy the Firmware or the information contained in the non-volatile or

programmable memory. The firmware (Software) is protected by applicable copyright laws and Licensor retains all rights

not expressly granted. In no event will Licensor or its suppliers be liable for any damages or loss, including direct,

incidental, economic, special, or consequential damages, arising out of the use or inability to use the Firmware

(Software).

WARNING

Lithium Battery: There is a danger of explosion or fire if the battery is incorrectly replaced. Replace only

with the same or equivalent type recommended by the manufacturer. Discard used batteries according to

the manufacturer’s instructions.

Information in this document is subject to change without notice and does not represent a commitment on the part of

Datamax-O’Neil. No part of this manual may be reproduced or transmitted in any form or by any means, for any purpose

other than the purchaser's personal use, without the expressed written permission of Datamax-O’Neil.

Part Number 88-2322-01 Rev. G

Contents

1 Overview

2 Adjustments and Maintenance

3 Troubleshooting

4 Removal and Replacement

5 Printer Assemblies

Overview

1.0 Introduction...........................................................................................................1

1.1 About the Printer................................................................................................... 2

Overview

1-1

1.0 Introduction

This manual is intended for use by qualified service personnel in the maintenance and repair of W-Class

printers (hereafter referred to as ‘the printer’). It primarily includes technical information relating to the

printer’s electrical and mechanical components. If necessary, refer to the following documents for

additional printer information (available for download at http://www.datamax-oneil.com/):

For operating information, reference the Operator’s Manual, part number 88-2245-01.

For software language documentation, reference the Class Series Programmer’s Manual, part

number 88-2316-01.

Important Information:

The exclamation point inside an equilateral triangle is intended to alert the technician to

the presence of important operating, maintenance or servicing information. Always, as

with all electrical equipment, follow basic safety precautions to avoid personal injury or

printer damage.

Overview

1-2

1.1 About the Printer

The following drawing highlights the user-assessable components of the printer.

2Adjustments and Maintenance

2.0 Introduction...........................................................................................................1

2.1 Media Sensor Calibration ..................................................................................... 1

2.1.1 Quick Calibration .......................................................................................1

2.1.2 Standard Calibration..................................................................................2

2.1.3 Advanced Entry Calibration .......................................................................5

2.2 Printhead Adjustments .......................................................................................10

2.2.1 Leveling Cam Adjustment........................................................................ 10

2.2.2 Pressure Adjustment ...............................................................................12

2.2.3 Burn Line Adjustment...............................................................................13

2.2.4 Voltage Adjustment..................................................................................15

2.3 Ribbon Shield Adjustment .................................................................................. 18

2.4 Maintenance....................................................................................................... 20

2.4.1 Cleaning the Printhead ............................................................................ 21

2.4.1.1 Cotton Swab Procedure............................................................22

2.4.1.2 Cleaning Card Procedure..........................................................23

2.4.1.3 Cleaning Film Procedure........................................................... 24

2.4.2 Cleaning the Platen Roller....................................................................... 26

2.4.3 Cleaning the Media Sensor & the Media Path......................................... 27

2.4.4 Cleaning the Exterior Surfaces................................................................ 28

2.4.5 Cleaning the Cutter.................................................................................. 29

2.4.5.1 Light-Duty Cutter...................................................................... 29

2.4.5.2 Standard Cutter .......................................................................31

2.4.6 Cleaning the Fan Filter.............................................................................33

2.5 Application Version Updates............................................................................... 35

2.5.1 Updating from Ready Mode..................................................................... 35

2.5.2 Updating from Download Mode ...............................................................36

2.5.3 Possible Problems during an Update....................................................... 37

2.6 Boot Loader Program Updates........................................................................... 38

2.7 Resetting the Printer...........................................................................................39

2.7.1 Soft Reset................................................................................................39

2.7.2 Level One Reset...................................................................................... 39

2.7.3 Level Two Reset...................................................................................... 39

Indice

Altri manuali Datamax Stampante

Datamax

Datamax MP-Compact4 Manuale utente

Datamax

Datamax ST-3210 Manuale utente

Datamax

Datamax A-Class A-4310 Manuale operativo e di manutenzione

Datamax

Datamax OC2 BT Guida

Datamax

Datamax Performance series Manuale utente

Datamax

Datamax S2000i Manuale utente

Datamax

Datamax M-Class Mark II M-4206 Manuale utente

Datamax

Datamax Mark II Manuale utente

Datamax

Datamax W-6208 Manuale utente

Datamax

Datamax ST-3210 Manuale utente

Datamax

Datamax M-Class Mark II Manuale utente

Datamax

Datamax I-Class Manuale utente

Datamax

Datamax E-class E-3202 Manuale utente

Datamax

Datamax Apex 3 Manuale utente

Datamax

Datamax DMX E E-4204 Manuale utente

Datamax

Datamax MP-Compact4 Manuale

Datamax

Datamax ?-class series Manuale utente

Datamax

Datamax MICROFLASH 4T Manuale utente

Datamax

Datamax W-6208 Manuale utente

Datamax

Datamax E-Class Mark III MPU-4000 Manuale utente

Datamax

Datamax PRINTPAD MC70 Manuale utente

Datamax

Datamax H-Class Manuale utente

Datamax

Datamax I-Class Mark II Manuale utente

Datamax

Datamax 88-2312-01 Manuale utente

Manuali Stampante popolari di altre marche

Lexmark

Lexmark 1400 Series Manuale

Canon

Canon i70 Series Manuale utente

Evolis

Evolis Elypso Manuale utente

Kyocera

Kyocera FS-9530DN Manuale utente

Canon

Canon LASER SHOT LBP-1210 Manuale utente

Samsung

Samsung BIXOLON SRP-350plusF Manuale utente

Canon

Canon PIXMA PRO-1 Series Manuale utente

Canon

Canon PIXMA G3560 Guida all'installazione

Dell

Dell Color Laser Printer 2130cn Manuale utente

Tektronix

Tektronix Phaser 840 Manuale utente

Epson

Epson ET-7750 Istruzioni operative

Canon

Canon CLBR 460ps Manuale utente

Eltron

Eltron P210 Guide Manuale utente

Ricoh

Ricoh MD-P1 Manuale utente

Epson

Epson SC-F7100 series Manuale utente

Epson

Epson Stylus C40UX Manuale utente

Canon

Canon imagePASS-A2 Manuale utente

Canon

Canon S820D Manuale utente