Extech Instruments IR255 Manuale utente



USERGUIDE



MiniInfraRedThermometer

WithLaserPointerandHigh‐LowAlarms



ModelIR255



EXTECHINSTRUMENTS

2IR255‐en‐EU_V1.49/14

Introduction

CongratulationsonyourpurchaseoftheIR255IRThermometer.Thisthermometermakesnon‐

contact(infrared)temperaturemeasurementsatthetouchofabutton.Thebuilt‐inlaserpointer

increasestargetaccuracywhilethebacklitLCDandhandypush‐buttonscombineforconvenient,

ergonomicoperation.Thisdeviceisshippedfullytestedandcalibratedand,withproperuse,will

provideyearsofreliableservice.Pleasevisitourwebsite(www.extech.com)tocheckforthe

latestversionofthisUserGuide,ProductUpdates,andCustomerSupport.

Features

Measuresnon‐contactsurfacetemperatureupto400°C(752°F)

12:1DistancetoSpotRatio(FieldofView)

Single‐pointlasertargeting

AutomaticDataHoldwhentriggerisreleased

DisplayBacklight

Maximum‐Minimumtemperaturefunction

Selectabletemperatureunits(°C/°F)

Dynamicbatterystatusindication

Adjustableemissivity

AudibleandvisiblealarmindicationforHighandLowTemperatureAlarm

Safety

InternationalSafetySymbols

Thissymbol,adjacenttoanothersymbolorterminal,indicatestheusermustrefertothemanualfor

furtherinformation

Warnings

oDonotdirectlyorindirectlypointthelaserattheeyesofapersonorananimal

oInspectfordamageorforanyshortageofpartsoraccessoriesbeforeuse

oReplacethebatteryimmediatelyafterthebatteryindicatorflashes

oDonotusethethermometernearexplosivegases,steam,ordust

oNotethatanobjectwithhighreflectivitywillnormallycausethemeasuredtemperaturevaluetoread

muchlowerthantheactualtemperature

oUsethedeviceonlyasdescribedinthisUserGuide

Cautions

Toavoidthermometerdamage,pleaseavoidthefollowinghazards:

oEMFfromweldingequipmentorelectro‐inductionheaters

oStaticelectricity

oThermalshockcausedbylargeorabruptenvironmentaltemperaturechanges;wait30minutesto

allowthethermometertostabilizetonewenvironmentalconditions

oDonotusethisdeviceinexcessivelyhightemperatureenvironments



EXTECHINSTRUMENTS

3IR255‐en‐EU_V1.49/14

Description



MeterDescription

1. LCDDisplay

2. SETButton

3. MAX‐MIN/DownArrowButton

4. Laserpointerlens

5. IRThermometerlens

6. Backlight‐LaserPointer/UpArrowButton

7. MeasurementScanTrigger

8. BatteryCompartment

DisplayDescription

Emissivityvalueindication

Laserpointeractiveicon



Scanmode(activewhilethetriggerispulled;displayed

temperaturetracksthetemperatureofthescannedsurfaces)

Holdmode(displayedtemperaturefreezeswithtriggerrelease)

Maximum/Minimumtemperatureicons

Batterycapacityindicator(flasheswhenbatteryvoltageiscritical)

DisplayBacklighticon

Temperatureunits(°F/°C)

TemperatureAlarmiconsandaudiblealarmdisableicon

EXTECHINSTRUMENTS

4IR255‐en‐EU_V1.49/14

Operation

MeterPower

Themeterispoweredbyone9Vbattery.Withafreshbatteryinstalled,themeterswitchesON

whenthetriggerispulled.Thebatteryislocatedinthemeterhandle;pullthebattery

compartmentlidawayfromthebodyofthemetertoopen.RefertotheMaintenancesection

formoreBatteryInstallationinstructions.Thebatteryiconprovidesbatterystatusindication.

Replacethe9Vbatteryassoonasthebatterystatusiconflashes.

SurfaceTemperatureMeasurements

1. HoldthemeterbyitsHandleGripandpointittowardthesurfacetobemeasured.Readthe

FieldofViewsectionbelowfordistancetotarget(spot)ratioinformation.

2. PullandholdtheTriggertoturnthemeteronandbegintestinginScanmode.Thedisplay

willlightifthe9Vbatteryisgood.Replacethebatteryifthedisplaydoesnotlight.

3. WhilecontinuingtopulltheTrigger:

a. PushthebuttontoswitchthelaserpointerON.WhenthelaserisON,thelaser

icon willappearontheLCD.Aimtheredlaserbeamapproximatelyahalfinchbelow

thepointoftest(pressingtheLaserbuttonagainturnsthelaseroff).

b. Selectthetemperatureunits(oC/oF)intheSettingsMode(seelatersection).

c. PushthebuttontoswitchONtheLCDbacklightingfunction.

4. ReleasetheTrigger;thereadingwillholdforapproximately9seconds,afterwhichthemeter

willautomaticallyshutoff.

5. Themeterdefaultstotheprogrammedconditionsinusewhenthemeterwaslastswitched

OFF.Forexample,ifthelaserissettoONandthetemperatureunitsaresettooFatthetime

theunitisswitchedOFF,theunitwillswitchONandusethesamesettings.

Over‐rangeIndicators(OLand‐OL)

Ifthetemperaturemeasurementexceeds400°C(752°F),thethermometerwilldisplayOLin

placeofatemperaturereading.Ifthetemperaturemeasurementisbelow‐20°C(‐4°F),the

thermometerwilldisplay‐OLinplaceofatemperaturereading.

MAX‐MINMode

PresstheMAX‐MINbuttontoviewthemaximumtemperaturereading(MAX),pressagainto

viewthelowestreading(MIN).PressagaintoswitchtheMAX‐MINmodeoff.

DisplayBacklight

Pressthebacklightbutton toswitchthebacklightON.Thebacklightwillswitch

OFFautomaticallyafterseveralsecondstoconservebatterypower.



EXTECHINSTRUMENTS

5IR255‐en‐EU_V1.49/14

SettingMode

PresstheSETbuttontoaccesstheSettingMode.Usetheupanddownbuttonstonavigatethe

SettingModemenuandtomakechanges.Theavailableparametersarelistedbelow:

Emissivitysetting

°C/°Ftemperatureunitsselection

TemperatureAlarmAudibleBeeperEnable/Disable

HighTemperatureAlarmLimitsetting

LowTemperatureAlarmLimitsetting

Thecorrespondingparametericonwillflashwhenselected.ToexittheSettingMode,press

andholdtheSETbuttonfortwoseconds.

EmissivitySetting

Theiconwillflashwhenselected.Usetheupanddownbuttonstoincreaseordecreasethe

emissivity(in0.01steps).Theemissivityrangeis0.10to1.00.Holddowntheupordown

buttontorapidlyincreaseordecreasetheemissivityvalue.PresstheSETbuttontoconfirm

andtosteptothenextoption.

SelectingtheTemperatureUnitofMeasure(°C/°F)

Usetheupanddownbuttonstoselect°Cor°F.PresstheSETbuttontoconfirmandtostepto

thenextoption.

Enable/DisableAudibleTemperatureAlarm

Thisparameterisusedtoenable/disabletheaudibletemperaturealarm.The iconwillflash

inthismode.

Usetheupanddownbuttonstotogglethesetting.Whentheaudiblealarmisdisabled,the

displaywillshow‘HIGHLOW’.Whentheaudiblealarmisenabled,thedisplaywillshow

.Whentheaudiblealarmisenabled,thebeeperisallowedtosoundwhenever

themeasuredtemperaturegoesbeyondthehighorlowtemperaturelimitvalues.Pressthe

SETbuttontoconfirmandtosteptothenextoption.

HIGHTemperatureAlarmLimitSetting

UsetheupanddownbuttonstoincreaseordecreasetheHighAlarmTemperatureLimit(in

0.1steps).HoldingdowntheupordownbuttonwillrapidlyincreaseordecreasetheHIGH

limitvalue.AbeepwillsoundiftheHIGHtemperaturevaluereachestheLOWtemperature

valuewhileprogramming.PresstheSETbuttontoconfirmandtosteptothenextoption.

LOWTemperatureAlarmLimitSetting

UsetheupandownbuttonstoincreaseordecreasetheLowAlarmTemperatureLimit(in0.1

steps).HoldingdowntheupordownbuttonwillrapidlyincreaseordecreasetheLOWlimit

value.AbeepwillsoundiftheLOWtemperaturevaluereachestheHIGHtemperaturevalue

whileprogramming.PresstheSETbuttontoconfirmandtosteptothenextoption.

EXTECHINSTRUMENTS

6IR255‐en‐EU_V1.49/14

LocatingHotorColdSpots

Todetectahotorcoldspot,aimthethermometerataregionbeyondthetargetandthenscan

theentireregioninaslow,up/downmotion.



DistancetoSpotRatio(FieldofView)

Themeter’sfieldofviewis12:1(distancetospotratio).Forexample,ifthemeteris600mm

fromthetarget(spot),thediameterofthetargetmustbeatleast50mm.Otherdistancesare

shownbelowinthefieldofviewdiagram.

Notethatmeasurementsshouldnormallybemadecloserthan1200mmfromthetarget.The

metercanmeasurefromfurtherdistancesbutthemeasurementmaybeaffectedbyexternal

sourcesoflight.Inaddition,thespotsizemaybesolargethatitencompassessurfaceareasnot

intendedtobemeasured.



Itisnecessarytoensurethatthesizeofthetargetislargerthanthespotsize.Thesmallerthe

target,thecloserthedistanceshouldbe.Seetheaccompanyingdiagram.



Emissivity

Emissivityrepresentstheenergyreflectivityofamaterial.Mostorganicmaterialsandpainted

oroxidizedsurfaceshaveanemissivityofapproximately0.95.Ifpossible,maskingtapeorflat

blackpaintshouldbeappliedtocoverthemeasuredsurface.

Waitaperiodoftimetoallowthetapeorpainttoreachthermalequilibriumwiththesurface

ofthecoveredobject.Measurethetemperatureofthesurfacecoveredwithtapeorpaintonly

afterequilibriumhasbeenachieved.

EXTECHINSTRUMENTS

7IR255‐en‐EU_V1.49/14

MeasurementNotes

1. Theobjectundertestshouldbelargerthanthespot(target)sizecalculatedbythefieldof

viewdiagram.

2. Ifthesurfaceoftheobjectundertestiscoveredwithfrost,oil,grime,etc.,cleanbefore

takingmeasurements.

3. Ifanobject'ssurfaceishighlyreflectiveapplymaskingtapeorflatblackpainttothesurface

beforemeasuring.

4. Themetermaynotmakeaccuratemeasurementsthroughtransparentsurfacessuchas

glass.

5. Steam,dust,smoke,etc.canobscuremeasurements.

6. Themetercompensatesfordeviationsinambienttemperature.Itcan,however,takeupto

30minutesforthemetertoadjusttoextremelywideambienttemperaturechanges.

7. Tofindahotspot,aimthemeteroutsidetheareaofinterestthenscanacross(inanupand

downmotion)untilthehotspotislocated.

Maintenance

Cleaning

Tocleanthelensesusecompressedairtocleardustandotherparticles,thencarefullyclean

withawetcottonswab.Thecottonswabshouldbemoistenedwithcleanwater.

Tocleanthemeterhousing,wipewithadamp,softcloth.Donotusesolventsorabrasives.Do

notimmersetheIR255inwaterorotherliquid.

Troubleshooting

SymptomProblemAction

OLdisplayTargettemperatureexceedsrangeSelectatargetwithinrange

‐OLdisplayTargettemperatureunder‐rangeSelectatargetwithinrange

BatteryiconflashesLowBatterypowerReplaceBattery

BlankdisplayscreenLowbatterypowerCheckand/orreplacebattery

NoLaserpointerLowbatteryorenvironmental

temperaturehigherthan40°C(104°F)

Replacethebatteryormovethe

IR255toanareawithalower

ambienttemperature

EXTECHINSTRUMENTS

8IR255‐en‐EU_V1.49/14

ReplacingBatteries

Whenthebatteryiconflashes,orwhenthemeterdoesn’tswitchON,replacethebatteries.

Thebatterycompartmentislocatedinthehandlegrip.Thebatterycompartmentlidislocated

justbelowthetrigger.Prythecompartmentlidofftoreachthecompartment.

Replacethe9Vbatteryfollowingcorrectpolarityandthenclosethebatterycompartmentlid.

Batterysafetynotes:

oRemovethebatteryifthedeviceistobestoredforlongerthan60days

oNeverdisposeofbatteriesinafire.Batteriesmayexplodeorleak

oNevermixbatterytypes.Alwaysinstallnewbatteriesofthesametype



Neverdisposeofusedbatteriesorrechargeablebatteriesinhouseholdwaste.

Asconsumers,usersarelegallyrequiredtotakeusedbatteriestoappropriate

collectionsites,theretailstorewherethebatterieswerepurchased,orwherever

batteriesaresold.

Disposal:Donotdisposeofthisinstrumentinhouseholdwaste.Theuseris

obligatedtotakeend‐of‐lifedevicestoadesignatedcollectionpointforthe

disposalofelectricalandelectronicequipment.



EXTECHINSTRUMENTS

9IR255‐en‐EU_V1.49/14

Specifications

InfraredThermometerSpecifications

Range/Resolution‐20to400oC(‐4to752oF)

Accuracy±2°C(3.6°F)or2%ofreading(whicheverisgreater)

Note:Accuracyisspecifiedforthefollowingambient

temperaturerange:21to25°C(70to77°F)

EmissivityAdjustablefrom0.10to1.00

FieldofViewD/S=Approx.12:1ratio(D=distance,S=spot)

LaserpowerLessthan1mW

Spectralresponse630to670nm(wavelength)

GeneralSpecifications

Display 1999count,backlitLCDdisplaywithfunctionindicators

Displayrate250msapprox.

OperatingTemperature 0°Cto40°C(32°Fto104°F)

OperatingHumidityMax.75%RH

PowerSupply9Vbattery

AutomaticPowerOffMetershutsoffautomaticallyafter9seconds

Weight 140g(4.0oz.)

Dimensions165x85x40mm(6.5x3.3x1.6”)



Allrightsreservedincludingtherightofreproductioninwholeorinpartinanyform

www.extech.com

Indice

Altri manuali Extech Instruments Termometro

Extech Instruments

Extech Instruments SDL200-NIST Manuale utente

Extech Instruments

Extech Instruments IR267 Manuale utente

Extech Instruments

Extech Instruments EA11 Manuale utente

Extech Instruments

Extech Instruments IR400 Manuale utente

Extech Instruments

Extech Instruments SDL500 Manuale utente

Extech Instruments

Extech Instruments 42555 Manuale utente

Extech Instruments

Extech Instruments K.J.E.T. 422324 Manuale utente

Extech Instruments

Extech Instruments 392050 Manuale utente

Extech Instruments

Extech Instruments 42570 Manuale utente

Extech Instruments

Extech Instruments 42545 Manuale utente

Extech Instruments

Extech Instruments 42512 Manuale utente

Extech Instruments

Extech Instruments IR100 Manuale utente

Extech Instruments

Extech Instruments VIR50 Manuale utente

Extech Instruments

Extech Instruments EzSmart RHT3 Manuale utente

Extech Instruments

Extech Instruments 42545A Manuale utente

Extech Instruments

Extech Instruments IR400 Manuale utente

Extech Instruments

Extech Instruments RHT510 Manuale utente

Extech Instruments

Extech Instruments AN500 Manuale utente

Extech Instruments

Extech Instruments 42570 Manuale utente

Extech Instruments

Extech Instruments 42570 Manuale utente

Extech Instruments

Extech Instruments RH250W Manuale utente

Extech Instruments

Extech Instruments 42540 Manuale utente

Extech Instruments

Extech Instruments 42510 Manuale utente

Extech Instruments

Extech Instruments RH200W Manuale utente

Manuali Termometro popolari di altre marche

Delton

Delton 981A Manuale utente

Baker

Baker MM2P Manuale utente

Tarmo

Tarmo 320281 Manuale utente

Citizen

Citizen CTD 504 Manuale utente

TFA

TFA 14.1500 Manuale utente

Vive

Vive DMD1010 Manuale utente

Gotemp

Gotemp THB4002 Manuale utente

GREISINGER

GREISINGER G 1202 Manuale utente

Amprobe

Amprobe TMD-53W Manuale utente

Trotec

Trotec BP10 Manuale utente

Radiance instruments

Radiance instruments RT616 Series Manuale utente

Eurolec

Eurolec IR151 Manuale utente

Scaneo

Scaneo TS42B Manuale utente

Sper scientific

Sper scientific 800043 Manuale utente

Microlife

Microlife NC 200 Manuale di istruzioni

Motorola

Motorola MBP69SN Guida alla configurazione

The MeatStick

The MeatStick The MeatStick Manuale utente

Hama

Hama TH35-A Manuale utente